Eco-efficiency in the production chain of Dutch semi-hard cheese

Abstract To achieve a sustainable cheese production chain, not only its ecological impact must be minimized, but economic value must be added along the chain also. The objectives of this study were to gain insight into ecological hotspots of the cheese chain, and to judge the ecological impact of chain stages in the context of their economic value added. A life cycle assessment (LCA) was performed to determine hotspots for global warming potential (GWP), land use and fossil energy use during production of Dutch, semi-hard cheese. To place ecological impact in an economic perspective, eco-efficiency of chain stages was determined, which was defined as the ratio of gross value added, and ecological impact. LCA and economic computations were based on empirical data from a specific Dutch cheese chain. Production of 1 kg cheese resulted in a GWP of 8.5 kg CO 2 -eq., and required 6.8 m 2 land and 47.2 MJ energy. Of all stages, on-farm milk production contributed most to GWP (65%), and to land use (58%), followed by cultivation of concentrate ingredients (12% to GWP and 24% to land use). Regarding energy use, cultivation of concentrate ingredients had the highest contribution (33%). The after farm gate stages cheese-making, storage, and packaging each contributed about 7%–13% to energy use and about 3%–4% to GWP, whereas retail had a marginal impact. To decrease the ecological impact of cheese production, reducing the impact of on-farm milk production (e.g., by using feed ingredients that reduce enteric methane emission in the cow), and reducing the impact of cultivation of concentrate ingredients (e.g., by using locally produced ingredients or by-products) would be most effective. Stages after farm gate can lower their impact by minimizing use of fossil energy and use of alternative energy resources. Minimizing losses of milk and cheese in stages after farm gate, furthermore, is an important improvement option to reduce the impact per kg cheese of the whole chain. Total gross value added of the whole chain was €5.94 per kg cheese. On-farm milk production added most economic value (34%), followed by retail (27%), cheese-making (17%), and packaging (17%). Total eco-efficiency of cheese was €0.78 per kg CO 2 -eq., €1.03 per m 2 land, and €0.16 per MJ energy. Of all stages, cultivation of concentrate ingredients and storage had the lowest eco-efficiency for each impact, whereas retail had the highest. Combining ecological impact and eco-efficiency, shows that cultivation of concentrate ingredients is the most problematic stage.

[1]  R. Helminen,et al.  Developing tangible measures for eco‐efficiency: the case of the Finnish and Swedish pulp and paper industry , 2000 .

[2]  C. Cederberg,et al.  Life cycle assessment of milk production — a comparison of conventional and organic farming , 2000 .

[3]  Juha-Matti Katajajuuri,et al.  Experiences and Improvement Possibilities­LCA Case Study of Broiler Chicken Production , 2007 .

[4]  M. D. Vries,et al.  Comparing environmental impacts for livestock products: A review of life cycle assessments , 2010 .

[5]  H. Steinfeld,et al.  Livestock's long shadow: environmental issues and options. , 2006 .

[6]  E. V. van Ierland,et al.  Protein Chains and Environmental Pressures: A Comparison of Pork and Novel Protein Foods , 2004 .

[7]  C. Basset-Mens,et al.  Eco-efficiency of intensification scenarios for milk production in New Zealand , 2009 .

[8]  A. Hospido,et al.  Simplified life cycle assessment of galician milk production , 2003 .

[9]  Stefan Albrecht,et al.  R&D decision support by parallel assessment of economic, ecological and social impact -- Adipic acid from renewable resources versus adipic acid from crude oil , 2009 .

[10]  Jeroen B. Guinee,et al.  Handbook on life cycle assessment operational guide to the ISO standards , 2002 .

[11]  A. Ahvonen,et al.  Regional socio‐economic importance of fisheries in Finland , 2001 .

[12]  I.J.M. de Boer,et al.  Relating life cycle assessment indicators to gross value added for Dutch dairy farms , 2009 .

[13]  Gjalt Huppes,et al.  Eco-efficiency guiding micro-level actions towards sustainability: Ten basic steps for analysis☆ , 2009 .

[14]  J. Duxbury,et al.  The significance of agricultural sources of greenhouse gases , 1994, Fertilizer research.

[15]  J. Berlin.  Environmental life cycle assessment (LCA) of Swedish semi-hard cheese , 2002 .

[16]  S. Schneider,et al.  Climate Change 2007 Synthesis report , 2008 .

[17]  Merete Høgaas Eide,et al.  Life cycle assessment (LCA) of industrial milk production , 2002 .

[18]  Uwe Geier,et al.  Life cycle assessment framework in agriculture on the farm level , 2000 .

[19]  S. Qanbari,et al.  Association of Milk Protein Genotypes with Production Traits and Somatic Cell Count of Holstein Cows , 2008 .

[20]  E. Hyman,et al.  Reorienting export production to benefit rural producers: Annatto processing in Peru , 1990 .

[21]  T. Bennett.  Environment and Agriculture , 2010 .

[22]  P. Eder,et al.  Environmental Improvement Potentials of Meat and Dairy Products , 2008 .

[23]  Hans-Jürgen Dr. Klüppel,et al.  ISO 14041: Environmental management — life cycle assessment — goal and scope definition — inventory analysis , 1998 .

[24]  M.H.A. de Haan,et al.  Vermindering van de uitstoot van broeikasgassen op het melkveebedrijf : berekeningen voor praktijkbedrijven = Decreasing greenhouse gas emissions on dairy farms , 2009 .

[25]  I. D. Boer,et al.  Life cycle assessment of conventional and organic milk production in the Netherlands , 2008 .

[26]  R. Scholz,et al.  Life cycle management on Swiss fruit farms: Relating environmental and income indicators for apple-growing , 2006 .

[27]  D W Pennington,et al.  Life cycle assessment: Part 1: Framework, goal and scope definition, inventory analysis, and applications , 2004 .

[28]  N. Holden,et al.  Analysis of greenhouse gas emissions from the average Irish milk production system , 2005 .

[29]  S. Hörtenhuber,et al.  Greenhouse gas emissions from selected Austrian dairy production systems—model calculations considering the effects of land use change , 2010, Renewable Agriculture and Food Systems.

[30]  S. Ryding.  ISO 14042 Environmental management • Life cycle assessment • life cycle impact assessment , 1999 .

[31]  Livio D. DeSimone,et al.  Eco‐Efficiency: The Business Link to Sustainable Development , 1997 .

[32]  Henri Lecouls,et al.  ISO 14043: Environmental management · life cycle assessment · life cycle interpretation , 1999 .