First structural use of site-cast, alkali-activated slag concrete in China

This paper reports the first structural application of site-cast, alkali-activated slag concrete in China. Special attention was given in this office building project at Chongqing Jianke to quality control, construction procedure and assessment. The experience showed that quality and costs could be successfully managed through careful control of raw materials, suitable selection of admixtures, proper mix proportions and an efficient construction team. It was also found that alkali-activated slag concrete has the potential for use in cold weather. The ambient temperature during construction was at times below 5°C, yet no specific procedures were needed to maintain the temperature or provide additional heat. The project is a useful reference for future structural use of alkali-activated slag concrete.

[1]  Sulapha Peethamparan,et al.  Quantification of CO 2 sequestration capacity and carbonation rate of alkaline industrial byproducts , 2015 .

[2]  Rafael Font,et al.  Organic and inorganic pollutants from cement kiln stack feeding alternative fuels. , 2008, Journal of hazardous materials.

[3]  Farshad Rajabipour,et al.  Electrical conductivity of drying cement paste , 2007 .

[4]  R. Rakhimov,et al.  Hydrated Portland cement as an admixture to alkali-activated slag cement , 2015 .

[5]  John L. Provis,et al.  Durability of Alkali‐Activated Materials: Progress and Perspectives , 2014 .

[6]  Judith Scott Clayton,et al.  The Future , 2001, Nature.

[7]  C. Shi,et al.  New cements for the 21st century: The pursuit of an alternative to Portland cement , 2011 .

[8]  P. Basheer,et al.  Field monitoring of electrical conductivity of cover-zone concrete , 2005 .

[9]  W. John McCarter,et al.  Sensor systems for use in reinforced concrete structures , 2004 .

[10]  Li Hui,et al.  On the future of Chinese cement industry , 2015 .

[11]  T. Hakkinen.  DURABILITY OF ALKALI-ACTIVATED SLAG CONCRETE , 1987 .

[12]  Wenzhi Li,et al.  Novel Method to Prepare Activated Crumb Rubber Used for Synthesis of Activated Crumb Rubber Modified Asphalt , 2015 .

[13]  Jay G. Sanjayan,et al.  Predictions of long-term deflection of geopolymer concrete beams , 2015 .

[14]  Bryan Magee,et al.  Investigation of moisture condition and Autoclam sensitivity on air permeability measurements for both normal concrete and high performance concrete , 2013 .

[15]  J. E. Davison,et al.  CO2 Capture in the Cement Industry , 2009 .

[16]  J. Provis,et al.  Advances in understanding alkali-activated materials , 2015 .

[17]  N. Rakhimova,et al.  Characterisation of ground hydrated Portland cement-based mortar as an additive to alkali-activated slag cement , 2015 .

[18]  Kåre Helge Karstensen,et al.  Formation, release and control of dioxins in cement kilns. , 2008, Chemosphere.