Non-equilibrium condensation process of water vapor in moist air expansion through a sonic nozzle

Non-equilibrium vapor condensation phenomenon through a sonic nozzle is very complicated and closely related to the flow measurement of the sonic nozzle. The gas–liquid two-phase flow Eulerian models for homogeneous and heterogeneous nucleation of moist gas in transonic nozzle flow were built to investigate the effect of vapor condensation on the mass flow rate of the sonic nozzle. Grid independence was achieved by using a solution-adaptive refinement. The CFD models were carefully validated by published experimental data and analytical results. It was shown that the flow rate of the sonic nozzle is affected by both homogeneous and heterogeneous nucleation. In comparison with the experimental data, the effects of vapor condensation on the mass flow rate of the sonic nozzle were obtained. Besides, experiments on periodic, unsteady condensation flow in the sonic nozzle were also reported. This unsteady flow will also affect the flow rate of the sonic nozzle. The results of experiments accorded well with simulations and semi-empirical formula. All the results can be used to further analyze the effect of unsteady flow induced by vapor condensation on the flow rate of the sonic nozzle.

[1]  R. Probstein.  Time Lag in the Self‐Nucleation of a Supersaturated Vapor , 1951 .

[2]  Barbara E. Wyslouzil,et al.  Binary condensation in a supersonic nozzle , 1986 .

[3]  Hongbing Ding,et al.  An analytical method for Wilson point in nozzle flow with homogeneous nucleating , 2014 .

[4]  J. Young.  Spontaneous condensation of steam in supersonic nozzles , 1982 .

[5]  Chao Wang,et al.  The dynamic compensation of temperature sensors in sonic nozzle airflow standard facilities based on method of positive pressure , 2012, 2012 IEEE International Instrumentation and Measurement Technology Conference Proceedings.

[6]  Andrew A. Pouring,et al.  Thermal Choking and Condensation in Nozzles , 1965 .

[7]  J. Jiang,et al.  A turbulent Eulerian multi-fluid model for homogeneous nucleation of water vapour in transonic flow , 2009 .

[8]  H. Wakeshima.  Time Lag in the Self-Nucleation , 1955 .

[9]  Chao Wang,et al.  Thermodynamic Model and Dynamic Temperature Compensation in Positive-Pressure-Based Sonic Nozzle Gas Flow Standard , 2013, IEEE Transactions on Instrumentation and Measurement.

[10]  Kyung-Am Park,et al.  The humidity effect on air flow rates in a critical flow venturi nozzle , 2011 .

[11]  P. Armenante,et al.  Hydrodynamic, mass transfer, and dissolution effects induced by tablet location during dissolution testing. , 2009, Journal of pharmaceutical sciences.

[12]  E. Géhin,et al.  Heterogeneous condensation process in an air water vapour expansion through a nozzle--experimental aspect , 2003 .

[13]  M. J. Moore,et al.  Two-phase steam flow in turbines and separators : theory, instrumentation, engineering , 1976 .

[14]  Hongbing Ding,et al.  Influence of wall roughness on discharge coefficient of sonic nozzles , 2014 .

[15]  A. Shapiro.  The dynamics and thermodynamics of compressible fluid flow. , 1953 .

[16]  Huang Li-zhong,et al.  Standard gas flowrate facilities by means of critical flow venturi nozzle , 2005 .

[17]  Weeratunge Malalasekera,et al.  An introduction to computational fluid dynamics - the finite volume method , 2007 .

[18]  Peter P. Wegener,et al.  Periodic Nozzle Flow with Heat Addition , 1973 .