Adsorption of Reactive Red 120 in Decamethyl-Cyclopentasiloxane Non-Aqueous Dyeing System

Traditional dyeing usually consumes a significant amount of water and salts, thus causing environmental pollution. Salt-free and low-water dyeing has become an important research direction in the cotton fabric dyeing industry. The non-aqueous media dyeing technology, using decamethylcyclopentasiloxane (D5) as the dyeing medium, has achieved energy saving and emission reduction in this industry. To investigate the influence of inorganic salts on the dyeing properties of reactive dyes in a non-aqueous medium dyeing system, the adsorption kinetics and level dyeing property of C.I. Reactive Red 120 were investigated at various concentrations of sodium sulfate. When no salts were included in the siloxane non-aqueous dyeing system, 80% of the reactive dye could diffuse onto the cotton fabric surface after 10 min. However, if 13% salts were added during dyeing, 87% of the reactive dye could diffuse to cotton fabric surface over the same amount of time. Moreover, the adsorption rate of dye was increased from 3.85 mg/g·min to 5.04 mg/g·min when the quantity of salts was increased from 0% to 13%. However, the concentration of sodium sulfate had minimal effect on the color depth of the dyed fabric and the final uptake of dye. But, when the concentration of sodium sulfate was significant, the level dyeing property of the dye became poor as the Sγ(λ) value was increased from 0.020 to 0.042. The adsorption kinetic of C.I. Reactive Red 120 in D5 dyeing solution may be best described by the pseudo-second-order kinetic model. As the sodium sulfate concentration increases, the half-dyeing time gradually decreases and the adsorption rate of dye increases. The repulsive force between the dye and the cotton fiber was lowered by the addition of sodium sulfate. Consequently, in the D5 dyeing system, the level dyeing property of reactive dye may be affected by the adsorption rate. Therefore, the formula of reactive dyes that do not contain salts can be applied successfully in non-aqueous dyeing systems.

[1]  A. Sayem,et al.  Sustainable Adsorbents from Plant-Derived Agricultural Wastes for Anionic Dye Removal: A Review , 2022, Sustainability.

[2]  Liujun Pei,et al.  Salt-free dyeing of cotton fabric and adsorption of reactive dyes in non-aqueous dyeing system: equilibrium, kinetics, and thermodynamics , 2022, Cellulose.

[3]  Dagang Miao,et al.  Enhanced Dyeability and Wash Fastness through a Salt-Free Plasma-Induced Grafting of Cationic Monomers on Cotton Fabrics , 2021, Fibers and Polymers.

[4]  M. Shao,et al.  Thermodynamic properties of cotton dyeing with indigo dyes in non-aqueous media of liquid paraffin and D5 , 2021, Textile Research Journal.

[5]  S. Lee,et al.  High-Level Production of the Natural Blue Pigment Indigoidine from Metabolically Engineered Corynebacterium glutamicum for Sustainable Fabric Dyes , 2021 .

[6]  M. Banchero.  Recent advances in supercritical fluid dyeing , 2020 .

[7]  G. Ke,et al.  Ultrasonic Effects on the Kinetics and Thermodynamics of Dyeing Wool Fiber with Reactive Dye , 2020, Fibers and Polymers.

[8]  Jianzhong Shao,et al.  Study on a water-saving and salt-free reactive dyeing of cotton fabrics in non-aqueous medium of liquid paraffin system , 2020 .

[9]  Liujun Pei,et al.  Sustainable wool fibers dyeing using henna extract in non-aqueous medium , 2019, Environmental Chemistry Letters.

[10]  Liujun Pei,et al.  Improvement of the Rubbing Fastness of Cotton Fiber in Indigo/Silicon Non-Aqueous Dyeing Systems , 2019, Polymers.

[11]  Laijiu Zheng,et al.  Supercritical CO2 dyeing for nylon, acrylic, polyester, and casein buttons and their optimum dyeing conditions by design of experiments , 2019, Journal of CO2 Utilization.

[12]  Chengbing Yu,et al.  Salt-Free Dyeing of Cotton Fabric Using 3-Chloro-2-Hydroxypropyltrimethyl Ammonium Chloride by Pad-Irradiate-Pad-Steam Process, and Prediction of Its K/S Value by LS-SVM , 2019, Journal of Natural Fibers.

[13]  Jin-xin He,et al.  Study on the salt-free low-alkaline reactive cotton dyeing in high concentration of ethanol in volume , 2019, Journal of Cleaner Production.

[14]  M. Hubbe,et al.  Implications of apparent pseudo-second-order adsorption kinetics onto cellulosic materials: A review , 2019, BioResources.

[15]  I. A. Nääs,et al.  The sustainability awareness of Brazilian consumers of cotton clothing , 2019, Journal of Cleaner Production.

