A CNT (carbon nanotube) paper as cathode gas diffusion electrode for water management of passive μ-DMFC (micro-direct methanol fuel cell) with highly concentrated methanol

A novel MEA (membrane electrode assembly) structure of passive μ-DMFC (micro-direct methanol fuel cell) controls water management and decreases methanol crossover. The CNT (carbon nanotube) paper replacing CP (carbon paper) as GDL (gas diffusion paper) enhances water back diffusion which passively prevents flooding in the cathode and promotes low methanol crossover. Moreover, the unique structure of CNT paper can also enhance efficiency of oxygen mass transport and catalyst utilization. The passive μ-DMFC with CNT-MEA exhibits significantly higher performance than passive μ-DMFC with CP-MEA and can operate in high methanol concentration, showing the peak power density of 23.2 mW cm−2. The energy efficiency and fuel utilization efficiency are obviously improved from 11.54% to 22.7% and 36.61%–49.34%, respectively, and the water transport coefficient is 0.47 which is lower than previously reported passive μ-DMFC with CP.

[1]  Siti Kartom Kamarudin,et al.  Overview on the application of direct methanol fuel cell (DMFC) for portable electronic devices , 2009 .

[2]  Jianyu Cao,et al.  Double microporous layer cathode for membrane electrode assembly of passive direct methanol fuel cells , 2010 .

[3]  Siti Kartom Kamarudin,et al.  High power direct methanol fuel cell with a porous carbon nanofiber anode layer , 2014 .

[4]  Joachim Scholta,et al.  Estimation of water distribution and degradation mechanisms in polymer electrolyte membrane fuel cel , 2011 .

[5]  C. Hochenauer,et al.  Water droplet accumulation and motion in PEM (Proton Exchange Membrane) fuel cell mini-channels , 2012 .

[6]  A. Iranzo,et al.  A novel approach coupling neutron imaging and numerical modelling for the analysis of the impact of water on fuel cell performance , 2014 .

[7]  T. Zhao,et al.  A sandwich structured membrane for direct methanol fuel cells operating with neat methanol , 2013 .

[8]  E. Médici,et al.  Evaporation, two phase flow, and thermal transport in porous media with application to low-temperature fuel cells , 2013 .

[9]  Xun Guo,et al.  A water collecting and recycling structure for silicon-based micro direct methanol fuel cells , 2012 .

[10]  Omar Imine,et al.  Simulation of species transport and water management in PEM fuel cells , 2011 .

[11]  Qin Xin,et al.  Preparation and Characterization of Multiwalled Carbon Nanotube-Supported Platinum for Cathode Catalysts of Direct Methanol Fuel Cells , 2003 .

[12]  Inseob Song,et al.  Mass balance research for high electrochemical performance direct methanol fuel cells with reduced methanol crossover at various operating conditions , 2008 .

[13]  Bernard Gauthier-Manuel,et al.  Realization of porous silicon based miniature fuel cells , 2006 .

[14]  Siti Kartom Kamarudin,et al.  Passive direct methanol fuel cells for portable electronic devices , 2011 .

[15]  D. Wilkinson,et al.  Investigation of the effect of microporous layers on water management in a proton exchange membrane fuel cell using novel diagnostic methods , 2014 .

[16]  Steven L. Bryant,et al.  Theory, modeling and experiment in reactive transport in porous media , 2001 .

[17]  D. Brett,et al.  A study of the effect of water management and electrode flooding on the dimensional change of polymer electrolyte fuel cells , 2013 .

[18]  Ned Djilali,et al.  Computational modelling of polymer electrolyte membrane (PEM) fuel cells: Challenges and opportunities , 2007 .

[19]  D. Wilkinson,et al.  Application of water barrier layers in a proton exchange membrane fuel cell for improved water manag , 2011 .

[20]  Fritz B. Prinz,et al.  Passive water management at the cathode of a planar air-breathing proton exchange membrane fuel cell , 2010 .

[21]  Amir Faghri,et al.  Water and air management systems for a passive direct methanol fuel cell , 2007 .

[22]  Tianshou Zhao,et al.  Effect of the cathode gas diffusion layer on the water transport behavior and the performance of passive direct methanol fuel cells operating with neat methanol , 2011 .