Effects of chlorine and sulphur on particle formation in wood combustion performed in a laboratory scale reactor

Abstract Fine particle formation in wood combustion was studied in a laboratory scale laminar flow reactor at various flue gas chlorine and sulphur concentrations. Aerosol samples were quenched at around 850 °C using a porous tube diluter. Fine particle number concentrations, mass concentrations, size distributions and chemical compositions were measured. In addition, flue gas composition, including SO 2 and HCl, was monitored. Experimental results were interpreted by thermodynamic equilibrium calculations. Addition of HCl clearly raised fine particle mass concentration (PM1.0) which was because of increased release of ash-forming material to fine particles. Especially the release of K, Na, Zn and Cd to fine particles increased. These species form chlorides which apparently increases their volatilization from the fuel. When a sufficient amount of SO 2 was supplied in a chlorine rich combustion (S/Cl molar ratio from 4.7 to 7.5), most of the HCl stayed in the gas phase, release of ash-forming elements decreased and also fine particle concentrations dropped significantly. The sulphation of alkali metals is suggested to play a key role in the observed decrease in the fine particle concentration. It seems that the formation of sulphates leads to alkali metal retention in the coarse particle fraction.

[1]  E. N. Sieder,et al.  Heat Transfer and Pressure Drop of Liquids in Tubes , 1936 .

[2]  C. Nilsson,et al.  The effects of particle characteristics on emissions from burning wood fuel powder , 2004 .

[3]  W. Maenhaut,et al.  Fly Ash Deposition Onto the Convective Heat Exchangers During Combustion of Willow in a Circulating Fluidized Bed Boiler , 2002 .

[4]  D. R. Dugwell,et al.  Trace Element Emissions from Co-combustion of Secondary Fuels with Coal: A Comparison of Bench-Scale Experimental Data with Predictions of a Thermodynamic Equilibrium Model , 2002 .

[5]  K. Iisa,et al.  Sulfation of potassium chloride at combustion conditions , 1999 .

[6]  L. B. Nielsen,et al.  The Nucleation of Aerosols in Flue Gases with a High Content of Alkali - A Laboratory Study , 2000 .

[7]  Akira Ishikawa,et al.  Fuel and emissions properties of Stirling engine operated with wood powder , 2007 .

[8]  Peter Arendt Jensen,et al.  Transformation and Release to the Gas Phase of Cl, K, and S during Combustion of Annual Biomass , 2004 .

[9]  J. T. Riley,et al.  The Effect of Chlorine and Sulfur on the Composition of Ash Deposits in a Fluidized Bed Combustion System , 2000 .

[10]  Rafael Kandiyoti,et al.  The Influence of Injected HCl and SO2 on the Behavior of Trace Elements during Wood-Bark Combustion , 2003 .

[11]  U. Tapper,et al.  Mobility size development and the crystallization path during aerosol decomposition synthesis of TiO2 particles , 2001 .

[12]  Hannu Vesala,et al.  Comparison of Different Dilution Methods for Measuring Diesel Particle Emissions , 2004 .

[13]  Gunnar Eriksson,et al.  FactSage thermochemical software and databases , 2002 .

[14]  R. Hillamo,et al.  Effect of Chlorine and Sulfur on Fine Particle Formation in Pilot-Scale CFBC of Biomass , 2006 .

[15]  Juha Kurkela,et al.  Fly ash formation and deposition during fluidized bed combustion of willow , 1998 .

[16]  Binlin Dou,et al.  Adsorption of alkali metal vapor from high-temperature coal-derived gas by solid sorbents , 2003 .

[17]  E. Swietlicki,et al.  Hygroscopic Behavior of Aerosol Particles Emitted from Biomass Fired Grate Boilers , 2005 .

[18]  K. Lehtinen,et al.  Numerical simulation of vapour-aerosol dynamics in combustion processes , 1994 .

[19]  John H. Seinfeld,et al.  Fundamentals of Air Pollution Engineering , 1988 .

[20]  H. Livbjerg,et al.  The formation of submicron aerosol particles, HCl and SO2 in straw-fired boilers , 1998 .

[21]  Jarkko Tissari,et al.  Effect of Wood Fuel on the Emissions from a Top-Feed Pellet Stove , 2007 .

[22]  Christer Andersson,et al.  Reducing superheater corrosion in wood‐fired boilers , 2006 .

[23]  Peter Glarborg,et al.  Mechanism and modeling of the formation of gaseous alkali sulfates , 2005 .

[24]  Frank P. Incropera,et al.  Fundamentals of Heat and Mass Transfer , 1981 .

[25]  O. Lindqvist,et al.  Capture of Potassium and Cadmium by Kaolin in Oxidizing and Reducing Atmospheres , 2004 .

[26]  Joakim Pagels,et al.  Characteristics of aerosol particles formed during grate combustion of moist forest residue , 2003 .