Real-time digital simulation of power electronics systems with Neutral Point Piloted multilevel inverter using FPGA

Abstract Most of actual real time simulation platforms have practically about ten microseconds as minimum calculation time step, mainly due to computation limits such as processing speed, architecture adequacy and modeling complexities. Therefore, simulation of fast switching converters’ instantaneous models requires smaller computing time step. The approach presented in this paper proposes an answer to such limited modeling accuracies and computational bandwidth of the currently available digital simulators.As an example, the authors present a low cost, flexible and high performance FPGA-based real-time digital simulator for a complete complex power system with Neutral Point Piloted (NPP) three-level inverter. The proposed real-time simulator can model accurately and efficiently the complete power system, reducing costs, physical space and avoiding any damage to the actual equipment in the case of any dysfunction of the digital controller prototype. The converter model is computed at a small fixed time step as low as 100 ns. Such a computation time step allows high precision account of the gating signals and thus avoids averaging methods and event compensations. Moreover, a novel high performance model of the NPP three-level inverter has also been proposed for FPGA implementation. The proposed FPGA-based simulator models the environment of the NPP converter: the dc link, the RLE load and the digital controller and gating signals. FPGA-based real time simulation results are presented and compared with offline results obtained using PLECS software. They validate the efficiency and accuracy of the modeling for the proposed high performance FPGA-based real-time simulation approach. This paper also introduces new potential FPGA-based applications such as low cost real time simulator for power systems by developing a library of flexible and portable models for power converters, electrical machines and drives.

[1]  Hui Li,et al.  Expansion application of dSPACE for HILS , 2008, 2008 IEEE International Symposium on Industrial Electronics.

[2]  V. Rajagopalan,et al.  Computer-Aided Analysis of Power Electronic Systems , 1988, Proceedings.14 Annual Conference of Industrial Electronics Society.

[3]  I. Etxeberria-Otadui,et al.  Generalized average modelling of FACTS for real time simulation in ARENE , 2002, IEEE 2002 28th Annual Conference of the Industrial Electronics Society. IECON 02.

[4]  E. E. Mitchell,et al.  Advanced Continuous Simulation Language (ACSL) , 1976 .

[5]  Philippe Poure,et al.  FPGA-based fully digital controller for three-phase shunt active filters , 2008 .

[6]  S. Rael,et al.  A converter topology for high speed motor drive applications , 2009, 2009 13th European Conference on Power Electronics and Applications.

[7]  V. Dinavahi,et al.  Real-Time Digital Hardware Simulation of Power Electronics and Drives , 2007, 2007 IEEE Power Engineering Society General Meeting.

[8]  Xin Wu,et al.  A Low-Cost Real-Time Hardware-in-the-Loop Testing Approach of Power Electronics Controls , 2007, IEEE Transactions on Industrial Electronics.

[9]  Venkata R. Dinavahi.  Real-time digital simulation of switching power circuits , 2000 .

[10]  Hui Li,et al.  Real time simulation of power flow control strategies for fuel cell vehicle with energy storage by using Real Time Digital Simulator (RTDS) , 2009, 2009 IEEE 6th International Power Electronics and Motion Control Conference.

[11]  Dragan Maksimovic,et al.  A method for fast time-domain simulation of networks with switches , 1994 .

[12]  D. Bedrosian,et al.  Time-domain analysis of networks with internally controlled switches , 1992 .

[13]  Christopher R. Clark,et al.  An FPGA-based network intrusion detection system with on-chip network interfaces , 2006 .

[14]  Philippe Poure,et al.  FPGA-based real time current sensor failure diagnosis for shunt active power filters , 2009 .

[15]  Philippe Weber,et al.  Fault tolerant control of a three-phase three-wire shunt active filter system based on reliability analysis , 2009 .

[16]  Venkata Dinavahi,et al.  FPGA-Based Real-Time Emulation of Power Electronic Systems With Detailed Representation of Device Characteristics , 2011, IEEE Transactions on Industrial Electronics.

[17]  J. H. Alimeling,et al.  PLECS-piece-wise linear electrical circuit simulation for Simulink , 1999, Proceedings of the IEEE 1999 International Conference on Power Electronics and Drive Systems. PEDS'99 (Cat. No.99TH8475).

[18]  Weiwei Liu,et al.  Development of an active power filter physical simulator connected with RTDS , 2008, 2008 International Conference on Electrical Machines and Systems.

[19]  Xin Wu,et al.  An interface for switching signals and a new real-time testing platform for accurate hardware-in-the-loop simulation , 2004, 2004 IEEE International Symposium on Industrial Electronics.

[20]  C. Gombert.  Simulation temps-réel des dispositifs d'Electronique de Puissance dédiés aux réseaux d'énergie électrique , 2005 .

[21]  Marian K. Kazimierczuk,et al.  Analysis of networks with ideal switches by state equations , 1997 .

[22]  R. Iravani,et al.  Guidelines for Modeling Power Electronics in Electric Power Engineering Applications , 1997, IEEE Power Engineering Review.