A micromachined thermoelectric sensor for natural gas analysis: Thermal model and experimental results

In this work, the potential use of a micromachined thermopile based device for analyzing natural gas is explored. Device's response is studied to attain the final goal of detecting variations in natural gas composition through the variation of its thermal conductivity. A FEM thermal model of the device is developed and used to simulate its thermal operation and estimate its sensitivity. Different responses have been recorded experimentally and compared with those obtained from the model developed, showing a good agreement. Results show that small variations in the gas mixture composition can be clearly detected.

[1]  John L. Crassidis,et al.  Sensors and actuators , 2005, Conference on Electron Devices, 2005 Spanish.

[2]  Oliver Paul,et al.  Test structures to measure the Seebeck coefficient of CMOS IC polysilicon , 1997 .

[3]  C. Schick,et al.  Temperature distribution in a thin-film chip utilized for advanced nanocalorimetry , 2005 .

[4]  O. Brand,et al.  Micromachined thermally based CMOS microsensors , 1998, Proc. IEEE.

[5]  H. Bogaard,et al.  Rapid method for the determination of the composition of natural gas by gas chromatography , 1975 .

[6]  Mohand Tazerout,et al.  Knock rating of gaseous fuels in a single cylinder spark ignition engine , 2004 .

[7]  R. Tye,et al.  thermal conductivity , 2019 .

[8]  Kuan Chen,et al.  Fabrication and characterization of thermal conductivity detectors (TCDs) of different flow channel and heater designs , 2002 .

[9]  J. Ely,et al.  Thermophysical Properties of Fluids. II. Methane, Ethane, Propane, Isobutane, and Normal Butane , 1987 .

[10]  Carles Cané,et al.  Assessment of the final metrological characteristics of a MOEMS-based NDIR spectrometer through system modeling and data processing , 2003 .

[11]  Peter Ulbig,et al.  Determination of the calorific value of natural gas by different methods , 2002 .

[12]  Jun Zhang,et al.  Thermal convection with a freely moving top boundary , 2005 .

[13]  M. Boutchich,et al.  Characterization of phosphorus and boron heavily doped LPCVD polysilicon films in the temperature range 293-373 K , 2002, IEEE Electron Device Letters.

[14]  K. Stephan,et al.  The Thermal Conductivity of Fluid Air , 1985 .

[15]  E. Obermeier,et al.  Heat-conduction microsensor based on silicon technology for the analysis of two- and three-component gas mixtures , 1993 .

[16]  J. Kestin,et al.  Thermal Conductivity of Nine Polyatomic Gases at Low Density , 1990 .

[17]  P. Larroudé,et al.  Direct numerical simulation of instabilities in a two-dimensional near-critical fluid layer heated from below , 2001, Journal of Fluid Mechanics.

[18]  Mohand Tazerout,et al.  Determination of the combustion properties of natural gases by pseudo-constituents☆ , 2003 .

[19]  Carles Cané,et al.  Characterization of thermal conductivity in thin film multilayered membranes , 2005 .

[20]  David Puente,et al.  Thermal conductivity microsensor for determining the Methane Number of natural gas , 2005 .

[21]  Oliver Paul,et al.  Thermal conductivity of CMOS materials for the optimization of microsensors , 1993 .

[22]  K. Kobe.  The properties of gases and liquids , 1959 .

[23]  R. Reid,et al.  The Properties of Gases and Liquids , 1977 .

[24]  J. Samitier,et al.  A methodology to extract dynamic compact thermal models under time-varying boundary conditions: application to a thermopile based IR sensor , 2005 .