Submersible microbial fuel cell sensor for monitoring microbial activity and BOD in groundwater: Focusing on impact of anodic biofilm on sensor applicability

A sensor, based on a submersible microbial fuel cell (SUMFC), was developed for in situ monitoring of microbial activity and biochemical oxygen demand (BOD) in groundwater. Presence or absence of a biofilm on the anode was a decisive factor for the applicability of the sensor. Fresh anode was required for application of the sensor for microbial activity measurement, while biofilm‐colonized anode was needed for utilizing the sensor for BOD content measurement. The current density of SUMFC sensor equipped with a biofilm‐colonized anode showed linear relationship with BOD content, to up to 250 mg/L (∼233 ± 1 mA/m2), with a response time of <0.67 h. This sensor could, however, not measure microbial activity, as indicated by the indifferent current produced at varying active microorganisms concentration, which was expressed as microbial adenosine‐triphosphate (ATP) concentration. On the contrary, the current density (0.6 ± 0.1 to 12.4 ± 0.1 mA/m2) of the SUMFC sensor equipped with a fresh anode showed linear relationship, with active microorganism concentrations from 0 to 6.52 nmol‐ATP/L, while no correlation between the current and BOD was observed. It was found that temperature, pH, conductivity, and inorganic solid content were significantly affecting the sensitivity of the sensor. Lastly, the sensor was tested with real contaminated groundwater, where the microbial activity and BOD content could be detected in <3.1 h. The microbial activity and BOD concentration measured by SUMFC sensor fitted well with the one measured by the standard methods, with deviations ranging from 15% to 22% and 6% to 16%, respectively. The SUMFC sensor provides a new way for in situ and quantitative monitoring contaminants content and biological activity during bioremediation process in variety of anoxic aquifers. Biotechnol. Bioeng. 2011;108: 2339–2347. © 2011 Wiley Periodicals, Inc.

[1]  Georg Teutsch,et al.  Natural attenuation research at the contaminated megasite Zeitz , 2006 .

[2]  B. Logan,et al.  Electricity-producing bacterial communities in microbial fuel cells. , 2006, Trends in microbiology.

[3]  J. R. van der Meer,et al.  Evolution of a Pathway for Chlorobenzene Metabolism Leads to Natural Attenuation in Contaminated Groundwater , 1998, Applied and Environmental Microbiology.

[4]  G. Gadd,et al.  Membrane‐electrode assembly enhances performance of a microbial fuel cell type biological oxygen demand sensor , 2009, Environmental technology.

[5]  Largus T Angenent,et al.  Aerated Shewanella oneidensis in continuously fed bioelectrochemical systems for power and hydrogen production , 2010, Biotechnology and bioengineering.

[6]  Bruce E Logan,et al.  Power production in MFCs inoculated with Shewanella oneidensis MR‐1 or mixed cultures , 2010, Biotechnology and bioengineering.

[7]  Paul C. Johnson,et al.  Field-scale demonstration of enhanced MTBE bioremediation through aquifer bioaugmentation and oxygenation. , 2000 .

[8]  Keith Scott,et al.  A single-chamber microbial fuel cell as a biosensor for wastewaters. , 2009, Water research.

[9]  E. E. L O G A N,et al.  Continuous Electricity Generation from Domestic Wastewater and Organic Substrates in a Flat Plate Microbial Fuel Cell , 2022 .

[10]  D. English,et al.  RAPID DETECTION OF MICROBIAL CONTAMINATION IN TRICLOSAN AND HIGH FLUORIDE DENTIFRICES USING AN ATP BIOLUMINESCENCE ASSAY , 1998 .

[11]  Bruce E Logan,et al.  Continuous electricity generation from domestic wastewater and organic substrates in a flat plate microbial fuel cell. , 2004, Environmental science & technology.

[12]  Hong Liu,et al.  Production of electricity from acetate or butyrate using a single-chamber microbial fuel cell. , 2005, Environmental science & technology.

[13]  Jing Liu,et al.  Microbial fuel cell-based biosensor for fast analysis of biodegradable organic matter. , 2007, Biosensors & bioelectronics.

[14]  A. E. Greenberg,et al.  Standard Methods for the Examination of Water and Wastewater seventh edition , 2013 .

[15]  Bruce E. Logan,et al.  Microbial Fuel Cells , 2006 .

[16]  Irini Angelidaki,et al.  Innovative microbial fuel cell for electricity production from anaerobic reactors , 2008 .

[17]  Baikun Li,et al.  Effect of Inoculum Types on Bacterial Adhesion and Power Production in Microbial Fuel Cells , 2010, Applied biochemistry and biotechnology.

[18]  Prathap Parameswaran,et al.  Microbial community structure in a biofilm anode fed with a fermentable substrate: The significance of hydrogen scavengers , 2010, Biotechnology and bioengineering.

[19]  Andreas Englert,et al.  Electrode-based approach for monitoring in situ microbial activity during subsurface bioremediation. , 2010, Environmental science & technology.

[20]  M. Wünsche,et al.  Lignite mining and its after-effects on the Central German landscape , 1996 .

[21]  A. E. Greenberg,et al.  Standard methods for the examination of water and wastewater. 14th edition. , 1976 .

[22]  Byung Hong Kim,et al.  Novel BOD (biological oxygen demand) sensor using mediator-less microbial fuel cell , 2003, Biotechnology Letters.

[23]  W H G Armytage.  The Generation of Electricity , 2003 .

