Nitrogen dissociation in a low pressure cylindrical ICP discharge studied by actinometry and mass spectrometry

A cylindrical inductively coupled plasma source (ICPS) is optimized for nitrogen atom production. How to operate in the bright mode (H-mode) in pure nitrogen at relatively low applied power is explained. Actinometry is developed for a quantitative determination of the nitrogen dissociation fraction in the ICPS. These results are compared with those obtained outside the ICPS by modulated beam mass spectrometry. A qualitative agreement is obtained between the nitrogen dissociative fraction inside and outside the ICPS. The higher magnitude of the dissociation fraction given by mass spectrometry compared with that derived from actinometry is explained by the contribution of dissociative recombination of near the exit hole of the ICPS. A dissociation fraction of up to 0.7 is observed by mass spectrometry. Some results are also reported for argon–nitrogen gas mixtures.

[1]  G. Piech,et al.  Measurement of electron-impact excitation cross sections out of metastable levels of argon and comparison with ground-state excitation , 1999 .

[2]  K. A. MacKinnon.  LXVI. On the origin of the electrodeless discharge , 1929 .

[3]  A. Catherinot,et al.  Quenching of the3pSo4atomic-nitrogen state in a low-pressure nitrogen glow discharge , 1979 .

[4]  J. Giuliani,et al.  ULTRAHIGH VACUUM ARCJET NITROGEN SOURCE FOR SELECTED ENERGY EPITAXY OF GROUP III NITRIDES BY MOLECULAR BEAM EPITAXY , 1998 .

[5]  K. Hassouni,et al.  VALIDATION OF ACTINOMETRY FOR ESTIMATING RELATIVE HYDROGEN ATOM DENSITIES AND ELECTRON ENERGY EVOLUTION IN PLASMA ASSISTED DIAMOND DEPOSITION REACTORS , 1998 .

[6]  David J. Smith,et al.  Complementary optical diagnostic modelling of the argon positive column , 2002 .

[7]  P. Leprince,et al.  Validity of actinometry to monitor oxygen atom concentration in microwave discharges created by surface wave in O2‐N2 mixtures , 1994 .

[8]  M. V. Malyshev,et al.  Determination of electron temperatures in plasmas by multiple rare gas optical emission, and implications for advanced actinometry , 1997 .

[9]  Y. Hatanaka,et al.  Measurements of the atomic nitrogen population produced by a microwave electron cyclotron resonance plasma , 1989 .

[10]  D. Hayashi,et al.  A Compact Nitrogen Radical Source by Helicon-Wave Discharge Employing a Permanent Magnet , 2000 .

[11]  M. V. Malyshev,et al.  Trace rare gases optical emission spectroscopy: nonintrusive method for measuring electron temperatures in low-pressure, low-temperature plasmas. , 1999, Physical review. E, Statistical physics, plasmas, fluids, and related interdisciplinary topics.

[12]  A. Ricard,et al.  Active species in microwave postdischarge for steel-surface nitriding , 1990 .

[13]  W. R. Thompson,et al.  Determination of the atomic nitrogen flux from a radio frequency plasma nitride source for molecular beam epitaxy systems , 1998 .

[14]  T. Belmonte,et al.  Determination of N and O Atom Density in Ar-N{2}-H{2} and Ar-O{2}-H{2} Flowing Microwave Post Discharges , 1996 .

[15]  J. Amorim,et al.  Validity of actinometry to measure N and H atom concentration in N2-H2 direct current glow discharges , 1999 .

[16]  Thierry Czerwiec,et al.  Low-pressure, high-density plasma nitriding: mechanisms, technology and results , 1998 .

[17]  W. R. Thompson,et al.  Study of the emission characteristics of a rf plasma source for atomic oxygen: Measurements of atom, ion, and electron fluxes , 2001 .

[18]  J. Berndt,et al.  Quantitative analysis of the atomic nitrogen concentration in a remote plasma by means of mass spectrometry , 2002 .

[19]  R. E. Walkup,et al.  Studies of atomic oxygen in O2+CF4 rf discharges by two‐photon laser‐induced fluorescence and optical emission spectroscopy , 1986 .

[20]  J. Coburn,et al.  Optical emission spectroscopy of reactive plasmas: A method for correlating emission intensities to reactive particle density , 1980 .

[21]  H. J. Jong.  Deactivation rate constants and cross sections for Ar3P2 metastables in collision reactions with several molecules , 1974 .

[22]  E. Tatarova,et al.  Wave driven N2–Ar discharge. I. Self-consistent theoretical model , 2002 .

[23]  N. Badnell,et al.  Calculated cross sections and measured rate coefficients for electron-impact excitation of neutral and singly ionized nitrogen , 1998 .

[24]  S. Xu,et al.  Optical emission characteristics and mode transitions in low-frequency inductively coupled plasmas , 2002 .

