Depinning-Induced Capillary Wave during the Sliding of a Droplet on a Textured Surface.

Surfaces covered with hydrophobic micro-/nanoscale textures can allow water droplets to slide easily because of low contact angle hysteresis. In contrast to the case of a droplet sliding on a smooth surface, when a droplet slides on a textured surface, it must recede from the textures at its rear edge and the resultant depinning events induce a capillary wave on the surface of the droplet. Although this depinning-induced capillary wave can be observed to some extent through high-speed imaging, important parameters of the wave, such as the wavelength and frequency, and the factors that determine these parameters are not fully understood. We report direct measurements of this depinning-induced capillary wave using microelectromechanical systems (MEMS)-based force sensors fabricated on a textured surface. Such sensor measurements reveal the frequency of the vibration occurring on the surface of the droplet, from which it is possible to calculate the wavelength of the capillary wave. We show that the frequency and wavelength of the depinning-induced capillary wave during the sliding of a water droplet on a micropillar array depend upon neither the size of the droplet nor its sliding velocity. However, the frequency (wavelength) decreases (increases) as the pitch of the micropillar array increases. We argue that the wavelength of the depinning-induced capillary wave is equal to the maximum length of the liquid bridges that develop at the micropillars before depinning. This hypothesis is confirmed by comparing the wavelengths obtained from the sensor measurements to the maximum liquid-bridge lengths calculated from observations using a high-speed camera.

[1]  Andrea Mammoli,et al.  Effective slip on textured superhydrophobic surfaces , 2005 .

[2]  Evelyn N Wang,et al.  Condensation on superhydrophobic surfaces: the role of local energy barriers and structure length scale. , 2012, Langmuir : the ACS journal of surfaces and colloids.

[3]  R. Blossey.  Self-cleaning surfaces — virtual realities , 2003, Nature materials.

[4]  Kripa K. Varanasi,et al.  Self-similarity of contact line depinning from textured surfaces , 2013, Nature Communications.

[5]  Jonathan P. Rothstein,et al.  Drag reduction in turbulent flows over superhydrophobic surfaces , 2009 .

[6]  F. He,et al.  Sliding of water droplets on microstructured hydrophobic surfaces. , 2010, Langmuir : the ACS journal of surfaces and colloids.

[7]  S. B. Lindström,et al.  Water drop friction on superhydrophobic surfaces. , 2013, Langmuir : the ACS journal of surfaces and colloids.

[8]  Nancy R. Sottos,et al.  Bioinspired Materials for Self-Cleaning and Self-Healing , 2008 .

[9]  Fabrice Pardo,et al.  Drops onto gradients of texture , 2009 .

[10]  Ilker S. Bayer,et al.  Microscopic Receding Contact Line Dynamics on Pillar and Irregular Superhydrophobic Surfaces , 2015, Scientific Reports.

[11]  Driving droplet by scale effect on microstructured hydrophobic surfaces. , 2012, Langmuir : the ACS journal of surfaces and colloids.

[12]  D. Quéré.  Wetting and Roughness , 2008 .

[13]  J. Boreyko,et al.  Self-propelled dropwise condensate on superhydrophobic surfaces. , 2009, Physical review letters.

[14]  Seung‐Woo Cho,et al.  Path-programmable water droplet manipulations on an adhesion controlled superhydrophobic surface , 2015, Scientific Reports.

[15]  Isao Shimoyama,et al.  Two-axis MEMS-based force sensor for measuring the interaction forces during the sliding of a droplet on a micropillar array , 2015 .

[16]  I. Parkin,et al.  Superhydrophobic surfaces as an on-chip microfluidic toolkit for total droplet control. , 2013, Analytical chemistry.

[17]  P. Gennes,et al.  Capillarity and Wetting Phenomena , 2004 .

[18]  Jolanta A Watson,et al.  Self-cleaning of superhydrophobic surfaces by self-propelled jumping condensate , 2013, Proceedings of the National Academy of Sciences.

[19]  Gareth H McKinley,et al.  Robust omniphobic surfaces , 2008, Proceedings of the National Academy of Sciences.

[20]  P. Gennes,et al.  Dynamics of wetting with nonideal surfaces. The single defect problem , 1989 .

[21]  Yuji Suzuki,et al.  Engineering superlyophobic surfaces as the microfluidic platform for droplet manipulation. , 2011, Lab on a chip.

[22]  Isao Shimoyama,et al.  Viscosity measurement based on the tapping-induced free vibration of sessile droplets using MEMS-based piezoresistive cantilevers. , 2015, Lab on a chip.

[23]  D. Quéré,et al.  Contact angle hysteresis generated by strong dilute defects. , 2009, The journal of physical chemistry. B.

[24]  P. Gennes.  Wetting: statics and dynamics , 1985 .

[25]  Chang-Hwan Choi,et al.  Structured surfaces for a giant liquid slip. , 2008, Physical review letters.

[26]  C. Kim,et al.  A dynamic Cassie-Baxter model. , 2015, Soft matter.

[27]  P. G. de Gennes,et al.  A model for contact angle hysteresis , 1984 .