Complex precipitation phenomena in strip cast steels with high sulfur and copper contents

A series of three steel alloys with increasing Cu and S concentrations has been prepared by simulated direct strip casting. It was found that the rapid solidification that occurs during direct strip casting results in the formation of a high number density of fine MnS precipitates, while Cu was retained in solid solution above equilibrium concentration. Upon ageing the MnS particles were found to coarsen and increase in volume fraction, indicating that some S was retained in solid solution in the as-cast condition. Ageing also resulted in the precipitation of Cu-rich precipitates. A new method to determine precipitate composition from small-angle neutron scattering is presented. This methodology, in conjunction with atom-probe tomography, has been used to show that the composition of the Cu-rich precipitates depends on the alloy's bulk Cu content.

[1]  Peter Hodgson,et al.  Quantitative examination of carbide and sulphide precipitates in chemically complex steels processed by direct strip casting , 2016 .

[2]  C. Liu,et al.  Precipitation mechanism and mechanical properties of an ultra-high strength steel hardened by nanoscale NiAl and Cu particles , 2015 .

[3]  D. Seidman,et al.  Interfacial segregation at Cu-rich precipitates in a high-strength low-carbon steel studied on a sub-nanometer scale , 2006 .

[4]  M. K. Miller,et al.  Atom-Probe Tomography: The Local Electrode Atom Probe , 2014 .

[5]  T. Dorin,et al.  Effect of Cooling Rate on Phase Transformations in a High-Strength Low-Alloy Steel Studied from the Liquid Phase , 2015, Metallurgical and Materials Transactions A.

[6]  G. L’espérance,et al.  Microstructure and Mechanical Properties of Strip Cast 1008 Steel after Simulated Coiling, Cold Rolling and Batch Annealing , 1996 .

[7]  P. Hodgson,et al.  Static recrystallization of strip cast alloys in the presence of complex nano-sulfide and nitride precipitates , 2013 .

[8]  Baptiste Gault,et al.  Atom Probe Microscopy , 2012 .

[9]  Y. Bréchet,et al.  Thermal ageing of an Fe‒Cu alloy: Microstructural evolution and precipitation hardening , 1996 .

[10]  G. Fournet,et al.  Small‐Angle Scattering of X‐Rays , 1956 .

[11]  V. F. Sears.  Neutron scattering lengths and cross sections , 1992 .

[12]  B. Ralph,et al.  A Study of the Precipitation of Copper from α-Iron in the Pre-Peak to Peak Hardness Range of Ageing , 1972 .

[13]  Joe Herbertson,et al.  Experimental Studies of Interfacial Heat Transfer and Initial Solidification Pertinent to Strip Casting , 1998 .

[14]  D. Seidman,et al.  The temporal evolution of the decomposition of a concentrated multicomponent Fe-Cu-based steel , 2008 .

[15]  K. Nagai,et al.  Crystallography and precipitation kinetics of copper sulfide in strip casting low carbon steel , 2004 .

[16]  Byeong-Joo Lee,et al.  Thermodynamic Calculations on the Stability of Cu2S in Low Carbon Steels , 2007 .

[17]  M. Ferry,et al.  Direct strip casting of metals and alloys , 2006 .

[18]  E. Jones,et al.  Antiferromagnetism in the Face-Centered Cubic Lattice. III. α -MnS , 1966 .

[19]  M. Barbosa.  Changes induced in anodic behaviour of stainless steel in H2SO4 solutionsby preanodic treatment and potential sweep rate , 1988 .

[20]  Matthias Militzer,et al.  Precipitation Kinetics and Strengthening of a Fe-0.8wt%Cu Alloy , 2001 .

[21]  A. Deschamps,et al.  Precipitate characterisation in metallic systems by small-angle X-ray or neutron scattering , 2012 .

[22]  G. E. BACON,et al.  Neutron Diffraction , 1972, Nature.

[23]  J. Brunvoll,et al.  On the Properties of alpha-MnS and MnS2. , 1965 .

[24]  S. R. Goodman,et al.  An FIM-atom probe study of the precipitation of copper from lron-1.4 at. pct copper. Part II: Atom probe analyses , 1973 .

[25]  R. Bozorth.  The physical basis of ferromagnetism , 1940 .

[26]  Terry Noakes,et al.  ‘Quokka’—the small-angle neutron scattering instrument at OPAL , 2006 .

[27]  P. Staron,et al.  Critical Consideration of Precipitate Analysis of Fe–1 at.% Cu Using Atom Probe and Small-Angle Neutron Scattering , 2010, Microscopy and Microanalysis.