On the shear thickening flow of dilute CTAT worm-like micellar solutions

Dilute solutions of worm-like micelles exhibit shear thickening caused by microstructural changes under specific flow conditions. In this work, for the first time, shear thickening in parallel plate and Poiseuille flows is investigated using simultaneously particle image velocimetry (PIV) and rheometry. Four distinctive zones of flow behavior are identified in parallel plates as the shear rate increases, namely, a Newtonian region, a transition regime where inhomogeneous nucleation of the shear-induced structures (SIS) is followed by homogeneous nucleation of SIS, and an apparent second-Newtonian regime at high shear rates, where rapid temporal fluctuations of the viscosity are smoothed out by inertia of the moving plate. In pipe pressure flow, PIV results reveal a flow pattern consisting of a superposition of two parabolic regions of the velocity profile located near the center and close to the pipe walls, and a transition region where again strong fluctuations in the velocity profile are observed. The experimental results are compared with predictions of a convected Maxwell constitutive equation coupled to a kinetic equation that accounts for an increase in dissipation of the system due to the presence of the SIS. The model accounts for the average steady values of the viscosity in the structured thickened state.

[1]  S. Koch,et al.  The velocity field of dilute cationic surfactant solutions in a Couette-viscometer , 1998 .

[2]  O. Manero,et al.  Rheology of the Cetyltrimethylammonium Tosilate−Water System. 2. Linear Viscoelastic Regime , 1996 .

[3]  R. Cressely,et al.  Occurrence of shear thickening in aqueous micellar solutions of CTAB with some added organic counterions , 1998 .

[4]  L. Walker,et al.  Flow-structure relationship of shear-thickening surfactant solutions , 1998 .

[5]  Liu,et al.  Shear-Induced Gelation and Fracture in Micellar Solutions. , 1996, Physical review letters.

[6]  O. Manero,et al.  Flow regimes of dilute surfactant solutions , 2001 .

[7]  Shi‐Qing Wang,et al.  Rheological and flow birefringence studies of a shear‐thickening complex fluid—A surfactant model system , 1993 .

[8]  O. Manero,et al.  Rheology of Cetyltrimethylammonium p-Toluenesulfonate−Water System. 3. Nonlinear Viscoelasticity , 1999 .

[9]  Eric F. Matthys,et al.  Characterization of micellar structure dynamics for a drag-reducing surfactant solution under shear: normal stress studies and flow geometry effects , 1995 .

[10]  H. Rehage,et al.  Shear induced phase transitions in highly dilute aqueous detergent solutions , 1982 .

[11]  H. Rehage,et al.  Flow birefringence and rheological measurements on shear induced micellar structures , 1987 .

[12]  R. Cressely,et al.  Shear Thickening of an Aqueous Micellar Solution of Cetyltrimethylammonium Bromide and Sodium Tosylate , 1997 .

[13]  D. Pine,et al.  Shear thickening in low-concentration solutions of wormlike micelles. I. Direct visualization of transient behavior and phase transitions , 1998 .

[14]  O. Manero,et al.  Irreversible Thermodynamics Approach and Modeling of Shear-Banding Flow of Wormlike Micelles , 2002 .

[15]  O. Manero,et al.  Dynamics of worm-like micelles: the Cox–Merz rule , 2002 .

[16]  O. Manero,et al.  Understanding thixotropic and antithixotropic behavior of viscoelastic micellar solutions and liquid crystalline dispersions. I. The model , 1999 .

[17]  P. Lindner,et al.  Shear-induced micellar growth in dilute surfactant solutions , 2001 .

[18]  O. Manero,et al.  On the shear banding flow of elongated micellar solutions , 2000 .

[19]  Coexistence and phase separation in sheared complex fluids , 1997, cond-mat/9705181.

[20]  L. Walker,et al.  Shear-Thickening Dilute Surfactant Solutions: Equilibrium Structure As Studied by Small-Angle Neutron Scattering , 1999 .

[21]  Springer,et al.  Light Scattering Experiments on Shear Induced Structures of Micellar Solutions , 1997, Journal of colloid and interface science.

[22]  J. Harden,et al.  Inhomogeneous Flows of Complex Fluids: Mechanical Instability Versus Non-Equilibrium Phase Transition , 1997 .

[23]  P. Brunn,et al.  The complex rheological behavior of an aqueous cationic surfactant solution investigated in a Couette-type viscometer , 1989 .