Do huge waves exist in horizontal gas-liquid pipe flow?

Abstract Huge waves are periodic interfacial structures which are observed in vertical co-current gas-liquid two-phase flow under churn and the transition between churn and annular flows. Published data examining vertical gas-liquid flow indicate that a huge wave has either a continuous gas core surrounded by a large-scale interfacial wave or a core with a highly-agitated mixture of gas and liquid. Employing a Wire-Mesh Sensor (WMS), the spatio/temporal investigation of high flow rate horizontal air-water flow divulged some recurrent liquid structures (one may call pseudo-slugs) analogous to huge waves of (vertical) churn flow. In both cases, the blow-through (penetration of gas into the liquid structure) was the most manifest feature. Different qualitative and quantitative methods were employed to compare the behavior of pseudo-slug to churn flow. The quantitative measures included Probability Density Function analysis (PDF), distribution coefficient in drift flux model, structural velocity, core average velocity, interfacial friction factor, and slippage number. Both flow regimes demonstrated similar behavior.

[1]  B. Azzopardi.  Flow Patterns: Does Gas/Solids Flow Pattern Correspond to Churn Flow in Gas/Liquid Flow , 2008 .

[2]  Afshin J. Ghajar,et al.  A flow pattern independent drift flux model based void fraction correlation for a wide range of gas–liquid two phase flow , 2014 .

[3]  N. R. Kesana,et al.  CFD simulation of sand particle erosion under multiphase flow conditions , 2017 .

[4]  K. Aziz,et al.  Intermittent two phase flow in horizontal pipes: Predictive models , 1978 .

[5]  Usama Kadri,et al.  Prediction of the transition from stratified to slug flow or roll-waves in gas-liquid horizontal pipes , 2009 .

[6]  T. J. Hanratty,et al.  Correlation of entrainment for annular flow in vertical pipes , 2002 .

[7]  A. Dukler,et al.  A model for predicting flow regime transitions in horizontal and near horizontal gas‐liquid flow , 1976 .

[8]  Geoffrey F. Hewitt,et al.  Visualisation and modelling studies of churn flow in a vertical pipe , 2001 .

[9]  B. A. Bennett,et al.  Flow visualization studies of boiling at high pressure , 1965 .

[10]  Zai-Sha Mao,et al.  The myth of churn flow , 1993 .

[11]  Eduardo Pereyra,et al.  A methodology and database to quantify the confidence level of methods for gas–liquid two-phase flow pattern prediction , 2012 .

[12]  P. B. Whalley,et al.  Slug flow regime identification from dynamic void fraction measurements in vertical air-water flows , 1997 .

[13]  Barry J. Azzopardi,et al.  Comparison between Electrical Capacitance Tomography and Wire Mesh Sensor Output for Air/Silicone Oil Flow in a Vertical Pipe , 2010 .

[14]  Uwe Hampel,et al.  Assessment of a hybrid CFD model for simulation of complex vertical upward gas–liquid churn flow , 2016 .

[15]  Uwe Hampel,et al.  On the effect of liquid viscosity on interfacial structures within churn flow: Experimental study using wire mesh sensor , 2015 .

[16]  Thomas J. Hanratty,et al.  Effect of pipe diameter on flow patterns for air-water flow in horizontal pipes , 1987 .

[17]  G. Wallis.  One Dimensional Two-Phase Flow , 1969 .

[18]  Alsarkhi Abdelsalam,et al.  New dimensionless number for gas–liquid flow in pipes , 2016 .

[19]  Thomas J. Hanratty,et al.  Detection of slug flow from pressure measurements , 1987 .

[20]  T. Mori,et al.  Gas–liquid interfacial structure and pressure drop characteristics of churn flow , 2004 .

[21]  Barry J. Azzopardi,et al.  Structures in gas–liquid churn flow in a large diameter vertical pipe , 2016 .

[22]  M. E. Charles,et al.  Vertical two-phase flow part I. Flow pattern correlations , 1974 .

[23]  Thomas J. Hanratty,et al.  Influence of Froude number on physical processes determining frequency of slugging in horizontal gas–liquid flows , 1999 .

[24]  Barry J. Azzopardi,et al.  Wisp-like structures in vertical gas–liquid pipe flow revealed by wire mesh sensor studies , 2010 .

[25]  Geoffrey F. Hewitt,et al.  To churn or not to churn , 1993 .

[26]  Neima Brauner,et al.  Slug/churn transition in upward gas-liquid flow , 1986 .

[27]  Arash Soleimani,et al.  Effect of drag-reducing polymers on pseudo-slugs––interfacial drag and transition to slug flow , 2002 .

[28]  Dvora Barnea,et al.  A unified model for predicting flow-pattern transitions for the whole range of pipe inclinations , 1987 .

[29]  Arash Soleimani,et al.  Critical liquid flows for the transition from the pseudo-slug and stratified patterns to slug flow , 2003 .

[30]  Thomas J. Hanratty,et al.  Physics of Gas-Liquid Flows , 2013 .

[31]  Uwe Hampel,et al.  Experimental investigation of interfacial structures within churn flow using a dual wire-mesh sensor , 2015 .