[24]  Brenda Little,et al.  A biofilm enhanced miniature microbial fuel cell using Shewanella oneidensis DSP10 and oxygen reduction cathodes. , 2007, Biosensors & bioelectronics.

[25]  Y. Lévi,et al.  An ATP-based method for monitoring the microbiological drinking water quality in a distribution network. , 2003, Water research.

[26]  B. Min,et al.  Generation of Electricity and Analysis of Microbial Communities in Wheat Straw Biomass-Powered Microbial Fuel Cells , 2009, Applied and Environmental Microbiology.

[27]  H. Richnow,et al.  In situ microcosms to evaluate natural attenuation potentials in contaminated aquifers , 2006 .

[28]  D. Lovley,et al.  Rates of Microbial Metabolism in Deep Coastal Plain Aquifers , 1990, Applied and environmental microbiology.

[29]  L. Lebbe,et al.  Identification and reliability of microbial aerobic respiration and denitrification kinetics using a single-well push-pull field test. , 2008, Journal of contaminant hydrology.

[30]  Lewis Semprini,et al.  Comparison Between Model Simulations and Field Results for In‐Situ Biorestoration of Chlorinated Aliphatics: Part 1. Biostimulation of Methanotrophic Bacteria , 1991 .

[31]  Zhiguo Yuan,et al.  Electron and carbon balances in microbial fuel cells reveal temporary bacterial storage behavior during electricity generation. , 2007, Environmental science & technology.

[32]  W. Verstraete,et al.  High shear enrichment improves the performance of the anodophilic microbial consortium in a microbial fuel cell , 2008, Microbial biotechnology.

[33]  J. Istok,et al.  Single‐Well, “Push‐Pull” Test for In Situ Determination of Microbial Activities , 1997 .

[34]  J. Hughes,et al.  Microbial fuel cell technology for measurement of microbial respiration of lactate as an example of bioremediation amendment , 2008, Biotechnology Letters.

[35]  Jae Kyung Jang,et al.  Continuous determination of biochemical oxygen demand using microbial fuel cell type biosensor. , 2004, Biosensors & bioelectronics.

[36]  J. Horiuchi,et al.  Simplified method for estimation of microbial activity in compost by ATP analysis. , 2003, Bioresource technology.

[37]  C. Thurston,et al.  Microbial fuel-cells , 1993 .

[38]  D. R. Bond,et al.  Electrode-Reducing Microorganisms That Harvest Energy from Marine Sediments , 2002, Science.

[39]  Byung Hong Kim,et al.  Continuous electricity production from artificial wastewater using a mediator-less microbial fuel cell. , 2006, Bioresource technology.

[40]  E. Cortón,et al.  Microbial fuel cells applied to the metabolically based detection of extraterrestrial life. , 2010, Astrobiology.

[41]  J. Hughes,et al.  Microbial fuel cell biosensor for in situ assessment of microbial activity. , 2008, Biosensors & bioelectronics.

[42]  A. Magic-Knezev,et al.  Optimisation and significance of ATP analysis for measuring active biomass in granular activated carbon filters used in water treatment. , 2004, Water research.

[43]  Jaai Kim,et al.  Optimization of adenosine 5′-triphosphate extraction for the measurement of␣acidogenic biomass utilizing whey wastewater , 2006, Biodegradation.

[44]  Keith Scott,et al.  Electricity generation from the treatment of wastewater with a hybrid up‐flow microbial fuel cell , 2010, Biotechnology and bioengineering.

[45]  J. Oades,et al.  Adenosine triphosphate content of the soil microbial biomass , 1979 .

[46]  Donald R. Metzler,et al.  Stimulating the In Situ Activity of Geobacter Species To Remove Uranium from the Groundwater of a Uranium-Contaminated Aquifer , 2003, Applied and Environmental Microbiology.

[47]  D. Karakashev,et al.  High yield simultaneous hydrogen and ethanol production under extreme-thermophilic (70 °C) mixed culture environment , 2009 .

[48]  Yingying Wang,et al.  Measurement and interpretation of microbial adenosine tri-phosphate (ATP) in aquatic environments. , 2010, Water research.

[49]  Keith Scott,et al.  Electricity generation from cysteine in a microbial fuel cell. , 2005, Water research.

[50]  C. W. Marshall,et al.  Electricity generation by thermophilic microorganisms from marine sediment , 2008, Applied Microbiology and Biotechnology.

[51]  B. Jørgensen,et al.  Oxidation and reduction of radiolabeled inorganic sulfur compounds in an estuarine sediment, Kysing Fjord, Denmark , 1990 .

[52]  Jae Kyung Jang,et al.  Improvement of a microbial fuel cell performance as a BOD sensor using respiratory inhibitors. , 2005, Biosensors & bioelectronics.

[53]  D. Lovley,et al.  Deep subsurface microbial processes , 1995 .

[54]  Jing Liu,et al.  Microbial BOD sensors for wastewater analysis. , 2002, Water research.

[55]  E. E. L O G A N,et al.  Bioaugmentation for Electricity Generation from Corn Stover Biomass Using Microbial Fuel Cells , 2009 .

[56]  Willy Verstraete,et al.  Tubular microbial fuel cells for efficient electricity generation. , 2005, Environmental science & technology.

[57]  Jizhong Zhou,et al.  Global Transcriptional Profiling of Shewanella oneidensis MR-1 during Cr(VI) and U(VI) Reduction , 2005, Applied and Environmental Microbiology.

[58]  C. Lee Burras,et al.  Equations for Predicting Soil Organic Carbon Using Loss‐on‐Ignition for North Central U.S. Soils , 2002 .