[16]  X. Gu,et al.  Diffusion Mechanism of Aqueous Solutions and Swelling of Cellulosic Fibers in Silicone Non-Aqueous Dyeing System , 2019, Polymers.

[17]  Liujun Pei,et al.  Influence of Ethylene Oxide Content in Nonionic Surfactant to the Hydrolysis of Reactive Dye in Silicone Non-Aqueous Dyeing System , 2018, Polymers.

[18]  X. Gu,et al.  Dyeing Property and Adsorption Kinetics of Reactive Dyes for Cotton Textiles in Salt-Free Non-Aqueous Dyeing Systems , 2018, Polymers.

[19]  Liujun Pei,et al.  Study of dichlorotriazine reactive dye hydrolysis in siloxane reverse micro-emulsion , 2017 .

[20]  Liujun Pei,et al.  Effect of Nonionic Surfactant on the Micro-Emulsifying Water in Silicone Media , 2017 .

[21]  A. Kroumov,et al.  Kinetic, equilibrium and thermodynamic phenomenological modeling of reactive dye adsorption onto polymeric adsorbent , 2017 .

[22]  Q. Zhong,et al.  Adsorption Kinetics of Amide Softeners on Cotton Fabrics in Decamethyl Cyclopentasiloxane Medium , 2016 .

[23]  M. Hasan,et al.  Application of Purified Lawsone as Natural Dye on Cotton and Silk Fabric , 2015 .

[24]  Jianzhong Shao,et al.  A non-aqueous dyeing process of reactive dye on cotton , 2015 .

[25]  Awais Khatri,et al.  A review on developments in dyeing cotton fabrics with reactive dyes for reducing effluent pollution , 2015 .

[26]  Shixiong Yi,et al.  Adsorption and dyeing characteristics of reactive dyes onto cotton fiber in nonionic Triton X-100 reverse micelles , 2014, Fibers and Polymers.

[27]  Mehran Alaee,et al.  Concentrations of cyclic volatile methylsiloxanes in biosolid amended soil, influent, effluent, receiving water, and sediment of wastewater treatment plants in Canada. , 2013, Chemosphere.

[28]  J. Gutmann,et al.  Pretreatment of cotton fabrics with polyamino carboxylic acids for salt‐free dyeing of cotton with reactive dyes , 2013 .

[29]  S. H. Amirshahi,et al.  The kinetic and thermodynamic parameters of dyeing of polypropylene/Clay composite fibers using disperse dye , 2012 .

[30]  Sung Dong Kim,et al.  Dyeing properties of nylon, PET, and N/P mixture fabric with reactive-disperse dyes having a sulfatoethylsulfone group , 2012, Fibers and Polymers.

[31]  Puspendu Bhunia,et al.  A review on chemical coagulation/flocculation technologies for removal of colour from textile wastewaters. , 2012, Journal of environmental management.

[32]  Wei Wang,et al.  Supercritical Fluid Spray Dyeing: A New Method of Dyeing and Simulations of its Flow Field , 2011 .

[33]  K. Y. Foo,et al.  Insights into the modeling of adsorption isotherm systems , 2010 .

[34]  D. Lewis,et al.  Design and application of a multifunctional reactive dye capable of high fixation efficiency on cellulose , 2008 .

[35]  Zhihua Wang,et al.  Reverse microemulsion-directed synthesis of hydroxyapatite nanoparticles under hydrothermal conditions , 2007 .

[36]  P. Petrolekas,et al.  Kinetic studies of the liquid-phase adsorption of a reactive dye onto activated lignite , 2007 .

[37]  K. Sawada,et al.  Adsorption and fixation of a reactive dye on cotton in non-aqueous systems , 2003 .

[38]  M S Chiou,et al.  Adsorption behavior of reactive dye in aqueous solution on chemical cross-linked chitosan beads. , 2003, Chemosphere.

[39]  Feng-Chin Wu,et al.  Kinetic modeling of liquid-phase adsorption of reactive dyes and metal ions on chitosan. , 2001, Water research.

[40]  Gordon McKay,et al.  The kinetics of sorption of divalent metal ions onto sphagnum moss peat , 2000 .

[41]  H. Tamai,et al.  Dye adsorption on mesoporous activated carbon fiber obtained from pitch containing yttrium complex and tha acid treatment effects , 1998 .

[42]  E. J. Weber,et al.  Hydrolysis kinetics of Reactive Blue 19-Vinyl Sulfone , 1993 .

[43]  G. Alberti,et al.  Thermodynamic Features in Acrylic Fiber Dyeing with Basic Dyes , 1984 .

[44]  G. L. Madan,et al.  Physical Chemistry of Dyeing of Cellulosic Fibers with Reactive Dyes , 1979 .