Advances in Evaporated Solid-Phase-Crystallized Poly-Si Thin-Film Solar Cells on Glass (EVA)

Polycrystalline silicon thin-film solar cells on glass obtained by solid-phase crystallization (SPC) of PECVD-deposited a-Si precursor diodes are capable of producing large-area devices with respectable photovoltaic efficiency. This has not yet been shown for equivalent devices made from evaporated Si precursor diodes (“EVA” solar cells). We demonstrate that there are two main problems for the metallization of EVA solar cells: (i) shunting of the p-n junction when the air-side metal contact is deposited; (ii) formation of the glass-side contact with low contact resistance and without shunting. We present a working metallization scheme and first current-voltage and quantum efficiency results of 2 cm2 EVA solar cells. The best planar EVA solar cells produced so far achieved fill factors up to 64%, series resistance values in the range of 4-5 Ωcm2, short-circuit current densities of up to 15.6 mA/cm2, and efficiencies of up to 4.25%. Using numerical device simulation, a diffusion length of about 4 𝜇m is demonstrated for such devices. These promising results confirm that the device fabrication scheme presented in this paper is well suited for the metallization of EVA solar cells and that the electronic properties of evaporated SPC poly-Si materials are sufficient for PV applications.

[1]  D. A. Clugston,et al.  PC1D version 5: 32-bit solar cell modeling on personal computers , 1997, Conference Record of the Twenty Sixth IEEE Photovoltaic Specialists Conference - 1997.

[2]  Martin A. Green,et al.  Consolidation of thin‐film photovoltaic technology: the coming decade of opportunity , 2006 .

[3]  Richard M. Swanson,et al.  A vision for crystalline silicon photovoltaics , 2006 .

[4]  A. Aberle,et al.  Solid phase crystallized polycrystalline thin-films on glass from evaporated silicon for photovoltaic applications , 2006 .

[5]  S. Glunz,et al.  Analyzing Back Contacts of Silicon Solar Cells by Suns-Voc-Measurement at High Illumination Densities , 2007 .

[6]  Polycrystalline Silicon Thin-Film Solar Cells on AIT-Textured Glass Superstrates , 2007 .

[7]  Martin A. Green,et al.  Solar cell efficiency tables (Version 31) , 2008 .

[8]  A. Sproul,et al.  Impedance analysis: A powerful method for the determination of the doping concentration and built-in potential of nonideal semiconductor p‐n diodes , 2005 .

[9]  A. Aberle,et al.  Elimination of severe shunting problems due to air-side electrode formation on evaporated poly-Si thin-film solar cells on glass , 2008, 2008 33rd IEEE Photovoltaic Specialists Conference.

[10]  Toshiaki Baba,et al.  High-quality polycrystalline silicon thin film prepared by a solid phase crystallization method , 1996 .

[11]  A. Aberle,et al.  Rapid Thermal Annealing and Hydrogen Passivation of Polycrystalline Silicon Thin-Film Solar Cells on Low-Temperature Glass , 2007 .

[12]  Michael G. Mauk,et al.  Light trapping in Silicon-Film™ solar cells with rear pigmented dielectric reflectors , 1999 .

[13]  A. Sproul,et al.  Poly-Si on glass thin-film PV research at UNSW , 2007 .

[14]  Otwin Breitenstein,et al.  Lock-in thermography : basics and use for functional diagnostics of electronic components , 2003 .

[15]  Ronald A. Sinton,et al.  A quasi-steady-state open-circuit voltage method for solar cell characterization , 2000 .

[16]  K. Ng,et al.  The Physics of Semiconductor Devices , 2019, Springer Proceedings in Physics.

[17]  H. Card,et al.  Aluminum—Silicon Schottky barriers and ohmic contacts in integrated circuits , 1976, IEEE Transactions on Electron Devices.

[18]  Theodore I. Kamins,et al.  Device Electronics for Integrated Circuits , 1977 .

[19]  M. Werner,et al.  Shunt types in crystalline silicon solar cells , 2004 .

[20]  J. Bauer,et al.  Shunting problems due to sub‐micron pinholes in evaporated solid‐phase crystallised poly‐Si thin‐film solar cells on glass , 2009 .

[21]  H. S. Ullal,et al.  Thin Film CIGS and CdTe Photovoltaic Technologies: Commercialization, Critical Issues, and Applications; Preprint , 2007 .

[22]  Rolf Brendel,et al.  Thin-Film Crystalline Silicon Solar Cells: Physics and Technology , 2003 .

[23]  Toshiaki Baba,et al.  High-quality polycrystalline silicon thin film prepared by a solid phase crystallization method , 1996 .

[24]  Armin G. Aberle,et al.  Large open-circuit voltage improvement by rapid thermal annealing of evaporated solid-phase-crystallized thin-film silicon solar cells on glass , 2005 .

[25]  A. Aberle,et al.  Commercial white paint as back surface reflector for thin-film solar cells , 2007 .

[26]  A. Maldonado,et al.  Physical properties of ZnO:F obtained from a fresh and aged solution of zinc acetate and zinc acetylacetonate , 2006 .

[27]  M. Green.  Silicon solar cells : advanced principles and practice , 1995 .