Multi-range silicon micromachined flow sensor

A new approach of enlarging the measurement range of a thermal calorimetric flow sensor is presented. It is based on the fact that the response of these kind of sensors tends to saturate at a certain flow ratio, so the widening of the flow range can be achieved by increasing the number of sensing elements of the sensor. This implies only a redesign of the flow sensor device, which is fabricated with an existing standard low cost technology. This approach has been implemented achieving measurement ranges from 0.1 up to 8 SLM by placing three different pairs of sensing resistors on the same membrane. Characterisation results and a simulation-based procedure to design flow sensors according to specific applications are included.

[1]  Gerald Urban,et al.  Wide range semiconductor flow sensors , 2000 .

[2]  Carles Cane,et al.  Low-cost thermal flow sensor for home-appliances applications , 2002, Symposium on Design, Test, Integration, and Packaging of MEMS/MOEMS.

[3]  G. Wachutka,et al.  Fabrication and modelling of CMOS microbridge gas-flow sensors , 1992 .

[4]  W. Dötzel,et al.  Asymmetrical locations of heaters and sensors relative to each other using heater arrays: a novel method for designing multi-range electrocaloric mass-flow sensors , 1997 .

[5]  G. Stemme,et al.  Three dimensional silicon triple-hot-wire anemometer based on polyimide joints , 1998, Proceedings MEMS 98. IEEE. Eleventh Annual International Workshop on Micro Electro Mechanical Systems. An Investigation of Micro Structures, Sensors, Actuators, Machines and Systems (Cat. No.98CH36176.

[6]  Tsugihiko Takumi,et al.  A polysilicon flow sensor for gas flow meters , 1996 .

[7]  C. Cane,et al.  A test structure for the design of thermal flow sensors , 2002, Proceedings of the 2002 International Conference on Microelectronic Test Structures, 2002. ICMTS 2002..

[8]  Jan H. J. Fluitman,et al.  Micro-liquid flow sensor , 1993 .

[9]  Frédérick Mailly,et al.  Anemometer with hot platinum thin film , 2001 .

[10]  Ahmed Al-Salaymeh,et al.  Development and testing of a novel single-wire sensor for wide range flow velocity measurements , 2004 .

[11]  F. Masana,et al.  Design end fabrication of a low cost water flow meter , 1997, Proceedings of International Solid State Sensors and Actuators Conference (Transducers '97).