Improving the electromechanical performance of dielectric elastomers using silicone rubber and dopamine coated barium titanate

Abstract In this work, a new soft dielectric elastomer (DE) was fabricated from dopamine coated barium titanate particles and silicone rubber (SR). The results showed that the barium titanate (BaTiO 3 , BT) was coated by dopamine and the coated particles were highly compatible with SR. In order to achieve a maximum voltage-induced deformation, the minimum secant moduli of DEs were obtained in experimentation at a stretch ratio of approximately 1.6 by applying equi-biaxial tensile strain using the bubble inflation method. Additionally, it was found that the addition of DP-BT into SR led to an increased dielectric constant and decreased dielectric loss tangent for the matrix by comparison with SR/BT composites. Furthermore, the electromechanical properties of the SR/DP-BT composites were greatly improved in terms of voltage-induced deformation ( s a ), electromechanical energy density ( e ) and coupling efficiency ( K 2 ). A maximum actuated area strain of approximately 78%, which was 30% larger than that of the SR/BT composites, was achieved for the sample having a DP-BT content of 20 wt.%. This strain corresponded to a low dielectric strength of around 53 V/μm, the composite exhibited a maximum energy density of 0.07 MJ/m 3 and coupling efficiency of 0.68.

[1]  Q. Pei,et al.  Advances in dielectric elastomers for actuators and artificial muscles. , 2010, Macromolecular rapid communications.

[2]  Min Zhou,et al.  Orientation and size dependence of the elastic properties of zinc oxide nanobelts , 2005 .

[3]  Q. Pei,et al.  High-field deformation of elastomeric dielectrics for actuators , 2000 .

[4]  Q. Pei,et al.  High-speed electrically actuated elastomers with strain greater than 100% , 2000, Science.

[5]  R. Janoschek,et al.  Extremely high polarizability of hydrogen bonds , 1972 .

[6]  M. Tian,et al.  New polyester dielectric elastomer with large actuated strain at low electric field , 2012 .

[7]  N. Muensit,et al.  Interface Polarization Effect on Dielectric and Electrical Properties of Polyurethane (PU)/Polyaniline (PANI) Polymer Composites , 2013 .

[8]  A. Kontos,et al.  Nanostructured TiO2 films for DSSCS prepared by combining doctor-blade and sol–gel techniques , 2008 .

[9]  Xuanhe Zhao,et al.  Harnessing large deformation and instabilities of soft dielectrics: Theory, experiment, and application , 2014 .

[10]  Kai Yu,et al.  New silicone dielectric elastomers with a high dielectric constant , 2008, SPIE Smart Structures and Materials + Nondestructive Evaluation and Health Monitoring.

[11]  幕内 恵三,et al.  Radiation processing of polymer materials and its industrial applications , 2012 .

[12]  E. Mazza,et al.  Multiaxial deformation and failure of acrylic elastomer membranes , 2012 .

[13]  Yang Shen,et al.  Improving the dielectric constants and breakdown strength of polymer composites: effects of the shape of the BaTiO3 nanoinclusions, surface modification and polymer matrix , 2012 .

[14]  Xuanhe Zhao,et al.  Mechanical Constraints Enhance Electrical Energy Densities of Soft Dielectrics , 2011 .

[15]  R. Landel,et al.  Mechanical Properties of Polymers and Composites , 1993 .

[16]  Z. Suo,et al.  Mechanisms of Large Actuation Strain in Dielectric Elastomers , 2011 .

[17]  Z. Suo.  Theory of dielectric elastomers , 2010 .

[18]  Ja Choon Koo,et al.  Development of integrated tactile display devices , 2009, Smart Structures and Materials + Nondestructive Evaluation and Health Monitoring.

[19]  C. Keplinger,et al.  Harnessing snap-through instability in soft dielectrics to achieve giant voltage-triggered deformation , 2012 .

[20]  S. Bose,et al.  Effect of Particle Size of Filler on Properties of Nylon-6 , 2004 .

[21]  S. Kaskel,et al.  Investigations of mussel-inspired polydopamine deposition on WC and Al2O3 particles: The influence of particle size and material , 2014 .

