Investigating the Characteristics of Two-Phase Flow Using Electrical Capacitance Tomography (ECT) for Three Pipe Orientations

Experiments of gas–liquid flow in a circular pipe for horizontal and inclined positions (upward/downward) are reported. The characteristics of two-phase flow in terms of liquid holdup (e(L)) and induced flow patterns are studied using three experimental techniques; time-averaged e(L) from permittivity profiles using electrical capacitance tomography (ECT), instantaneous e(L) using two fast-closing valves (TFCV), and high-speed camera images (HSCI) to capture/identify the formed flow patterns. Thus, this experimental setup enables the development of more well-defined flow patterns in gas–liquid two-phase flow and allows for multi-technique verification of the results. Taken from experimental measurements, a model is proposed to predict e(L) for high and low situations. The correlations are a function of the hydrodynamic dimensionless quantities which provide hydrodynamic similarity. Regarding different pipe orientations, e(L) predictions are comparable to e(L) from experimental measurements with accepted accuracy: 88% of the predictions are within ±5–15% and 98% are below ±20%. The correlations also were validated by reported results and against correlations available in the literature and show higher prediction accuracy. It is confirmed that the kinematic similarity which is achieved by the gas–liquid velocity ratios and the inertial forces influence the flow pattern and the liquid holdup.

[1]  Experimental study of liquid holdup of liquid-gas two-phase flow in horizontal and inclined pipes , 2017 .

[2]  Wuqiang Yang,et al.  Multiphase Flow Measurement by Electrical Capacitance Tomography and Microwave Cavity Resonant Sensor , 2019, 2019 IEEE International Instrumentation and Measurement Technology Conference (I2MTC).

[3]  L. Shemer,et al.  Evolution of hydrodynamic and statistical parameters of gas-liquid slug flow along inclined pipes , 2003 .

[4]  A. Dukler,et al.  A model for predicting flow regime transitions in horizontal and near horizontal gas‐liquid flow , 1976 .

[5]  G. Hewitt,et al.  Studies of Two-Phase Flow Patterns by Simultaneous X-Ray and Flash Photography , 1969 .

[6]  Qian Wang,et al.  Effects of High Oil Viscosity on Oil/Gas Flow Behavior in Horizontal Pipes , 2008 .

[7]  A study of drift velocity in bubbly two-phase flow under microgravity conditions , 2001 .

[8]  D. Bestion,et al.  The physical closure laws in the CATHARE code , 1990 .

[9]  Said I. Abdel-Khalik,et al.  Gas-liquid two-phase flow in narrow horizontal annuli , 1999 .

[10]  Vivek V. Ranade,et al.  Void fraction measurement using electrical capacitance tomography and high speed photography , 2015 .

[11]  G. Wang,et al.  Measurement of multiple gas-bubble velocities in gas–liquid flows using hot-film anemometry , 2001 .

[12]  Wuqiang Yang,et al.  Electrical capacitance tomography for gas–solids flow measurement for circulating fluidized beds , 2005 .

[13]  Dimensional analysis and scaling in two-phase gas–liquid stratified pipe flow–Methodology evaluation , 2020 .

[14]  Behdad Moghtaderi,et al.  Predicting the solid circulation rate in chemical looping combustion systems using pressure drop measurements , 2015 .

[15]  Behdad Moghtaderi,et al.  A correlation for predicting solids holdup in the dilute pneumatic conveying flow regime of circulating and interconnected fluidised beds , 2016 .

[16]  A. Dastranj,et al.  Different configurations of capacitance sensor for gas/oil two phase flow measurement: An experimental and numerical study , 2017 .

[17]  Neima Brauner,et al.  Holdup of the liquid slug in two phase intermittent flow , 1985 .

[18]  O. Shoham,et al.  Flow pattern transition for vertical downward two phase flow , 1982 .

[19]  Xiaonan Wu,et al.  Stress analysis of parallel oil and gas steel pipelines in inclined tunnels , 2015, SpringerPlus.

[20]  E. A. Hammer,et al.  Capacitance sensor design for reducing errors in phase concentration measurements , 1998 .

[21]  Ghassan H. Abdul-Majeed,et al.  Liquid holdup in horizontal two-phase gas—liquid flow , 1996 .

[22]  Y. Zhao,et al.  Investigation and prediction of slug flow characteristics in highly viscous liquid and gas flows in horizontal pipes , 2015 .

[23]  M. Tutkun,et al.  Holdup and frequency characteristics of slug flow in concentric and fully eccentric annuli pipes , 2019, Journal of Petroleum Science and Engineering.

[24]  J. Thome,et al.  Adiabatic vertical downward air-water flow pattern map: influence of inlet device, flow development length and hysteresis effects , 2013 .

[25]  D. Mewes,et al.  Multielectrode capacitance sensors for the visualization of transient two-phase flows , 1997 .

[26]  Pedram Hanafizadeh,et al.  Light Oil – Gas Two-Phase Flow Pattern Identification in Different Pipe Orientations: An Experimental Approach , 2017 .

[27]  Supachai Bangliang,et al.  The use of simultaneous iterative reconstruction technique for electrical capacitance tomography , 2000 .

[28]  J. P. Brill,et al.  Liquid Holdup in Wet-Gas Pipelines , 1987 .

