SPMSMs Sensorless Torque Estimation Using High Frequency Signal Injection

Torque measurement/estimation in surface permanent magnet synchronous machines (SPMSMs) is needed in many applications. Torque measurement systems are expensive, require extra room, add weight, can introduce resonances into the system, and their performance can be compromised due to electromagnetic interference. Alternatively, torque can be estimated, accurate knowledge of machine parameters being critical in this case. Injection of a high frequency (HF) signal in the stator via inverter has been shown to be a viable option for online identification of machine parameters identification required by torque estimation methods for interior PMSMs (IPMSMs). However, the reported methods require the use of two pulsating HF currents, which introduces concerns both on the adverse effects on machine’s performance (additional noise, vibration, additional, …) as well as to the additional computational burden, as HF current controllers are required. This paper proposes a torque estimation method for SPMSMs using a single HF signal; further more, a HF voltage signal can be used, avoiding the use of HF current controllers, and therefore simplifying the implementation.1

[1]  Shih-Chin Yang,et al.  Surface permanent magnet machine self-sensing at zero and low speeds using improved observer for position, velocity, and disturbance torque estimation , 2011, 2011 IEEE International Electric Machines & Drives Conference (IEMDC).

[2]  Robert D. Lorenz,et al.  Efficiency Contours and Loss Minimization Over a Driving Cycle of a Variable Flux-Intensifying Machine , 2015, IEEE Transactions on Industry Applications.

[3]  J. Pyrhonen,et al.  Guidelines for Designing Concentrated Winding Fractional Slot Permanent Magnet Machines , 2007, 2007 International Conference on Power Engineering, Energy and Electrical Drives.

[4]  Ya-Jun Pan,et al.  Improved PMSM pulsating torque minimization with iterative learning and sliding mode observer , 2000, 2000 26th Annual Conference of the IEEE Industrial Electronics Society. IECON 2000. 2000 IEEE International Conference on Industrial Electronics, Control and Instrumentation. 21st Century Technologies.

[5]  Luis Romeral,et al.  Shaft Trajectory Analysis in a Partially Demagnetized Permanent-Magnet Synchronous Motor , 2013, IEEE Transactions on Industrial Electronics.

[6]  D. Fernández,et al.  PMSMs Torque Estimation Using Pulsating HF Current Injection , 2018, 2018 IEEE 9th International Symposium on Sensorless Control for Electrical Drives (SLED).

[7]  Tomy Sebastian,et al.  Temperature effects on torque production and efficiency of PM motors using NdFeB magnets , 1993, Conference Record of the 1993 IEEE Industry Applications Conference Twenty-Eighth IAS Annual Meeting.

[8]  Greg Heins,et al.  Accurate Torque Ripple Measurement for PMSM , 2011, IEEE Transactions on Instrumentation and Measurement.

[9]  Robert D. Lorenz,et al.  High-Frequency Injection-Based Stator Flux Linkage and Torque Estimation for DB-DTFC Implementation on IPMSMs Considering Cross-Saturation Effects , 2014 .

[10]  Takashi Kato,et al.  Comparative Analysis of BEMF and Pulsating High-Frequency Current Injection Methods for PM Temperature Estimation in PMSMs , 2017, IEEE Transactions on Power Electronics.

[11]  Sanjib Kumar Panda,et al.  Torque ripple minimization in PM synchronous motor using iterative learning control , 1999, IECON'99. Conference Proceedings. 25th Annual Conference of the IEEE Industrial Electronics Society (Cat. No.99CH37029).

[12]  R.D. Lorenz,et al.  Fast and Smooth Initial Position and Magnet Polarity Estimation of Salient and Near Zero Saliency PM Synchronous Machines , 2005, IEEE International Conference on Electric Machines and Drives, 2005..

[13]  Myung-Joong Youn,et al.  A new instantaneous torque control of PM synchronous motor for high performance direct drive applications , 1997, Proceedings of APEC 97 - Applied Power Electronics Conference.

[14]  R. McCann,et al.  Torque measurements in synchronous generators using giant magnetoresistive sensor arrays via the Maxwell stress tensor , 2013, 2013 IEEE Power & Energy Society General Meeting.

