Oxygen reduction activity of Pt and Pt–Mn–Co electrocatalysts sputtered on nano-structured thin film support

Abstract We report on extensive measurements of oxygen reduction activity of Pt and Pt–Co–Mn electrocatalysts using the rotating ring-disk electrode (RRDE) method. The electrocatalysts were prepared by sputtering from Pt or Pt, Co and Mn targets onto 3M's nano-structured thin film support (NSTF) structures. The area specific activity of Pt/NSTF, measured in 0.1 M HClO 4 and at room temperature, is similar to that of bulk Pt. The area specific measurements show a 20 mV reduction in the Pt–Co–Mn/NSTF overpotential compared to Pt/NSTF. The corresponding kinetic gain in the area specific activity of the ternary alloy is about a factor of two. This ORR enhancement factor observed in the ternary Pt–Co–Mn/NSTF by RRDE measurements is similar to the results obtained in 50 cm 2 H 2 /air fuel cells.

[1]  M. Debe,et al.  Postdeposition growth of a uniquely nanostructured organic film by vacuum annealing , 1994 .

[2]  M. Debe,et al.  Structural characteristics of a uniquely nanostructured organic thin film , 1995 .

[3]  F. Maillard,et al.  Detection of Pt z + Ions and Pt Nanoparticles Inside the Membrane of a Used PEMFC , 2007 .

[4]  Hubert A. Gasteiger,et al.  Handbook of fuel cells : fundamentals technology and applications , 2003 .

[5]  Olivera Kesler,et al.  An oxidation-resistant indium tin oxide catalyst support for proton exchange membrane fuel cells , 2006 .

[6]  N. Marković,et al.  Surface Composition Effects in Electrocatalysis: Kinetics of Oxygen Reduction on Well-Defined Pt3Ni and Pt3Co Alloy Surfaces , 2002 .

[7]  H. Gasteiger,et al.  Activity benchmarks and requirements for Pt, Pt-alloy, and non-Pt oxygen reduction catalysts for PEMFCs , 2005 .

[8]  Hubert A. Gasteiger,et al.  Determination of Catalyst Unique Parameters for the Oxygen Reduction Reaction in a PEMFC , 2006 .

[9]  M. Inaba,et al.  Effect of Agglomeration of Pt/C Catalyst on Hydrogen Peroxide Formation , 2004 .

[10]  P. Kulesza,et al.  Network electrocatalytic films of conducting polymer-linked polyoxometallate-stabilized platinum nanoparticles , 2005 .

[11]  K.H.J. Buschow,et al.  Magneto-optical properties of metallic ferromagnetic materials , 1983 .

[12]  V. Pierron-Bohnes,et al.  Comparative investigation of structural and transport properties of L10 NiPt and Copt phases; the role of magnetism , 1988 .

[13]  Guoying Chen,et al.  DEVELOPMENT OF SUPPORTED BIFUNCTIONAL ELECTROCATALYSTS FOR UNITIZED REGENERATIVE FUEL CELLS , 2002 .

[14]  Philip N. Ross,et al.  Improved Oxygen Reduction Activity on Pt3Ni(111) via Increased Surface Site Availability , 2007, Science.

[15]  Philip N. Ross,et al.  Surface segregation effects in electrocatalysis: Kinetics of oxygen reduction reaction on polycrystalline Pt3Ni alloy surfaces , 2002 .

[16]  F. Uribe,et al.  Platinum monolayer electrocatalysts for oxygen reduction: Effect of substrates, and long-term stability , 2005 .

[17]  J. Dahn,et al.  Acid Stability and Oxygen Reduction Activity of Magnetron-Sputtered Pt1 − x Ta x ( 0 ≤ x ≤ 1 ) Films , 2006 .

[18]  A. Jezierski,et al.  Magnetic order in crystallographically ordered Pt4-y(MnxCr1-x)y alloys , 1986 .

[19]  D. Stevens,et al.  Thermal degradation of the support in carbon-supported platinum electrocatalysts for PEM fuel cells , 2005 .

[20]  T. Jarvi,et al.  Electrocatalytic corrosion of carbon support in PEMFC cathodes , 2004 .

[21]  V. Radmilović,et al.  Oxygen Reduction on Carbon-Supported Pt−Ni and Pt−Co Alloy Catalysts , 2002 .

[22]  R. L. Clarke,et al.  Electrodes based on Magnéli phase titanium oxides: the properties and applications of Ebonex® materials , 1998 .

[23]  P N Ross,et al.  The impact of geometric and surface electronic properties of pt-catalysts on the particle size effect in electrocatalysis. , 2005, The journal of physical chemistry. B.

[24]  Hubert A. Gasteiger,et al.  Instability of Pt ∕ C Electrocatalysts in Proton Exchange Membrane Fuel Cells A Mechanistic Investigation , 2005 .

[25]  R. Smoluchowski,et al.  Elements of X‐Ray Diffraction , 1957 .

[26]  K. Sasaki,et al.  Stabilization of Platinum Oxygen-Reduction Electrocatalysts Using Gold Clusters , 2007, Science.

[27]  D. Martin,et al.  A New Superlattice in Co‐Pt Alloys , 1952 .