Comparative study of methods used to estimate ionic diffusion coefficients using migration tests

Ionic diffusion coefficients are estimated rapidly using electromigration tests. In this paper, electromigration tests are accurately simulated by numerically solving the Nernst–Planck (NP) equation (coupled with the electroneutrality condition (EN)) using the finite element method. Numerical simulations are validated against experimental data obtained elsewhere [E. Samson, J. Marchand, K.A. Snyder, Calculation of ionic diffusion coefficients on the basis of migration test results, Materials and Structures/Materiaux et Constructions 36 (257) (2003) 156–165., H. Friedmann, O. Amiri, A. Ait-Mokhtar, A direct method for determining chloride diffusion coefficient by using migration test, Cement and Concrete Research 34 (11) (2004) 1967–1973.]. It is shown that migration due to the non-linear electric potential completely overwhelms diffusion due to concentration gradients. The effects of different applied voltage differences and chloride source concentrations on estimations of chloride diffusion coefficients are explored. We show that the pore fluid within concrete and mortar specimens generally differs from the curing solution, lowering the apparent diffusion coefficient, primarily due to interactions of chloride ions with other ions in the pore fluid. We show that the variation of source chloride concentration strongly affects the estimation of diffusion coefficients in non-steady-state tests; however this effect vanishes under steady-state conditions. Most importantly, a comparison of diffusion coefficients obtained from sophisticated analyses (i.e., NP–EN) and a variety of commonly used simplifying methods to estimate chloride diffusion coefficients allows us to identify those methods and experimental conditions where both approaches deliver good estimates for chloride diffusion coefficients. Finally, we demonstrate why simultaneous use and monitoring of current density and fluxes are recommended for both the non-steady and steady-state migration tests.

[1]  David W. Smith,et al.  Numerical aspects of multiionic transport in electrolytic solutions , 2005 .

[2]  Marta Castellote,et al.  Non-steady-state chloride diffusion coefficients obtained from migration and natural diffusion tests. Part I: Comparison between several methods of calculation , 2000 .

[3]  E. Samson,et al.  Prediction of diffusion coefficients in cement-based materials on the basis of migration experiments , 1996 .

[4]  Lars-Olof Nilsson,et al.  Numerical simulation of multi-species transport through saturated concrete during a migration test - MsDiff code , 2000 .

[5]  O. Gjørv,et al.  Effect of ionic interaction in migration testing of chloride diffusivity in concrete , 1995 .

[6]  Samson,et al.  Numerical Solution of the Extended Nernst-Planck Model. , 1999, Journal of colloid and interface science.

[7]  Luping Tang,et al.  ELECTRICALLY ACCELERATED METHODS FOR DETERMINING CHLORIDE DIFFUSIVITY IN CONCRETE - CURRENT DEVELOPMENT , 1996 .

[8]  C. Page,et al.  Aspects of the electrochemistry of steel in concrete , 1982, Nature.

[9]  A. Macgillivray,et al.  Nernst‐Planck Equations and the Electroneutrality and Donnan Equilibrium Assumptions , 1968 .

[10]  Carmen Andrade,et al.  Calculation of chloride diffusion coefficients in concrete from ionic migration measurements , 1993 .

[11]  J. Santamarina,et al.  Discrete Signals and Inverse Problems: An Introduction for Engineers and Scientists , 2005 .

[12]  Mda Thomas,et al.  TESTING THE CHLORIDE PENETRATION RESISTANCE OF CONCRETE: A LITERATURE REVIEW , 1997 .

[13]  O. Gjørv,et al.  Effect of Chloride Source Concentration on Chloride Diffusivity in Concrete , 2005 .

[14]  Peter Pivonka,et al.  Theoretical Analysis of Anion Exclusion and Diffusive Transport Through Platy-Clay Soils , 2004 .

[15]  J. Marchand,et al.  Calculation of ionic diffusion coefficients on the basis of migration test results , 2003 .

[16]  R. D. Hooton,et al.  Influence of voltage on chloride diffusion coefficients from chloride migration tests , 1996 .

[17]  Marta Castellote,et al.  Measurement of the steady and non-steady-state chloride diffusion coefficients in a migration test by means of monitoring the conductivity in the anolyte chamber. Comparison with natural diffusion tests , 2001 .

[18]  Masayuki Kato.  Numerical analysis of the Nernst-Planck-Poisson system , 1995 .

[19]  J. Marchand,et al.  Dimensional analysis of ionic transport problems in hydrated cement systems: Part 1. Theoretical considerations , 2000 .

[20]  Peter Pivonka,et al.  MICROSCOPIC EFFECTS ON CHLORIDE DIFFUSIVITY OF CEMENT PASTES - A SCALE-TRANSITION ANALYSIS , 2004 .

[21]  Abdelkarim Aït-Mokhtar,et al.  A DIRECT METHOD FOR DETERMINING CHLORIDE DIFFUSION COEFFICIENT BY USING MIGRATION TEST , 2004 .