Application of fluoroalkylsilanes (FAS) grafted ceramic membranes in membrane distillation process of NaCl solutions

Abstract Novel fluorosilanes grafted ceramic membranes were prepared and characterized in the air-gap membrane distillation (AGMD) process. The hydrophobic active layer was created by grafting 1H,1H,2H,2H-perfluorodecyltriethoxysilane (C8 compound) on the commercial ceramic membrane (zirconia layer on the microporous alumina support). Two kinds of commercial membranes were used with average pore diameter of the zirconia layer equal to 50 or 200 nm. Four hydrophobic membranes were prepared using different grafting conditions. The efficiency of grafting process was characterized by TGA, contact angle and liquid water entry pressure (LEP) measurements. These new kinds of hydrophobic ceramic membranes were applied in the membrane distillation (MD) process. The influence of NaCl concentration and feed/permeate temperature difference on the efficiency of MD process were determined. The rejection of NaCl was found to be close 100%, indicating good hydrophobic behaviour of the FAS grafted ceramic membranes. The permeate fluxes were dependent of the NaCl concentration, pore diameter of the zirconia layer and the temperature difference between feed and permeate side of the membrane. The average flux of about 6.67 L/(m 2  h) was found for M1 and M2 membranes in contact with pure water and at feed/permeate temperatures equal 95 and 5 °C, respectively. The flux of about 5.42 L/(m 2  h) was found for M3 membrane in contact with 1 M NaCl solution and feed/permeate temperatures equal 99 and 5 °C, respectively. This is the first broader study of the use of modified ceramic membranes in MD process.

[1]  Wojciech Kujawski,et al.  Water desalination using ceramic membrane distillation , 2004 .

[2]  Yoram Cohen,et al.  Topological AFM characterization of graft polymerized silica membranes , 2003 .

[3]  Ricard Garcia-Valls,et al.  Modification of ceramic membranes by alcohol adsorption , 2002 .

[4]  Y. Cohen,et al.  Ceramic-supported polymer membranes for pervaporation of binary organic/organic mixtures , 2003 .

[5]  Daniel Schondelmaier,et al.  Orientation and Self-Assembly of Hydrophobic Fluoroalkylsilanes , 2002 .

[6]  M. Gryta,et al.  Mass transfer of HCl and H2O across the hydrophobic membrane during membrane distillation , 2000 .

[7]  Y. Cohen,et al.  A Novel Ceramic-Supported Polymer Membrane for Pervaporation of Dilute Volatile Organic Compounds , 1999 .

[8]  P. Carr,et al.  Physical and chemical characterization of microporous zirconia , 1990 .

[9]  T. Minami,et al.  Water-repellent coating films on glass prepared from hydrolysis and polycondensation reactions of fluoroalkyltrialkoxylsilane , 2001 .

[10]  V. Ugrozov,et al.  Theoretical and experimental research of liquid-gap membrane distillation process in membrane module , 2003 .

[11]  A. Larbot,et al.  Grafting γ alumina microporous membranes by organosilanes:: Characterisation by pervaporation , 1998 .

[12]  D. M. Ford,et al.  Solubility-based gas separation with oligomer-modified inorganic membranes , 2001 .

[13]  Christian Guizard,et al.  Inorganic membranes and solid state sciences , 2000 .

[14]  Noam Lior,et al.  Membrane-distillation desalination: Status and potential , 2005 .

[15]  A. B. de Haan,et al.  Air gap membrane distillation: 2. Model validation and hollow fibre module performance analysis , 2005 .

[16]  L. Martinez-diez,et al.  Desalination of brines by membrane distillation , 2001 .

[17]  M. Tomaszewska,et al.  Preparation and properties of flat-sheet membranes from poly(vinylidene fluoride) for membrane distillation , 1996 .

[18]  J. Caro,et al.  Chemically modified ceramic membranes , 1998 .

[19]  Fawzi Banat,et al.  Theoretical and experimental study in membrane distillation , 1994 .

[20]  Antoni W. Morawski,et al.  Recovery of hydrochloric acid from metal pickling solutions by membrane distillation , 2001 .

[21]  P. Wilderer,et al.  Ozone–water contacting by ceramic membranes , 2001 .

[22]  H. Monbouquette,et al.  Shear-induced permeability changes in a polymer grafted silica membrane , 2000 .

[23]  R. Podsiadły,et al.  Fundamentals on inorganic membranes: present and new developments , 2003 .

