Euler-Lagrange Computational Fluid Dynamics simulation of a full-scale unconfined anaerobic digester for wastewater sludge treatment

Abstract For the first time, an Euler-Lagrange model for Computational Fluid Dynamics (CFD) is used to model a full-scale gas-mixed anaerobic digester. The design and operation parameters of a digester from a wastewater treatment works are modelled, and mixing is assessed through a novel, multi-facetted approach consisting of the simultaneous analysis of ( i ) velocity, shear rate and viscosity flow patterns, ( ii ) domain characterization following the average shear rate value, and ( iii ) concentration of a non-diffusive scalar tracer. The influence of sludge’s non-Newtonian behaviour on flow patterns and its consequential impact on mixing quality were discussed for the first time. Recommendations to enhance mixing effectiveness are given: ( i ) a lower gas mixing input power can be used in the digester modelled within this work without a significant change in mixing quality, and ( ii ) biogas injection should be periodically switched between different nozzle series placed at different distances from the centre.

[1]  G. P. Noone,et al.  Anaerobic sludge digestion, need it be expensive? III: Integrated and low-cost digestion , 1985 .

[2]  A. Almstedt,et al.  Methods for multiphase computational fluid dynamics , 2003 .

[3]  Binxin Wu,et al.  CFD simulation of gas mixing in anaerobic digesters , 2014 .

[4]  Binxin Wu,et al.  CFD simulation of gas and non-Newtonian fluid two-phase flow in anaerobic digesters. , 2010, Water research.

[5]  M. Al-Dahhan,et al.  Gas-lift digester configuration effects on mixing effectiveness. , 2007, Water research.

[6]  Argyrios Margaritis,et al.  Hydrodynamic characteristics of free rise of light solid particles and gas bubbles in non-Newtonian liquids , 1999 .

[7]  Alastair J Ward,et al.  Optimisation of the anaerobic digestion of agricultural resources. , 2008, Bioresource technology.

[8]  P. F. Greenfield,et al.  Effect of Mixing on Biomethanation of Cattle-Manure Slurry , 2002, Environmental technology.

[9]  Binxin Wu,et al.  CFD simulation of mixing in egg-shaped anaerobic digesters. , 2010, Water research.

[10]  Mark M. Clark.  Critique of Camp and Stein's RMS Velocity Gradient , 1985 .

[11]  Jos Derksen,et al.  Modeling of aerated stirred tanks with shear-thinning power law liquids , 2012 .

[12]  John Bridgeman,et al.  Euler-Lagrange CFD modelling of unconfined gas mixing in anaerobic digestion. , 2015, Water research.

[13]  Philip R. Goodrich,et al.  Rheological properties of Moroccan dairy cattle manure , 1992 .

[14]  K. McMahon,et al.  Anaerobic codigestion of municipal solid waste and biosolids under various mixing conditions--II: Microbial population dynamics. , 2001, Water research.

[15]  Jos Derksen,et al.  Modeling of turbulent gas-liquid bubbly flows using stochastic Lagrangian model and lattice-Boltzmann scheme , 2011 .

[16]  Davide Dapelo,et al.  Positron emission particle tracking (PEPT): A novel approach to flow visualisation in lab-scale anaerobic digesters , 2017 .

[17]  K. Craig,et al.  CFD simulation of anaerobic digester with variable sewage sludge rheology. , 2013, Water research.

[18]  A S Kaiser,et al.  Fluid dynamic analysis of a continuous stirred tank reactor for technical optimization of wastewater digestion. , 2015, Water research.

[19]  P. Roache.  Verification of Codes and Calculations , 1998 .

[20]  K. McMahon,et al.  Anaerobic codigestion of municipal solid waste and biosolids under various mixing conditions--I. Digester performance. , 2001, Water research.

[21]  H. Landry,et al.  PHYSICAL AND RHEOLOGICAL PROPERTIES OF MANURE PRODUCTS , 2004 .

[22]  J. Bridgeman,et al.  Computational fluid dynamics modelling of sewage sludge mixing in an anaerobic digester , 2012, Adv. Eng. Softw..

[23]  Binxin Wu,et al.  CFD simulation of non‐Newtonian fluid flow in anaerobic digesters , 2008, Biotechnology and bioengineering.

[24]  Hiroshi Takahashi,et al.  CFD simulation of mixing in anaerobic digesters. , 2009, Bioresource technology.

[25]  Muthanna Al-Dahhan,et al.  Flow pattern visualization in a mimic anaerobic digester using CFD. , 2005, Biotechnology and bioengineering.

[26]  Bengt Andersson,et al.  Computational Fluid Dynamics for Engineers , 2011 .

[27]  Paulo Monteiro,et al.  The influence of the anaerobic digestion process on the sewage sludges rheological behaviour , 1997 .

[28]  E. L. Paul,et al.  Handbook of Industrial Mixing: Science and Practice , 2003 .

[29]  J. Bridgeman,et al.  Velocity gradient as a tool to characterise the link between mixing and biogas production in anaerobic waste digesters. , 2013, Water science and technology : a journal of the International Association on Water Pollution Research.

[30]  Hidesada Tamai,et al.  Transverse migration of single bubbles in simple shear flows , 2002 .

[31]  Binxin Wu.  Integration of mixing, heat transfer, and biochemical reaction kinetics in anaerobic methane fermentation , 2012, Biotechnology and bioengineering.

[32]  B. Launder,et al.  Ground effects on pressure fluctuations in the atmospheric boundary layer , 1978, Journal of Fluid Mechanics.

[33]  Xiomar Gómez,et al.  Anaerobic co-digestion of primary sludge and the fruit and vegetable fraction of the municipal solid wastes: Conditions for mixing and evaluation of the organic loading rate , 2006 .

[34]  Binxin Wu,et al.  CFD investigation of turbulence models for mechanical agitation of non-Newtonian fluids in anaerobic digesters. , 2011, Water research.

[35]  Richard V. Calabrese,et al.  Rotor–Stator Mixing Devices , 2004 .

[36]  Paul Slatter,et al.  Rheological characterisation of municipal sludge: a review. , 2013, Water research.

[37]  Binxin Wu,et al.  CFD simulation of mixing for high‐solids anaerobic digestion , 2012, Biotechnology and bioengineering.

[38]  Paul Slatter,et al.  The impact of temperature on the rheological behaviour of anaerobic digested sludge , 2013 .

[39]  Philip R. Goodrich,et al.  Bulk density and thermal properties of Moroccan dairy cattle manure , 1992 .

[40]  Robert N Meroney,et al.  CFD simulation of mechanical draft tube mixing in anaerobic digester tanks. , 2009, Water research.