[22]  Vijay Kumar Thakur,et al.  Surface functionalization of BaTiO3 nanoparticles and improved electrical properties of BaTiO3/polyvinylidene fluoride composite , 2011 .

[23]  Junhua Qiang,et al.  Experimental study on the dielectric properties of polyacrylate dielectric elastomer , 2012 .

[24]  R. Vaidyanathan,et al.  Spray deposited multilayered dielectric elastomer actuators , 2011 .

[25]  D. Rossi,et al.  Dielectric constant enhancement in a silicone elastomer filled with lead magnesium niobate–lead titanate , 2007 .

[26]  Zhigang Suo,et al.  Extension limit, polarization saturation, and snap-through instability of dielectric elastomers , 2011 .

[27]  T. Ghosh,et al.  Dielectric elastomers as next-generation polymeric actuators. , 2007, Soft matter.

[28]  Samuel Rosset,et al.  Self-sensing dielectric elastomer actuators in closed-loop operation , 2013 .

[29]  Longtu Li,et al.  Fabrication, characterization, properties and theoretical analysis of ceramic/PVDF composite flexible films with high dielectric constant and low dielectric loss , 2014 .

[30]  G. Kovács,et al.  Dielectric elastomer actuators used for pneumatic valve technology , 2013 .

[31]  Hyoukryeol Choi,et al.  Development of Soft-Actuator-Based Wearable Tactile Display , 2008, IEEE Transactions on Robotics.

[32]  Peter J. Hotchkiss,et al.  Phosphonic Acid‐Modified Barium Titanate Polymer Nanocomposites with High Permittivity and Dielectric Strength , 2007 .

[33]  G. Madras,et al.  Process induced electroactive β-polymorph in PVDF: effect on dielectric and ferroelectric properties. , 2014, Physical chemistry chemical physics : PCCP.

[34]  S. Jerrams,et al.  The Significance of Equi-Biaxial Bubble Inflation in Determining Elastomeric Fatigue Properties , 2012 .

[35]  C. Jean-Mistral,et al.  Impact of the nature of the compliant electrodes on the dielectric constant of acrylic and silicone electroactive polymers , 2012 .

[36]  M. Alam,et al.  Synthesis and Characterization of Barium Titanate (BaTiO3) Nanoparticle , 2012 .

[37]  S. Michel,et al.  A comparison between silicone and acrylic elastomers as dielectric materials in electroactive polymer actuators , 2009 .

[38]  M. Tian,et al.  A high-performance dielectric elastomer consisting of bio-based polyester elastomer and titanium dioxide powder , 2013 .

[39]  Jinsong Leng,et al.  An investigation on electromechanical stability of dielectric elastomers undergoing large deformation , 2009 .

[40]  T. Nishi,et al.  Separated-structured all-organic dielectric elastomer with large actuation strain under ultra-low voltage and high mechanical strength , 2015 .

[41]  Shuhai Jia,et al.  Dynamic electromechanical performance of viscoelastic dielectric elastomers , 2013 .

[42]  Jinsong Leng,et al.  Dielectric elastomer film actuators: characterization, experiment and analysis , 2009 .

[43]  M. Tian,et al.  Enhanced dielectric properties and actuated strain of elastomer composites with dopamine-induced surface functionalization , 2013 .

[44]  Sheng Liu,et al.  A compact electroactive polymer actuator suitable for refreshable Braille display , 2007, SPIE Smart Structures and Materials + Nondestructive Evaluation and Health Monitoring.

[45]  Chuan Yi Tang,et al.  A 2.|E|-Bit Distributed Algorithm for the Directed Euler Trail Problem , 1993, Inf. Process. Lett..

[46]  Tianhu He,et al.  The effect of prestretch on the performance of a dielectric elastomer membrane , 2011, 2011 International Conference on Remote Sensing, Environment and Transportation Engineering.

[47]  Pengyu Y. Ren,et al.  Polarizable Atomic Multipole-based Molecular Mechanics for Organic Molecules. , 2011, Journal of chemical theory and computation.

[48]  P Lotz,et al.  Fabrication and Application of Miniaturized Dielectric Elastomer Stack Actuators , 2011, IEEE/ASME Transactions on Mechatronics.