Neural network controller based on PID using an extended Kalman filter algorithm for multi-variable non-linear control system

The Proportional Integral Derivative (PID) controller is widely used in the industrial control application, which is only suitable for the single input/single output (SISO) with known-parameters of the linear system. However, many researchers have been proposed the neural network controller based on PID (NNPID) to apply for both of the single and multi-variable control system but the NNPID controller that uses the conventional gradient descent-learning algorithm has many disadvantages such as a low speed of the convergent stability, difficult to set initial values, especially, restriction of the degree of system complexity. Therefore, this paper presents an improvement of recurrent neural network controller based on PID, including a controller structure improvement and a modified extended Kalman filter (EKF) learning algorithm for weight update rule, called ENNPID controller. We apply the proposed controller to the dynamic system including inverted pendulum, and DC motor system by the MATLAB simulation. From our experimental results, it shows that the performance of the proposed controller is higher than the other PID-like controllers in terms of fast convergence and fault tolerance that are highly required.

[1]  S. Haykin.  Kalman Filtering and Neural Networks , 2001 .

[2]  Yun Li,et al.  PID control system analysis, design, and technology , 2005, IEEE Transactions on Control Systems Technology.

[3]  Hideaki Sakai,et al.  A real-time learning algorithm for a multilayered neural network based on the extended Kalman filter , 1992, IEEE Trans. Signal Process..

[4]  Léon Personnaz,et al.  A recursive algorithm based on the extended Kalman filter for the training of feedforward neural models , 1998, Neurocomputing.

[5]  Shuang Cong,et al.  PID-Like Neural Network Nonlinear Adaptive Control for Uncertain Multivariable Motion Control Systems , 2009, IEEE Transactions on Industrial Electronics.

[6]  Vikas Kumar,et al.  ANN based self tuned PID like adaptive controller design for high performance PMSM position control , 2014, Expert Syst. Appl..

[7]  G. V. Puskorius,et al.  Training controllers for robustness: multi-stream DEKF , 1994, Proceedings of 1994 IEEE International Conference on Neural Networks (ICNN'94).

[8]  Geoffrey E. Hinton,et al.  Learning representations by back-propagating errors , 1986, Nature.

[9]  Sharad Singhal,et al.  Training feed-forward networks with the extended Kalman algorithm , 1989, International Conference on Acoustics, Speech, and Signal Processing,.

[10]  Kok Lay Teo,et al.  A constrained optimal PID-like controller design for spacecraft attitude stabilization , 2012 .

[11]  Sang-Min Kim,et al.  Induction motor servo drive using robust PID-like neuro-fuzzy controller , 2006 .