Studying combustion and cyclic irregularity of diethyl ether as supplement fuel in diesel engine

Abstract An experimental study is conducted to evaluate the effects of using diesel fuel blend with diethyl ether (DEE) 24% by vol., a promising fuel that can be produced from biomass (bio-DEE), on the combustion behavior of a standard, direct injection, ‘Hydra’ diesel engine. Combustion chamber and fuel injection pressure diagrams are obtained at four loads, using a high-speed, data acquisition and processing system. A heat release analysis of the experimentally obtained cylinder pressure diagrams and plots of histories in the combustion chamber of the gross heat release rate (HRR) and other related parameters, reveal some interesting features of the combustion mechanism when using DEE blend. Cylinder pressures and temperatures are reduced, HRR diagrams are delayed, and the engine runs overall a little ‘leaner’ at reduced heat losses, with the DEE blend compared to neat diesel fuel for all loads. Moreover, given the shown low ignition quality of DEE/diesel fuel blend and reports for unstable engine operation at high DEE blending ratios, the strength of cyclic (combustion variation) irregularity is examined as reflected in the pressure indicator diagrams, by analyzing for the maximum pressure and rate as well as dynamic injection timing and ignition delay, using stochastic analysis for averages, coefficients of variation, probability density functions, auto-correlations, and cross-correlation coefficients. The stochastic analysis reveals the randomness of fluctuation phenomena observed in the engine, and the cross-correlation coefficients showed that neither the injection process nor the DEE/diesel fuel blend had practical effect on cyclic irregularity.

[1]  C. D. Rakopoulos,et al.  Performance and emissions of bus engine using blends of diesel fuel with bio-diesel of sunflower or cottonseed oils derived from Greek feedstock , 2008 .

[2]  José Rodríguez-Fernández,et al.  Performance, combustion and emissions of a diesel engine operated with reformed EGR. Comparison of diesel and GTL fuelling , 2009 .

[3]  Dimitrios C. Rakopoulos,et al.  Multi-zone modeling of Diesel engine fuel spray development with vegetable oil, bio-diesel or Diesel fuels , 2006 .

[4]  Keith C. Corkwell,et al.  Review of Exhaust Emissions of Compression Ignition Engines Operating on E Diesel Fuel Blends , 2003 .

[5]  C. Bae,et al.  The potential of di-methyl ether (DME) as an alternative fuel for compression-ignition engines: A review , 2008 .

[6]  Su Han Park,et al.  A study of spray strategies on improvement of engine performance and emissions reduction characteris , 2011 .

[7]  James J. Eberhardt,et al.  Diethyl Ether (DEE) as a Renewable Diesel Fuel , 1997 .

[8]  A. Tsolakis,et al.  Engine performance and emissions of a diesel engine operating on diesel-RME (rapeseed methyl ester) blends with EGR (exhaust gas recirculation) , 2007 .

[9]  Alex C. Alkidas,et al.  Combustion advancements in gasoline engines , 2007 .

[10]  C. D. Rakopoulos,et al.  Combustion heat release analysis of ethanol or n-butanol diesel fuel blends in heavy-duty DI diesel engine , 2011 .

[11]  Bruce D. Peters,et al.  Cyclic Variations and Average Burning Rates in a S. I. Engine , 1970 .

[12]  M. Babu,et al.  Application of Diethyl Ether to Reduce Smoke and NOx Emissions Simultaneously With Diesel and Biodiesel Fueled Engines , 2008 .

[13]  Charles A. Amann,et al.  Cylinder-Pressure measurement and Its Use in Engine Research , 1985 .

[14]  N. Mahalakshmi,et al.  Simultaneous reduction of NO x and smoke from a direct-injection diesel engine with exhaust gas recirculation and diethyl ether , 2007 .

[15]  Dimitrios C. Rakopoulos,et al.  Exhaust emissions of diesel engines operating under transient conditions with biodiesel fuel blends , 2012 .

[16]  Dimitrios C. Rakopoulos,et al.  Development and application of multi-zone model for combustion and pollutants formation in direct injection diesel engine running with vegetable oil or its bio-diesel , 2007 .

[17]  Roger B. Krieger,et al.  A Statistical Analysis of the Influence of Cyclic Variation on the Formation of Nitric Oxide in Spark Ignition Engines , 1976 .

[18]  Dimitrios C. Rakopoulos,et al.  Multi-zone modeling of combustion and emissions formation in DI diesel engine operating on ethanol–diesel fuel blends , 2008 .

[19]  C. D. Rakopoulos,et al.  Exhaust emissions with ethanol or n-butanol diesel fuel blends during transient operation: A review , 2013 .

[20]  R. D. Wing.  The Rotary Fuel-Injection Pump as a Source of Cyclic Variation in Diesel Engines, and its Effect on Nitric Oxide Emissions , 1975 .

[21]  Robert L. McCormick,et al.  Combustion of fat and vegetable oil derived fuels in diesel engines , 1998 .

[22]  Dimitrios C. Rakopoulos,et al.  Combustion noise radiation during the acceleration of a turbocharged diesel engine operating with biodiesel or n-butanol diesel fuel blends , 2012 .

[23]  C. D. Rakopoulos,et al.  Investigation of the performance and emissions of bus engine operating on butanol/diesel fuel blends , 2010 .

