Liquefied petroleum gas (LPG) sensor properties of interconnected web-like structured sprayed TiO2 films

Abstract In this paper, we explore for the first time the liquefied petroleum gas (LPG) sensing properties of the interconnected web-like structured TiO2 films synthesized by a spray pyrolysis deposition method using an aqueous Ti(III) chloride solution. The TiO2 films were characterized for their structural, surface morphological, optical and electrical properties and used for LPG response measurements. The SEM analyses indicated the systematically grown web-like surface morphology, to which LPG was found to be sensitive. The deposited films were polycrystalline with pronounced orientation along the (1 0 1) plane, uniform and adherent to the glass substrate. From optical absorbance studies, the optical band gap was estimated to be 3.1 eV. Thermo-emf measurement revealed that the conductivity of the TiO2 web-like structure was of n-type. With this morphology, the maximum response of 35.8% at 698 K was recorded on exposure to 0.08 vol% of LPG.

[1]  Amit K. Gupta,et al.  Characterization of vaccinia virus particles using microscale silicon cantilever resonators and atomic force microscopy , 2006 .

[2]  Matteo Ferroni,et al.  Nanostructured pure and Nb-doped TiO2 as thick film gas sensors for environmental monitoring , 1999 .

[3]  Pravin S. Shinde,et al.  Structural, optical and electrical characterization of spray-deposited TiO2 thin films , 2006 .

[4]  M. Grätzel,et al.  A low-cost, high-efficiency solar cell based on dye-sensitized colloidal TiO2 films , 1991, Nature.

[5]  Ghenadii Korotcenkov,et al.  Peculiarities of SnO2 thin film deposition by spray pyrolysis for gas sensor application , 2001 .

[6]  Murthy Chavali,et al.  Composite of TiO2 nanowires and Nafion as humidity sensor material , 2006 .

[7]  Spray pyrolysis deposition of lanthanum telluride thin films and their characterizations , 2005 .

[8]  P. Patil.  Versatility of chemical spray pyrolysis technique , 1999 .

[9]  D. Lane,et al.  Structural characterisation of sprayed TiO2 films for extremely thin absorber layer solar cells , 2004 .

[10]  Sheikh A. Akbar,et al.  TiO2–SnO2 nanostructures and their H2 sensing behavior , 2005 .

[11]  G. Martinelli,et al.  Preparation of nanosized titania thick and thin films as gas-sensors , 1999 .

[12]  Gyoichi Nogami,et al.  Titanium dioxide thin film deposited by spray pyrolysis of aqueous solution , 1998 .

[13]  S. Mathur,et al.  CVD of titanium oxide coatings: Comparative evaluation of thermal and plasma assisted processes , 2006 .

[14]  Peter Lund,et al.  Spray deposition and compression of TiO2 nanoparticle films for dye-sensitized solar cells on plastic substrates , 2006 .

[15]  J. Madarász,et al.  Porous TiO2 thin films prepared by spray pyrolysis deposition (SPD) technique and their application to UV sensors , 2004 .

[16]  C. Lokhande,et al.  Cathodic electrodeposition of amorphous titanium oxide films from an alkaline solution bath , 2004 .

[17]  C. Lokhande,et al.  Room temperature chemical deposition of amorphous TiO2 thin films from Ti(III) chloride solution , 2004 .

[18]  C. Lokhande,et al.  Systematic interconnected web-like architecture growth of sprayed TiO2 films. , 2007, Micron.

[19]  J. Schoonman,et al.  Inorganic Nanocomposites of n‐ and p‐Type Semiconductors: A New Type of Three‐Dimensional Solar Cell , 2004 .

[20]  C. Lokhande,et al.  Improved performance of dense TiO2/CdSe coupled thin films by low temperature process , 2005 .

[21]  Ulrike Diebold,et al.  The surface science of titanium dioxide , 2003 .

[22]  Jiaguo Yu,et al.  Photocatalytic activity of nanometer TiO2 thin films prepared by the sol–gel method , 2001 .

[23]  C. Lokhande,et al.  Use of successive ionic layer adsorption and reaction (SILAR) method for amorphous titanium dioxide thin films growth , 2006 .

[24]  Craig A. Grimes,et al.  A room-temperature TiO2-nanotube hydrogen sensor able to self-clean photoactively from environmental contamination , 2004 .

[25]  F. Lévy,et al.  TiO2 anatase thin films as gas sensors , 1995 .

[26]  Ion N. Mihailescu,et al.  Anatase phase TiO2 thin films obtained by pulsed laser deposition for gas sensing applications , 2005 .

[27]  C. Lokhande,et al.  Room temperature synthesis of compact TiO2 thin films for 3-D solar cells by chemical arrested route , 2005 .

[28]  M. Miki-Yoshida,et al.  Growth and structure of TiO2 thin films deposited inside borosilicate tubes by spray pyrolysis , 2006 .

[29]  Craig A. Grimes,et al.  Extreme Changes in the Electrical Resistance of Titania Nanotubes with Hydrogen Exposure , 2003 .

[30]  Chandrakant D. Lokhande,et al.  LPG sensing properties of ZnO films prepared by spray pyrolysis method : Effect of molarity of precursor solution , 2007 .

[31]  D. Acosta,et al.  Effect of deposition methods on the properties of photocatalytic TiO2 thin films prepared by spray pyrolysis and magnetron sputtering , 2004 .

[32]  S. Tao,et al.  Preparation and characterization of nanocrystalline α-Fe2O3 by a sol-gel process , 1997 .

[33]  J. Peng,et al.  Preparation and gas-sensing properties of α-Fe2O3 thin films , 1995 .

[34]  M. L. Curri,et al.  TiO2 colloidal nanocrystals functionalization of PMMA: A tailoring of optical properties and chemical adsorption , 2007 .

[35]  A. Duţă.  TiO2 thin layers with controlled morphology for ETA (extremely thin absorber) solar cells , 2006 .