[15]  Jin Hur,et al.  Analysis of cogging torque and torque ripple according to unevenly magnetized permanent magnets pattern in PMSM , 2017, 2017 IEEE Energy Conversion Congress and Exposition (ECCE).

[16]  Takashi Kato,et al.  Permanent-Magnet Temperature Estimation in PMSMs Using Pulsating High-Frequency Current Injection , 2015, IEEE Transactions on Industry Applications.

[17]  P. Sue,et al.  High precision torque measurement on a rotating load coupling for power generation operations , 2012, 2012 IEEE International Instrumentation and Measurement Technology Conference Proceedings.

[18]  Z. Q. Zhu,et al.  Sensitivity of Manufacturing Tolerances on Cogging Torque in Interior Permanent Magnet Machines With Different Slot/Pole Number Combinations , 2017, IEEE Transactions on Industry Applications.

[19]  Barry W. Williams,et al.  Online Modeling for Switched Reluctance Motors Using B-Spline Neural Networks , 2007, IEEE Transactions on Industrial Electronics.

[20]  Y. Mohamed,et al.  Adaptive self-tuning MTPA vector controller for IPMSM drive system , 2006, IEEE Transactions on Energy Conversion.

[21]  Robert D. Lorenz,et al.  Deadbeat-Direct Torque and Flux Control of Interior Permanent Magnet Synchronous Machines With Discrete Time Stator Current and Stator Flux Linkage Observer , 2011, IEEE Transactions on Industry Applications.

[22]  Kheng Cher Yeo,et al.  Comparison of torque estimators for PMSM , 2008, 2008 Australasian Universities Power Engineering Conference.

[23]  F. Blaabjerg,et al.  Combined Flux Observer With Signal Injection Enhancement for Wide Speed Range Sensorless Direct Torque Control of IPMSM Drives , 2008, IEEE Transactions on Energy Conversion.

[24]  Z. Zhu,et al.  Influence of Electric Loading and Magnetic Saturation on Cogging Torque, Back-EMF and Torque Ripple of PM Machines , 2012, IEEE Transactions on Magnetics.

[25]  Fernando Briz,et al.  Magnet temperature estimation in surface PM machines using high frequency signal injection , 2009, 2009 IEEE Energy Conversion Congress and Exposition.

[26]  Marcelo A Pérez,et al.  Torque ripple modeling of a permanent magnet synchronous motor , 2010, 2010 IEEE International Conference on Industrial Technology.

[27]  Robert D. Lorenz,et al.  Saliency based Self-Sensing Enhanced Operating Condition Monitoring Using High-Frequency Injection Under Intentional Magnetic Saturation , 2019, 2019 IEEE International Electric Machines & Drives Conference (IEMDC).

[28]  Wang Tianmiao,et al.  Comparison between model reference observer and reduced order observer of PMSM torque , 2011, 2011 6th IEEE Conference on Industrial Electronics and Applications.

[29]  G. Scelba,et al.  Steady-State and Transient Operation of IPMSMs Under Maximum-Torque-per-Ampere Control , 2010, IEEE Transactions on Industry Applications.

[30]  Mark Yim,et al.  Cogging Torque Ripple Minimization via Position Based Characterization , 2014, Robotics: Science and Systems.

[31]  Jacek F. Gieras,et al.  Permanent magnet motor technology : design and applications , 1996 .

[32]  Kay Hameyer,et al.  High-Performance Adaptive Torque Control for an IPMSM With Real-Time MTPA Operation , 2017, IEEE Transactions on Energy Conversion.

[33]  Olli Pyrhonen,et al.  Advanced measurement of rotor vibration in electric drives , 1998 .

[34]  G. Heins,et al.  Cogging torque estimation for sensorless PMSM , 2012, 2012 XXth International Conference on Electrical Machines.

[35]  Bing Cheng,et al.  Torque Feedforward Control Technique for Permanent Magnet Synchronous Motors , 2007, IECON 2007 - 33rd Annual Conference of the IEEE Industrial Electronics Society.

[36]  Damir Sumina,et al.  Comparison of torque estimation methods for interior permanent magnet wind power generator , 2017, 2017 19th International Conference on Electrical Drives and Power Electronics (EDPE).