[24]  Mark A. Theobald,et al.  On the heat-release analysis of diesel engines: Effects of filtering of pressure data , 1987 .

[25]  W. J. D. Annand,et al.  Heat Transfer in the Cylinders of Reciprocating Internal Combustion Engines , 1963 .

[26]  Dimitrios C. Rakopoulos,et al.  Characteristics of performance and emissions in high-speed direct injection diesel engine fueled with diethyl ether/diesel fuel blends , 2012 .

[27]  Dimitrios C. Rakopoulos,et al.  Investigating the emissions during acceleration of a turbocharged diesel engine operating with bio-d , 2010 .

[28]  D. Rakopoulos.  Heat release analysis of combustion in heavy-duty turbocharged diesel engine operating on blends of diesel fuel with cottonseed or sunflower oils and their bio-diesel , 2012 .

[29]  Dimitrios C. Kyritsis,et al.  An experimental comparison of non-premixed bio-butanol flames with the corresponding flames of ethanol and methane , 2011 .

[30]  Maria A. Founti,et al.  Comparative environmental behavior of bus engine operating on blends of diesel fuel with four straight vegetable oils of Greek origin: Sunflower, cottonseed, corn and olive , 2011 .

[31]  C. A. Larsen,et al.  An Optimization Study on the Control of NOx and Particulate Emissions from Diesel Engines , 1996 .

[32]  R. Reitz.  Directions in internal combustion engine research , 2013 .

[33]  C. Lee,et al.  Characteristics of Biofuels and Renewable Fuel Standards , 2010 .

[34]  H. Saunders.  Literature Review : RANDOM DATA: ANALYSIS AND MEASUREMENT PROCEDURES J. S. Bendat and A.G. Piersol Wiley-Interscience, New York, N. Y. (1971) , 1974 .

[35]  Dimitrios C. Rakopoulos,et al.  Comparative performance and emissions study of a direct injection Diesel engine using blends of Diesel fuel with vegetable oils or bio-diesels of various origins , 2006 .

[36]  Chao Jin,et al.  Progress in the production and application of n-butanol as a biofuel , 2011 .

[37]  N. Kapilan,et al.  Effect of Diethyl Ether on the Performance and Emission of a 4 - S Di Diesel Engine , 2003 .

[38]  Richard Stone,et al.  Introduction to Internal Combustion Engines , 1985, Internal Combustion Engines.

[39]  Dimitrios C. Kyritsis,et al.  Electrostatic atomization of hydrocarbon fuels and bio-alcohols for engine applications , 2012 .

[40]  John B. Heywood,et al.  Internal combustion engine fundamentals , 1988 .

[41]  C. D. Rakopoulos,et al.  A stochastic-experimental investigation of the cyclic pressure variation in a di single-cylinder diesel engine , 1992 .

[42]  J. Bendat,et al.  Random Data: Analysis and Measurement Procedures , 1971 .

[43]  Dimitrios C. Rakopoulos,et al.  Investigation of the combustion of neat cottonseed oil or its neat bio-diesel in a HSDI diesel engine by experimental heat release and statistical analyses , 2010 .

[44]  H. O. Pritchard,et al.  Effect of free-radical release on diesel ignition delay under simulated cold-starting conditions , 1990 .

[45]  Dimitrios C. Rakopoulos,et al.  Effects of ethanol-diesel fuel blends on the performance and exhaust emissions of heavy duty DI diesel engine , 2008 .

[46]  Robert S. Barlow,et al.  Piloted jet flames of CH4/H2/air: Experiments on localized extinction in the near field at high Reynolds numbers , 2009 .

[47]  Dimitrios C. Kyritsis,et al.  The combustion of n-butanol/diesel fuel blends and its cyclic variability in a direct injection diesel engine , 2011 .

[48]  Dimitrios C. Rakopoulos,et al.  Experimental heat release analysis and emissions of a HSDI diesel engine fueled with ethanol–diesel fuel blends , 2007 .

[49]  D. Rakopoulos.  Combustion and emissions of cottonseed oil and its bio-diesel in blends with either n-butanol or diethyl ether in HSDI diesel engine , 2013 .

[50]  E. Obert.  Internal combustion engines and air pollution , 1973 .

[51]  C. D. Rakopoulos,et al.  Experimental Heat Release Rate Analysis in Both Chambers of an Indirect Injection Turbocharged Diesel Engine at Various Load and Speed Conditions , 2005 .

[52]  Dimitrios C. Kyritsis,et al.  Experimental-stochastic investigation of the combustion cyclic variability in HSDI diesel engine using ethanol–diesel fuel blends , 2008 .

[53]  L. Ntziachristos,et al.  Biodiesel blend effects on common-rail diesel combustion and emissions , 2010 .

[54]  Naeim A. Henein,et al.  Cycle-to-cycle variation with low ignition quality fuels in a CFR diesel engine , 1979 .

[55]  Robert W. Dibble,et al.  Emissions Performance of Oxygenate-in-Diesel Blends and Fischer-Tropsch Diesel in a Compression Ignition Engine , 1999 .

[56]  A. Ramesh,et al.  Operation of a Compression Ignition Engine on Diesel-Diethyl Ether Blends , 2002 .

[57]  C. D. Rakopoulos,et al.  Effects of butanol–diesel fuel blends on the performance and emissions of a high-speed DI diesel engine , 2010 .