Silica-zirconia membranes for nanofiltration

Abstract Inorganic nanofiltration membranes were fabricated from silica–zirconia composite colloidal sol (molar ratio Si/Zr=9/1) using a sol–gel process. Molecular weight cut-off (MWCO) was successfully controlled between 200 and 1000 Da by regulating the colloidal diameters of sol solutions in the final coating stage. The pure water permeabilities ranged from 0.15×10 −11 to 1.5×10 −11  m 3  m −2  s −1  Pa −1 . Pore size and pore size distribution were estimated based on the dynamic method of humid air permeation, and found to be from 1.0 to 2.9 nm. The MWCO obtained from NF experiments using neutral organic solutes corresponds well with the pore diameters estimated from the dynamic permeation method. Silica–zirconia membranes were found to be stable in aqueous solution for periods in excess of four months.

[1]  C. Guizard,et al.  A microporous zirconia membrane prepared by the sol-gel process from zirconyl oxalate , 1994 .

[2]  Shoji Kimura,et al.  Reverse Osmosis of Single and Mixed Electrolytes with Charged Membranes: Experiment and Analysis , 1991 .

[3]  S. Kitao,et al.  Gas Separation Performance of Thin Porous Silica Membrane Prepared by Sol-Gel and CVD Methods , 1992 .

[4]  Robert Rautenbach,et al.  Separation potential of nanofiltration membranes , 1990 .

[5]  Maurice Carles,et al.  Investigation of ion separation by microporous nanofiltration membranes , 1996 .

[6]  S. Nakao,et al.  Peptide and amino acid separation with nanofiltration membranes , 1994 .

[7]  C. A. Smolders,et al.  Permporometry: the determination of the size distribution of active pores in UF membranes , 1992 .

[8]  M. Asaeda.  Preparation of Thin Porous Silica Membranes for Separation of Non-aqueous Organic Solvent Mixtures by Pervaporation , 1992 .

[9]  A. Mey-Marom,et al.  Measurement of active pore size distribution of microporous membranes - a new approach , 1986 .

[10]  T. Yazawa,et al.  Preparation of water and alkali durable porous glass membrane coated on porous alumina tubing by sol-gel method , 1991 .

[11]  Shoji Kimura,et al.  TRANSPORT OF ORGANIC ELECTROLYTES WITH ELECTROSTATIC AND STERIC-HINDRANCE EFFECTS THROUGH NANOFILTRATION MEMBRANES , 1995 .

[12]  A. Larbot,et al.  Rejection of mineral salts on a gamma alumina nanofiltration membrane Application to environmental process , 1995 .

[13]  S. Sarrade,et al.  Dynamic characterization and transport mechanisms of two inorganic membranes for nanofiltration , 1994 .

[14]  A. Larbot,et al.  Preparation of a γ-alumina nanofiltration membrane , 1994 .