Towards novel non-chemically amplified (n-CARS) negative resists for electron beam lithography applications

A novel, non-chemically amplified negative resist was synthesized and characterized for next generation lithography applications. This resist material was shown to be directly sensitive to radiation without utilizing the concept of chemical amplification (CAR) and resulted in high-resolution 20 nm features. This resist design is accomplished by copolymers that are prepared from a monomer containing a sulfonium group which is sensitive to e-beam irradiation. Under 20 keV e-beam imaging and TMAH development, a sensitivity of 2.06 μC cm−2 and contrast of 1.8 were obtained. It has an LER of 20 nm, 10 line pattern varies from 1.8 ± 0.3 to 2.3 ± 0.4 nm.

[1]  Robert L. Bristol,et al.  The tri-lateral challenge of resolution, photospeed, and LER: scaling below 50nm? , 2007, SPIE Advanced Lithography.

[2]  Anda E. Grigorescu,et al.  Resist thickness effects on ultra thin HSQ patterning capabilities , 2009 .

[3]  Clifford L. Henderson,et al.  Negative tone molecular resists using cationic polymerization: Comparison of epoxide and oxetane functional groups , 2009 .

[4]  H. M. Zaid,et al.  A chemically amplified fullerene-derivative molecular electron-beam resist. , 2007, Small.

[5]  Yayi Wei,et al.  Performance of chemically amplified resists at half-pitch of 45 nm and below , 2007, SPIE Advanced Lithography.

[6]  C. W. Hagen,et al.  10nm lines and spaces written in HSQ, using electron beam lithography , 2007 .

[7]  Yasin Ekinci,et al.  20nm Line/space patterns in HSQ fabricated by EUV interference lithography , 2007 .

[8]  Dominic Ashworth,et al.  The SEMATECH Berkeley MET: demonstration of 15-nm half-pitch in chemically amplified EUV resist and sensitivity of EUV resists at 6.x-nm , 2012, Advanced Lithography.

[9]  J. Thackeray.  Materials challenges for sub-20-nm lithography , 2011 .

[10]  T. Wallow,et al.  EUV resist performance: current assessment for sub-22-nm half-pitch patterning on NXE:3300 , 2012, Advanced Lithography.

[11]  Hengpeng Wu,et al.  A Novel Single‐Component Negative Resist for DUV and Electron Beam Lithography , 2001 .

[12]  Atsuko Yamaguchi,et al.  Spectral analysis of line-edge roughness in polyphenol EB-resists and its impact on transistor performance , 2005 .

[13]  Kenneth A. Goldberg,et al.  Critical challenges for EUV resist materials , 2011, Advanced Lithography.

[14]  Yasin Ekinci,et al.  Evaluation of EUV resist performance with interference lithography towards 11 nm half-pitch and beyond , 2013, Advanced Lithography.

[15]  Warren Montgomery,et al.  Development of an inorganic nanoparticle photoresist for EUV, e-beam, and 193nm lithography , 2011, Advanced Lithography.

[16]  Hasnah Mohd Zaid,et al.  Chemical Amplification of a Triphenylene Molecular Electron Beam Resist , 2007 .

[17]  J. Stowers,et al.  High resolution, high sensitivity inorganic resists , 2009 .

[18]  Hideaki Tsubaki,et al.  EUV resist materials design for 15nm half pitch and below , 2013, Advanced Lithography.

[19]  Wilhelm T. S. Huck,et al.  Polymer brush resist for responsive wettability , 2009 .

[20]  X. Chen,et al.  A high resolution water soluble fullerene molecular resist for electron beam lithography , 2008, Nanotechnology.

[21]  G. G. Stokes.  "J." , 1890, The New Yale Book of Quotations.

[22]  Richard E. Palmer,et al.  Fullerene Resist Materials for the 32 nm Node and Beyond , 2008 .

[23]  Yasuo Takahashi,et al.  Three-dimensional siloxane resist for the formation of nanopatterns with minimum linewidth fluctuations , 1998 .

[24]  Fumio Murai,et al.  Accurate critical dimension control by using an azide/novolak resist process for electron-beam lithography , 1997 .

[25]  A new nanocomposite resist for low and high voltage electron beam lithography , 2003 .

[26]  Christoph Hohle,et al.  Evaluation of direct patternable inorganic spin-on hard mask materials using electron beam lithography , 2012 .

[27]  Hengpeng Wu,et al.  Organic–Inorganic Nanocomposites: Unique Resists for Nanolithography , 2001 .

[28]  W. Cho,et al.  Electron beam lithography patterning of sub-10 nm line using hydrogen silsesquioxane for nanoscale device applications , 2005 .