Two-phase flow regimes in microchannels

Capillary hydrodynamics has three considerable distinctions from macrosystems: first, there is an increase in the ratio of the surface area of the phases to the volume that they occupy; second, a flow is characterized by small Reynolds numbers at which viscous forces predominate over inertial forces; and third, the microroughness and wettability of the wall of the channel exert a considerable influence on the flow pattern. In view of these differences, the correlations used for tubes with a larger diameter cannot be used to calculate the boundaries of the transitions between different flow regimes in microchannels. In the present review, an analysis of published data on a gas-liquid two-phase flow in capillaries of various shapes is given, which makes it possible to systematize the collected body of information. The specific features of the geometry of a mixer and an inlet section, the hydraulic diameter of a capillary, and the surface tension of a liquid exert the strongest influence on the position of the boundaries of two-phase flow regimes. Under conditions of the constant geometry of the mixer, the best agreement in the position of the boundaries of the transitions between different hydrodynamic regimes in capillaries is observed during the construction of maps of the regimes with the use of the Weber numbers for a gas and a liquid as coordinate axes.

[1]  M. Vaillancourt,et al.  Two-Phase Flow Regime Transitions in Microchannels: A Comparative Experimental Study , 2005 .

[2]  G. Whitesides,et al.  Mechanism for flow-rate controlled breakup in confined geometries: a route to monodisperse emulsions. , 2005, Physical review letters.

[3]  Tianshou Zhao,et al.  Co-current air–water two-phase flow patterns in vertical triangular microchannels , 2001 .

[4]  Tohru Fukano,et al.  Characteristics of gas-liquid two-phase flow in a capillary tube , 1993 .

[5]  M. Simmons,et al.  Influence of orientation upon the hydrodynamics of gas–liquid flow for square channels in monolith supports , 2007 .

[6]  H. Löwe,et al.  Hydrodynamics and Mixer‐Induced Bubble Formation in Micro Bubble Columns with Single and Multiple‐Channels , 2006 .

[7]  Jinliang Xu,et al.  Experimental study on gas–liquid two-phase flow regimes in rectangular channels with mini gaps , 1999 .

[8]  Mahidhar Tatineni,et al.  Bubble dispenser in microfluidic devices. , 2005, Physical review. E, Statistical, nonlinear, and soft matter physics.

[9]  Muhammad Akbar,et al.  On gas–liquid two-phase flow regimes in microchannels , 2003 .

[10]  Masahiro Kawaji,et al.  The effect of channel diameter on adiabatic two-phase flow characteristics in microchannels ☆ , 2004 .

[11]  A. Gañán-Calvo,et al.  Monodisperse microbubbling: Absolute instabilities in coflowing gas–liquid jets , 2001 .

[12]  A. Kawahara,et al.  Investigation of two-phase flow pattern, void fraction and pressure drop in a microchannel , 2002 .

[13]  Ziping Feng,et al.  Two-phase flow in microchannels , 2002 .

[14]  F. Bretherton.  The motion of long bubbles in tubes , 1961, Journal of Fluid Mechanics.

[15]  Naim Afgan,et al.  Two-phase momentum, heat and mass transfer in chemical, process, and energy engineering systems , 1979 .

[16]  Asterios Gavriilidis,et al.  CFD simulations of the effect of inlet conditions on Taylor flow formation , 2008 .

[17]  Wim Moerman,et al.  Full-scale modelling of a food industry wastewater treatment plant in view of process upgrade , 2008 .

[18]  Freek Kapteijn,et al.  Multiphase monolith reactors: Chemical reaction engineering of segmented flow in microchannels , 2005 .

[19]  R. Panton,et al.  The effects of contact angle on two-phase flow in capillary tubes , 1993 .

[20]  Chien-Yuh Yang,et al.  Flow pattern of air–water and two-phase R-134a in small circular tubes , 2001 .

[21]  L. Luo,et al.  An experimental investigation of gas–liquid two-phase flow in single microchannel contactors , 2008 .

[22]  Srinivas Garimella,et al.  Characterization of two-phase flow patterns in small diameter round and rectangular tubes , 1999 .

[23]  L. Galbiati,et al.  Flow pattern transition for vertical downward two-phase flow in capillary tubes. Inlet mixing effects , 1992 .

[24]  Asterios Gavriilidis,et al.  On the formation of Taylor bubbles in small tubes , 2006 .

[25]  Philipp Rudolf von Rohr,et al.  Two-phase flow characteristics in gas–liquid microreactors , 2006 .

[26]  Said I. Abdel-Khalik,et al.  Two-phase flow in microchannels , 2001 .

[27]  Ryszard Pohorecki,et al.  Hydrodynamic regimes of gas–liquid flow in a microreactor channel , 2008 .

[28]  K. S. Rezkallah,et al.  Weber number based flow-pattern maps for liquid-gas flows at microgravity , 1996 .

[29]  Sang Yong Lee,et al.  Influence of surface wettability on transition of two-phase flow pattern in round mini-channels , 2008 .

[30]  Mikio Suo,et al.  Two phase flow in capillary tubes , 1964 .

[31]  Said I. Abdel-Khalik,et al.  Gas–liquid two-phase flow in microchannels Part I: two-phase flow patterns , 1999 .

[32]  T. Karayiannis,et al.  The effect of tube diameter on vertical two-phase flow regimes in small tubes , 2006 .

[33]  D. Poulikakos,et al.  On two-phase flow patterns and transition criteria in aqueous methanol and CO2 mixtures in adiabatic, rectangular microchannels , 2009 .

[34]  Chih-Ming Ho,et al.  Transport of bubbles in square microchannels , 2002 .

[35]  Asterios Gavriilidis,et al.  Effect of Gas-Inlet conditions on the mechanism of Taylor Flow formation , 2004 .

[36]  G. Whitesides,et al.  Formation of droplets and bubbles in a microfluidic T-junction-scaling and mechanism of break-up. , 2006, Lab on a chip.

[37]  Rainer Mertz,et al.  Numerical Study on the Formation of Taylor Bubbles in Capillary Tubes , 2009 .

[38]  Said I. Abdel-Khalik,et al.  Gas–liquid two-phase flow in microchannels: Part II: void fraction and pressure drop , 1999 .

[39]  Adeniyi Lawal,et al.  Numerical study on gas and liquid slugs for Taylor flow in a T-junction microchannel , 2006 .

[40]  Kaichiro Mishima,et al.  Some characteristics of gas-liquid flow in narrow rectangular ducts , 1993 .