Review of Experimental Procedure for Determining Liquid Flow in Microchannels

Large scatter in published experimental data has been observed with respect to classical theory. Recent data have confirmed that liquid, fully-developed, laminar flow in smooth microchannels of various cross-section is governed by the Navier-Stokes equations. However, when the dimensions of the channels are comparable with the wall roughness, surface effects become significant, as shown experimentally. To better assess the effect of surface phenomena such as wall roughness, sources of systematic bias must be eliminated. Some of the observed inconsistencies in data could originate from the experimental method. This paper explores and categorizes different approaches found in literature for measuring microflow characteristics and highlights the advantages and disadvantages inherent to these experimental techniques. A discussion of system components, experimental measurement and error analyses is included in the paper, with an emphasis on important issues which may have been overlooked in previous research. This study serves as a summary of experimental procedure and is a useful guideline for research in microfluidics. Moreover, several recommendations are proposed for improvement in areas requiring further study.

[1]  J. Welty,et al.  Pressure Drop Measurements in a Microchannel , 1998, Micro-Electro-Mechanical Systems (MEMS).

[2]  Gian Piero Celata,et al.  EXPERIMENTAL INVESTIGATION OF HYDRAULIC AND SINGLE-PHASE HEAT TRANSFER IN 0.130-MM CAPILLARY TUBE , 2002, Proceeding of Heat Transfer and Transport Phenomena in Microscale.

[3]  G. Morini.  Single-phase Convective Heat Transfer in Microchannels: a Review of Experimental Results , 2004 .

[4]  S. Garimella,et al.  A COMPARATIVE ANALYSIS OF STUDIES ON HEAT TRANSFER AND FLUID FLOW IN MICROCHANNELS , 2001, Proceeding of Heat Transfer and Transport Phenomena in Microscale.

[5]  I. Idelchik.  Handbook of Hydraulic Resistance, 2nd Edition , 1987 .

[6]  G. Peterson,et al.  Convective heat transfer and flow friction for water flow in microchannel structures , 1996 .

[7]  T. Kenny,et al.  Measurements and modeling of two-phase flow in microchannels with nearly constant heat flux boundary conditions , 2002 .

[8]  Proceedings of NHTC ’ 01 35 th National Heat Transfer Conference June 10-12 , 2001 , Anaheim , California NHTC 01-12134 EFFECT OF CHANNEL ROUGHNESS ON HEAT TRANSFER AND FLUID FLOW CHARACTERISTICS AT LOW REYNOLDS NUMBERS IN SMALL DIAMETER TUBES , 2001 .

[9]  M. Bahrami.  Modeling of Thermal Joint Resistance for Sphere-Flat Contacts in a Vacuum , 2004 .

[10]  I. Mudawar,et al.  Transport Phenomena in Two-Phase Micro-Channel Heat , 2002 .

[11]  Said I. Abdel-Khalik,et al.  An experimental investigation of single-phase forced convection in microchannels , 1998 .

[12]  Jay N. Zemel,et al.  Liquid Transport In Micron And Submicron Channels , 1989, Optics & Photonics.

[13]  J. Zemel,et al.  Liquid transport in micron and submicron channels , 1990 .

[14]  W. Choi,et al.  Experimental investigation of flow friction for liquid flow in microchannels , 2000 .

[15]  S. Kandlikar,et al.  Effect of Surface Roughness on Heat Transfer and Fluid Flow Characteristics at Low Reynolds Numbers in Small Diameter Tubes , 2003 .

[16]  B. W. Webb,et al.  Characterization of frictional pressure drop for liquid flows through microchannels , 2002 .

[17]  S. Garimella,et al.  Investigation of Liquid Flow in Microchannels , 2002 .

[18]  Dongqing Li,et al.  Flow characteristics of water in microtubes , 1999 .

[19]  Zhi-Xin Li,et al.  EXPERIMENTAL STUDY ON FLOW CHARACTERISTICS OF LIQUID IN CIRCULAR MICROTUBES , 2003 .

[20]  C. Y. Liu,et al.  Laminar flow through microchannels used for microscale cooling systems , 1997, Proceedings of the 1997 1st Electronic Packaging Technology Conference (Cat. No.97TH8307).

[21]  N. Obot.  TOWARD A BETTER UNDERSTANDING OF FRICTION AND HEAT/MASS TRANSFER IN MICROCHANNELS-- A LITERATURE REVIEW , 2000, Proceeding of Heat Transfer and Transport Phenomena in Microscale.

[22]  Huiying Wu,et al.  Friction factors in smooth trapezoidal silicon microchannels with different aspect ratios , 2003 .

[23]  Stéphane Le Person,et al.  Scale effects on hydrodynamics and heat transfer in two-dimensional mini and microchannels , 2002 .

[24]  Björn Palm,et al.  Experimental investigation of single-phase convective heat transfer in circular microchannels , 2004 .

[25]  S. Hsieh,et al.  Liquid flow in a micro-channel , 2006 .

[26]  A. R. Ganji,et al.  Introduction to Engineering Experimentation , 1995 .

[27]  X. Peng,et al.  FRICTIONAL FLOW CHARACTERISTICS OF WATER FLOWING THROUGH RECTANGULAR MICROCHANNELS , 1994 .

[28]  Shung-Wen Kang,et al.  Experimental Investigation of Fluid Flow and Heat Transfer in Microchannels , 2004 .

[29]  Eric M. Kennedy,et al.  Friction factors for pipe flow of xanthan-based concentrates of fire fighting foams , 2005 .

[30]  Ian Papautsky,et al.  A Review of Laminar Single-Phase Flow in Microchannels , 2001, Micro-Electro-Mechanical Systems (MEMS).