Impact of average free‐volume element size on transport in stereoisomers of polynorbornene. I. Properties at 35 °C

This article demonstrates that transport of gases through glassy polymers is significantly influenced not only by the absolute amount but also by the distribution of free volume. Two stereoisomers of polynorbornene with nearly equivalent total free volume, but markedly different average free-volume sizes, were evaluated. The free-volume element size was probed with positron annihilation lifetime spectroscopy, wide-angle X-ray scattering, gas sorption, and molecular modeling. The permeation, sorption, and diffusion of light gases were measured in each stereoisomer at 35 °C. All analytical techniques indicated that one isomer (labeled as Architecture II) had a larger average free-volume element size but fewer elements. This isomer also had a very slightly higher bulk density (1.000 vs 0.992 g/cm3 for the other stereoisomer). Architecture II also had gas sorption and diffusion coefficients that were two to three times those of the less dense counterpart. These differences have been attributed to differences in the free-volume element size available within the polymer matrix. © 2003 Wiley Periodicals, Inc. J Polym Sci Part B: Polym Phys 41: 2185–2199, 2003

[1]  A. J. Hill,et al.  Ultrapermeable, Reverse-Selective Nanocomposite Membranes , 2002, Science.

[2]  William J. Koros,et al.  Tailoring mixed matrix composite membranes for gas separations , 1997 .

[3]  W. Koros,et al.  Controlled Permeability Polymer Membranes , 1992 .

[4]  V. Volkov.  Free Volume Structure and Transport Properties of Glassy Polymers—Materials for Separating Membranes , 1991 .

[5]  S. A. Stern,et al.  Structure/permeability relationships of polyimides with branched or extended diamine moieties , 1993 .

[6]  S. Jacobson.  Molecular modeling studies of polymeric gas separation and barrier materials: structure and transport mechanisms , 1994 .

[7]  H. Fujita.  Diffusion in polymer-diluent systems , 1961 .

[8]  R. Simha,et al.  Ortho-positronium lifetime studies of free volume in polycarbonates of different structures: influence of hole size distributions , 1993 .

[9]  David Turnbull,et al.  Molecular Transport in Liquids and Glasses , 1959 .

[10]  K. Nagai,et al.  Effect of physical aging of poly(1-trimethylsilyl-1-propyne) films synthesized with TaCl5 and NbCl5 on gas permeability, fractional free volume, and positron annihilation lifetime spectroscopy parameters , 2000 .

[11]  E. M. Antipov,et al.  Transport characteristics and other physicochemical properties of aged poly (1-(trimethylsilyl)-1-propyne) , 1993 .

[12]  W. Burgoyne,et al.  Effects of diamine monomer structure on the gas permeability of polyimides. I. Bridged diamines , 1993 .

[13]  V. Bondar,et al.  Synthesis, Gas Permeability, and Gas Sorption Properties of Fluorine-Containing Norbornene Polymers , 1994 .

[14]  H. Kita,et al.  Correlation between Positron Annihilation and Sorption of CO2 in Glassy Polymers , 1993 .

[15]  A. Michaels,et al.  Solution of Gases in Polyethylene Terephthalate , 1963 .

[16]  Donald R Paul,et al.  Correlation and prediction of gas permeability in glassy polymer membrane materials via a modified free volume based group contribution method , 1997 .

[17]  Y. Jean.  Free-volume mean sizes of polymers probed by positron annihilation spectroscopy: a correlation of results obtained by PAL and by ACAR methods , 1991 .

[18]  W. Koros,et al.  CO2 sorption in poly(ethylene terephthalate) above and below the glass transition , 1978 .

[19]  V. S. Subrahmanyam,et al.  Structural characteristics and gas permeation properties of polynorbornenes with retained bicyclic structure , 2001 .

[20]  J. Wendorff,et al.  Polynorbornene: synthesis, properties and simulations , 1996 .

[21]  R. M. Barrer,et al.  Sorption and diffusion in ethyl cellulose. Part III. Comparison between ethyl cellulose and rubber , 1958 .

[22]  W. Koros,et al.  The transport properties of polyimide isomers containing hexafluoroisopropylidene in the diamine residue , 1994 .

[23]  G. H. Dai,et al.  Free-volume hole distributions of polymers probed by positron annihilation spectroscopy: experiences of using the CONTIN program , 1993 .

[24]  V. Bondar,et al.  Sorption of gases and vapors in an amorphous glassy perfluorodioxole copolymer , 1999 .

[25]  B. Freeman,et al.  Pure hydrocarbon sorption properties of poly(1‐trimethylsilyl‐1‐propyne) (PTMSP), poly(1‐phenyl‐1‐propyne) (PPP), and PTMSP/PPP blends , 1996 .

[26]  Peter J. Ludovice,et al.  Stereochemical structure-property relationships in polynorbornene from simulation , 1998 .

[27]  W. Koros,et al.  Effect of structural symmetry on gas transport properties of polysulfones , 1992 .

[28]  Y. Yampolskii,et al.  Estimation of free volume in poly(trimethylsilyl propyne) by positron annihilation and electrochromism methods , 1993 .

[29]  W. Koros,et al.  Gas transport properties of biphenol polysulfones , 1992 .

[30]  W. Koros,et al.  Gas permeation and sorption studies on stereoregular polynorbornene , 1997 .

[31]  Y. Mi,et al.  Structure/permeability relationships of polyimide membranes. II , 1990 .

[32]  Y. Mi,et al.  Structure/permeability relationships of polyimide membranes. Applications to the separation of gas mixtures , 1989 .

[33]  Giovanni Consolati,et al.  Positron annihilation lifetime (PAL) in poly[1‐(trimethyl‐silyl)propine] (PTMSP): Free volume determination and time dependence of permeability , 1996 .

[34]  W. Koros,et al.  Gas sorption and transport in substituted polycarbonates , 1987 .

[35]  D. R. Paul,et al.  Effect of tacticity on permeation properties of poly(methyl methacrylate) , 1988 .

[36]  Eric J. Amis,et al.  Combinatorial Methods for Investigations in Polymer Materials Science , 2002 .

[37]  B. Goodall,et al.  New catalysts for the polymerization of cyclic olefins , 1995 .

[38]  Robert A. Shick,et al.  Addition Polymerization of Norbornene-Type Monomers Using Neutral Nickel Complexes Containing Fluorinated Aryl Ligands , 2003 .

[39]  W. Koros,et al.  Transport characterization of a polypyrrolone for gas separations , 1991 .

[40]  D. R. Paul,et al.  Gas sorption and transport in poly(phenylene oxide) and comparisons with other glassy polymers , 1982 .

[41]  W. M. Lee.  Selection of barrier materials from molecular structure , 1980 .

[42]  W. Koros,et al.  Relationship between gas separation properties and chemical structure in a series of aromatic polyimides , 1988 .

[43]  W. Koros,et al.  Gas transport properties of polysulphones: 1. Role of symmetry of methyl group placement on bisphenol rings , 1991 .

[44]  Y. Jean.  Positron annihilation spectroscopy for chemical analysis: A novel probe for microstructural analysis of polymers☆ , 1990 .