Modeling and control of a natural circulation loop

Abstract In this paper some theoretical and experimental results concerning the modeling and control of rectangular natural circulation loops are presented. These thermo-fluid-dynamic systems are used to refrigerate heat sources by means of natural circulation of a fluid without mechanical pumping. Despite the structural simplicity of these systems, they can exhibit unstable behaviour, resulting in wide and dangerous oscillations. A non-linear lumped parameter model was derived by using a truncated Fourier series expansion of a suitable set of variables. The performance of the model was compared with a set of experimental data. Then a set of controllers, corresponding to different equilibrium points, was designed and tested both in simulation and experimentally. In all cases the controllers were capable of stabilising the system to the desired equilibrium condition.

[1]  Y. Zvirin,et al.  The Transient and Stability Behavior of a Natural Convection Loop , 1979 .

[2]  D. Japikse,et al.  Advances in Thermosyphon Technology , 1973 .

[3]  Instability of Single-phase Natural Circulation Under Double Loop Systemfn1fn1Communicated by Y. H. Ichikawa. , 1998 .

[4]  E. Lorenz.  Deterministic nonperiodic flow , 1963 .

[5]  Erik S. Van Vleck,et al.  Complex oscillations in a closed thermosyphon , 1998 .

[6]  James A. Yorke,et al.  Lorenz-like chaos in a partial differential equation for a heated fluid loop , 1987 .

[7]  Alberto Fichera,et al.  A new modelling methodology of natural circulation loop for stability analysis , 1999 .

[8]  Jonathan P. Singer,et al.  Controlling chaos in a thermal convection loop , 1992, Journal of Fluid Mechanics.

[9]  Y. Zvirin,et al.  ON THE STABILITY OF THE NATURAL CIRCULATION SOLAR HEATER , 1978 .

[10]  Singer,et al.  Controlling a chaotic system. , 1991, Physical review letters.

[11]  C. R. Miles,et al.  Thermosyphon models for downhole heat exchanger applications in shallow geothermal systems , 1978 .

[12]  Boundary control for the chaotic flow of a thermal convection loop , 1995, Proceedings of 1995 34th IEEE Conference on Decision and Control.

[13]  Erik S. Van Vleck,et al.  Diffusion Induced Chaos in a Closed Loop Thermosyphon , 1998, SIAM J. Appl. Math..

[14]  Yoram Zvirin,et al.  A review of natural circulation loops in pressurized water reactors and other systems , 1981 .

[15]  M. Gorman,et al.  Nonlinear dynamics of a convection loop II. Chaos in laminar and turbulent flows , 1989 .

[16]  Po Ki Yuen,et al.  Optimal and adaptive control of chaotic convection—Theory and experiments , 1999 .

[17]  J. J. L. Velázquez.  On the Dynamics of a Closed Thermosyphon , 1994, SIAM J. Appl. Math..

[18]  Giovanni Muscato,et al.  Modelling unstable behavior of a natural circulation loop with a neural network , 2000, Proceedings of the IEEE-INNS-ENNS International Joint Conference on Neural Networks. IJCNN 2000. Neural Computing: New Challenges and Perspectives for the New Millennium.

[19]  B. Larock.  Jets from two-dimensional symmetric nozzles of arbitrary shape , 1969, Journal of Fluid Mechanics.