[25]  Paul H. Krupenie,et al.  The spectrum of molecular nitrogen , 1977 .

[26]  E. Quandt,et al.  Detection of atomic oxygen: Improvement of actinometry and comparison with laser spectroscopy , 2000 .

[27]  J. Keto,et al.  Radiative lifetimes and collisional deactivation of two‐photon excited xenon in argon and xenon , 1990 .

[28]  Kock,et al.  Unified set of atomic transition probabilities for neutral argon. , 1989, Physical review. A, General physics.

[29]  A. Ricard,et al.  RF plasma investigations for plasma-assisted MBE growth of (Ga,In)(As,N) materials , 2002 .

[30]  T. Godfroid,et al.  Atomic nitrogen source for reactive magnetron sputtering , 2003 .

[31]  Yoon-Kee Kim,et al.  Plasma diagnostics of pulsed d.c. glow discharge combined with ICP for deep nitriding process , 2001 .

[32]  Z. R. Wasilewski,et al.  Compositional control in molecular beam epitaxy growth of GaNyAs1−y on GaAs (001) using an Ar/N2 RF plasma , 2002 .

[33]  M. Moisan,et al.  Hydrogen atom yield in RF and microwave hydrogen discharges , 1994 .

[34]  R. Vaudo,et al.  Atomic-nitrogen production in a radio-frequency plasma source. , 1993, Optics letters.

[35]  C. Stinespring,et al.  Influence of Active Nitrogen Species on the Nitridation Rate of Sapphire , 1999 .

[36]  R. E. Murphy,et al.  Production of atomic nitrogen emission by electron-impact dissociative excitation of nitrogen molecules , 1982 .

[37]  R. Vaudo,et al.  Atomic nitrogen production in a molecular‐beam epitaxy compatible electron cyclotron resonance plasma source , 1994 .

[38]  N. Itagaki,et al.  Electron-temperature dependence of nitrogen dissociation in 915 MHz ECR plasma , 2003 .

[39]  M. Lagus,et al.  Electron impact excitation out of the metastable levels of argon into the level , 1996 .

[40]  Veres,et al.  Atomic transition probabilities and tests of the spectroscopic coupling scheme for N I. , 1995, Physical review. A, Atomic, molecular, and optical physics.

[41]  J. Perrin,et al.  Thermal accommodation of a gas on a surface and heat transfer in CVD and PECVD experiments , 1997 .

[42]  U. Czarnetzki,et al.  Quenching rate constants for reactions of Ar(4p′[1/2]0, 4p[1/2]0, 4p[3/2]2, and 4p[5/2]2) atoms with 22 reagent gases , 2001 .

[43]  J. E. Chilton,et al.  Measurement of electron-impact excitation into the 3 p 5 4 p levels of argon using Fourier-transform spectroscopy , 1998 .

[44]  Terry A. Miller,et al.  Two-photon absorption laser-induced fluorescence of atomic nitrogen by an alternative excitation scheme , 1998 .

[45]  Uwe R. Kortshagen,et al.  On the E - H mode transition in RF inductive discharges , 1996 .

[46]  Kari Niemi,et al.  Absolute calibration of atomic density measurements by laser-induced fluorescence spectroscopy with two-photon excitation , 2001 .

[47]  C. T. Foxon,et al.  Nitrogen species from radio frequency plasma sources used for molecular beam epitaxy growth of GaN , 2000 .

[48]  J. Coburn,et al.  Fundamental beam studies of radical enhanced atomic layer deposition of TiN , 2003 .

[49]  W. Runciman,et al.  The optical absorption of divalent chromium in CrCl2. 4H2O and CrSO4. 7H2O , 1963 .

[50]  J. Pelletier,et al.  Oxygen atom actinometry reinvestigated: Comparison with absolute measurements by resonance absorption at 130 nm , 1991 .

[51]  C. Yildiz.  Influence of anisotropic scattering on the size of time-dependent systems in monoenergetic neutron transport , 1999 .

[52]  Larsson,et al.  Natural lifetimes of excited states of neutral nitrogen determined by time-resolved laser spectroscopy. , 1992, Physical review. A, Atomic, molecular, and optical physics.

[53]  J. Coburn,et al.  Heteronuclear and homonuclear surface abstraction reactions of Cl, Br, and F , 1999 .

[54]  J. Coburn,et al.  Mass spectrometric detection of reactive neutral species: Beam-to-background ratio , 1999 .

[55]  E. Tatarova,et al.  Wave driven N2–Ar discharge. II. Experiment and comparison with theory , 2002 .

[56]  D. Graves,et al.  Mode transitions in low pressure rare gas cylindrical ICP discharge studied by optical emission spectroscopy , 2004 .

[57]  S. Xu,et al.  Hysteresis and mode transitions in a low-frequency inductively coupled plasma , 2000 .