[24]  W. Shiu,et al.  A review of the effect of salts on the solubility of organic compounds in seawater , 1997 .

[25]  Y. Cohen,et al.  Removal of methyl tert-butyl ether from water by pervaporation using ceramic-supported polymer membranes , 2004 .

[26]  M. C. García-Payo,et al.  Separation of binary mixtures by thermostatic sweeping gas membrane distillation: II. Experimental results with aqueous formic acid solutions , 2002 .

[27]  M. C. García-Payo,et al.  Separation of binary mixtures by thermostatic sweeping gas membrane distillation: I. Theory and simulations , 2002 .

[28]  Noam Lior,et al.  Transport analysis of air-gap membrane distillation , 2005 .

[29]  F. Dijoux,et al.  Grafting of ZrO2 powder and ZrO2 membrane by fluoroalkylsilanes , 2004 .

[30]  Mahmoud Dhahbi,et al.  Fluidised bed crystalliser and air gap membrane distillation as a solution to geothermal water desalination , 2003 .

[31]  Y. Cohen,et al.  On the Loss of Hydraulic Permeability in Ceramic Membranes , 1996 .

[32]  André Larbot,et al.  Characterisation of hydrophilic ceramic membranes modified by fluoroalkylsilanes into hydrophobic membranes , 2004 .

[33]  K.S.M.S. Raghavarao,et al.  Acoustic field-assisted osmotic membrane distillation , 2002 .

[34]  Y. Cohen,et al.  Fouling-resistant ceramic-supported polymer membranes for ultrafiltration of oil-in-water microemulsions , 2001 .

[35]  K. Bani-Melhem,et al.  Sensitivity Analysis of Air Gap Membrane Distillation , 2003 .

[36]  Y. Cohen,et al.  Protein Adsorption onto Zirconia Modified with Terminally Grafted Polyvinylpyrrolidone. , 2001, Journal of colloid and interface science.

[37]  Wilhelm F. Maier,et al.  hydrophobic silica membranes for gas separation , 1999 .

[38]  Roland Wimmerstedt,et al.  Membrane distillation - a theoretical study of evaporation through microporous membranes , 1985 .

[39]  H. Monbouquette,et al.  Silica-suported polyvinylpyrrolidone filtration membranes , 1996 .

[40]  Anthony G. Fane,et al.  Heat and mass transfer in membrane distillation , 1987 .

[41]  D. Lucas,et al.  Role of the physico-chemical environment on ultrafiltration of lysozyme with modified inorganic membrane , 1998 .

[42]  Antoni W. Morawski,et al.  Ethanol production in membrane distillation bioreactor , 2000 .

[43]  Antoni W. Morawski,et al.  Membrane distillation of NaCl solution containing natural organic matter , 2001 .

[44]  Anthony G. Fane,et al.  Gas and vapour transport through microporous membranes. II. Membrane distillation , 1990 .

[45]  Bernard Boutevin,et al.  Grafting of ceramic membranes by fluorinated silanes: hydrophobic features , 2001 .

[46]  H. Monbouquette,et al.  The permeability behavior of polyvinylpyrrolidone-modified porous silica membranes , 1993 .

[47]  K.S.M.S. Raghavarao,et al.  Membrane distillation for the concentration of raw cane-sugar syrup and membrane clarified sugarcane juice☆ , 2002 .

[48]  Pedro Prádanos,et al.  Characterisation of three hydrophobic porous membranes used in membrane distillation , 2002 .

[49]  M. Maalej,et al.  Experimental study of air gap and direct contact membrane distillation configurations: application to geothermal and seawater desalination , 2004 .

[50]  Christian Leger,et al.  Preparation and properties of surface modified ceramic membranes. Part II. Gas and liquid permeabilities of 5 nm alumina membranes modified by a monolayer of bound polydimethylsiloxane (PDMS) silicone oil , 1996 .

[51]  E. Drioli,et al.  Microporous membranes in membrane distillation , 1986 .

[52]  H. A. Abu Qdais,et al.  The role of desalination in bridging the water gap in Jordan , 2002 .

[53]  A. B. Haan,et al.  Modelling of a transmembrane evaporation module for desalination of seawater , 1999 .

[54]  C. W. Leung,et al.  Theoretical and experimental studies on air gap membrane distillation , 1998 .

[55]  M. Dornier,et al.  The problem of membrane characterization for the process of osmotic distillation , 2001 .