[29]  Tohru Fukano,et al.  Effects of liquid viscosity on flow patterns in vertical upward gas–liquid two-phase flow , 2001 .

[30]  J.M.H. Fortuin,et al.  Correlations predicting frictional pressure drop and liquid holdup during horizontal gas-liquid pipe flow with a small liquid holdup , 1989 .

[31]  Yuanxin Wu,et al.  Prediction of Pressure Drop and Liquid Holdup in High-Pressure Trickle-Bed Reactors , 1998 .

[32]  P. Spedding,et al.  Holdup in two phase flow , 1984 .

[33]  Eissa Al-Safran,et al.  Effects of High Oil Viscosity on Slug Liquid Holdup in Horizontal Pipes , 2011 .

[34]  J. P. Brill,et al.  Liquid Holdup Correlations for Inclined Two-Phase Flow , 1983 .

[35]  Ovadia Shoham,et al.  Prediction of slug liquid holdup : horizontal to upward vertical flow , 2000 .

[36]  Eissa Al-Safran,et al.  Prediction of Slug Liquid Holdup in Horizontal Pipes , 2009 .

[37]  A. E. Dukler,et al.  Modelling flow pattern transitions for steady upward gas‐liquid flow in vertical tubes , 1980 .

[38]  Jinho Choi,et al.  An Efficient Drift-Flux Closure Relationship to Estimate Liquid Holdups of Gas-Liquid Two-Phase Flow in Pipes , 2012 .

[39]  M. Ishii,et al.  One-dimensional drift-flux model and constitutive equations for relative motion between phases in various two-phase flow regimes , 2003 .

[40]  S. L. Soo,et al.  Multiphase fluid dynamics , 1990 .

[41]  Stein Tore Johansen,et al.  Ledaflow 1D: Simulation Results With Multiphase Gas/Condensate and Oil/Gas Field Data , 2007 .

[42]  Barry J. Azzopardi,et al.  Comparative study of gas–oil and gas–water two-phase flow in a vertical pipe , 2010 .

[43]  Ghassan H. Abdul-Majeed.  Liquid slug holdup in horizontal and slightly inclined two-phase slug flow , 2000 .

[44]  Bikash Mohanty,et al.  A new correlation for holdup in gas-solids cyclone , 2011 .

[45]  Norio Arihara,et al.  Effects of Pressure and Pipe Diameter on Gas-Liquid Two-Phase Flow Behavior in Pipelines , 2003 .

[46]  Wuqiang Yang,et al.  Tomography for multi-phase flow measurement in the oil industry , 2005 .

[47]  W. J. Korchinsky,et al.  Imaging Immiscible Liquid-Liquid Systems by Capacitance Tomography , 1999 .

[48]  U. Hampel,et al.  Evaluation of a limited angle scanned electron beam x-ray CT approach for two-phase pipe flows , 2006 .

[49]  Barry J. Azzopardi,et al.  Experimental study of the hydrodynamic behaviour of slug flow in a vertical riser , 2014 .

[50]  P. J. Hamersma,et al.  A pressure drop correlation for gas/liquid pipe flow with a small liquid holdup , 1987 .

[51]  Hoi Yeung,et al.  High viscosity effects on characteristics of oil and gas two-phase flow in horizontal pipes , 2013 .

[52]  Ning-De Jin,et al.  Water holdup measurement of oil-water two-phase flow with low velocity using a coaxial capacitance sensor , 2017 .

[53]  G. Abdul-Majeed,et al.  A unified correlation for predicting slug liquid holdup in viscous two-phase flow for pipe inclination from horizontal to vertical , 2018, SN Applied Sciences.

[54]  Somchai Wongwises,et al.  Two-phase flow pattern maps for vertical upward gas-liquid flow in mini-gap channels , 2004 .

[55]  F. Garcia-Nocetti,et al.  Visualisation of gas–oil two-phase flows in pressurised pipes using electrical capacitance tomography , 2005 .

[56]  R. W. Time,et al.  Imaging of oil-water flow patterns by Electrical Capacitance Tomography , 2017 .

[57]  Wuqiang Yang,et al.  Adaptive calibration of a capacitance tomography system for imaging water droplet distribution , 2004 .

[58]  Ovadia Shoham,et al.  Flow pattern transition for downward inclined two phase flow; horizontal to vertical , 1982 .

[59]  Jing-yu Xu.  Investigation on average void fraction for air/non-Newtonian power-law fluids two-phase flow in downward inclined pipes , 2010 .

[60]  Anthony J. Peyton,et al.  Chemical engineering applications of electrical process tomography , 2003 .

[61]  Xiaoxiao Dong,et al.  Design of a Conductance and Capacitance Combination Sensor for water holdup measurement in oil–water two-phase flow , 2015 .

[62]  Y. Baba,et al.  Study of high viscous multiphase phase flow in a horizontal pipe , 2018 .

[63]  E. Rhodes,et al.  Non-equilibrium Flows, Part I. Edited by P. P. WEGENER. Marcel Dekker, 1969. 255 pp. $13.75 or £6 11s. , 1970, Journal of Fluid Mechanics.

[64]  Eissa Al-Safran,et al.  Prediction of slug liquid holdup in high viscosity liquid and gas two-phase flow in horizontal pipes , 2015 .