An Accelerated Test Method for Predicting the Useful Life of an LED Driver

This paper proposes an accelerated life-test method for LED drivers that use electrolytic capacitors at the output stage. The type of failure considered here is parametric. Estimated failure rates of power components suggest the electrolytic capacitor used at the driver output stage is the weakest link. As an electrolytic capacitor degrades, its capacitance decreases and its equivalent series resistance increases, contributing to an increase of output current ripple. Thus, the amplitude of the output current ripple is a good indicator of the degradation level of the electrolytic capacitor. Temperature was selected as the acceleration factor because LED drivers are usually exposed to elevated temperatures in typical applications. The current ripple was experimentally found to have a negative impact on light output and efficacy; therefore, the useful life of an LED driver is proposed as the time it takes for the output current ripple to reach its maximum rate of change. The relationship between the capacitor's positive pin temperature and the useful life of the LED driver was then established using the proposed definition. The accelerated life test shows that the LED driver's useful life is shortened exponentially, as the output electrolytic capacitor's operating temperature increases.

[1]  D. Weng,et al.  Quasi-Active Power Factor Correction Circuit for HB LED Driver , 2007, APEC 07 - Twenty-Second Annual IEEE Applied Power Electronics Conference and Exposition.

[2]  W. Minford,et al.  Accelerated Life Testing and Reliability of High K Multilayer Ceramic Capacitors , 1981 .

[3]  M. Pashley,et al.  Red, green, and blue LEDs for white light illumination , 2002 .

[4]  Harada Kousuke,et al.  Use of ESR for deterioration diagnosis of electrolytic capacitor , 1993 .

[5]  Pascal Venet,et al.  Failure prediction of electrolytic capacitors during operation of a switchmode power supply , 1998 .

[6]  George C. Verghese,et al.  Principles of Power Electronics , 2023 .

[7]  Heinz van der Broeck,et al.  Power driver topologies and control schemes for LEDs , 2007, APEC 07 - Twenty-Second Annual IEEE Applied Power Electronics Conference and Exposition.

[8]  E. Henry,et al.  Life Testing of Electronic Power Transformers , 1965 .

[9]  Nadarajah Narendran,et al.  Characterization of thermal resistance coefficient of high-power LEDs , 2006, SPIE Optics + Photonics.

[10]  Xinbo Ruan,et al.  Means of Eliminating Electrolytic Capacitor in AC/DC Power Supplies for LED Lightings , 2009, IEEE Transactions on Power Electronics.

[11]  J. L. Stevens,et al.  The service life of large aluminum electrolytic capacitors: effects of construction and application , 2001, Conference Record of the 2001 IEEE Industry Applications Conference. 36th IAS Annual Meeting (Cat. No.01CH37248).

[12]  M.M. Jovanovic,et al.  LED Driver With Self-Adaptive Drive Voltage , 2008, IEEE Transactions on Power Electronics.

[13]  V. A. Sankaran,et al.  Electrolytic capacitor life testing and prediction , 1997, IAS '97. Conference Record of the 1997 IEEE Industry Applications Conference Thirty-Second IAS Annual Meeting.

[14]  C.K. Tse,et al.  On Driving Techniques for LEDs: Toward a Generalized Methodology , 2009, IEEE Transactions on Power Electronics.

[15]  Thomas W. Dakin,et al.  Life Testing of Electronic Power Transformers-Part II , 1968, IEEE Transactions on Electrical Insulation.

[16]  N. Narendran,et al.  Life of LED-based white light sources , 2005, Journal of Display Technology.

[17]  Lipei Huang,et al.  Progressively converging deadbeat control for UPS inverter , 2006, Twenty-First Annual IEEE Applied Power Electronics Conference and Exposition, 2006. APEC '06..

[18]  T.G. Habetler,et al.  LMS based condition monitoring of electrolytic capacitor , 2005, 31st Annual Conference of IEEE Industrial Electronics Society, 2005. IECON 2005..

[19]  P. Venet,et al.  Influence of aging on electrolytic capacitors function in static converters: Fault prediction method , 1999 .

[20]  Michael L. Gasperi,et al.  Life prediction model for aluminum electrolytic capacitors , 1996, IAS '96. Conference Record of the 1996 IEEE Industry Applications Conference Thirty-First IAS Annual Meeting.

[21]  E RhoadesG,et al.  Expected life of capacitors with non-solid electrolyte. , 1984 .

[22]  Claudio Adragna.  AN1059 APPLICATION NOTE DESIGN EQUATIONS OF HIGH-POWER-FACTOR FLYBACK CONVERTERS BASED ON THE L6561 , 2003 .