Dual-Rate Adaptive Control for Mixed Separation Thickening Process Using Compensation Signal Based Approach

The mixed separation thickening process (MSTP) of hematite beneficiation is a strong nonlinear cascade process with frequency of slurry pump as input, underflow slurry flow-rate (USF) as inner-loop output, and underflow slurry density (USD) as outer-loop output. The model parameters such as settling velocity of slurry particles and slurry height are unknown and nonlinear. Moreover, these model parameters vary from flotation middling, sewage, and magnetic separation slurry. In this paper, the unknown change of the above dynamic characteristics are described by the previous sample unmodeled dynamics and its change rate. A novel adaptive controller using compensation signal based approach is developed. Inner-loop closed-loop control system equation and lifting technology are adopted to develop dual rate adaptive control method. Two compensation signals are constructed and added onto the linear proportional-integral (PI) controller. Such two compensation signals aim at eliminating the effects of the previous sample unmodeled dynamics and tracking error, respectively. The stability and convergence analysis is given and a simulation experiment on hardware-in-the-loop simulation system of MSTP based on industrial data is carried out, where it shows that the USD, USF, and its changing rate can be controlled well inside their targeted ranges when the system is subjected to unknown variations of its parameters.

[1]  Tianyou Chai,et al.  Networked Multirate Output Feedback Control for Setpoints Compensation and Its Application to Rougher Flotation Process , 2014, IEEE Transactions on Industrial Electronics.

[2]  Mark S. Klima,et al.  Development and application of a dynamic model for hindered-settling column separations , 2004 .

[3]  Jyh-Cheng Jeng.  Simultaneous closed-loop tuning of cascade controllers based directly on set-point step-response data , 2014 .

[4]  Jan J. Cilliers,et al.  A review of froth flotation control , 2011 .

[5]  Hangil Park,et al.  Experimental studies and modeling of surface bubble behaviour in froth flotation , 2015 .

[6]  F. H. Garner,et al.  Chemical Engineering , 1955, Nature.

[7]  Raimund Bürger,et al.  Advanced methods of flux identification for clarifier–thickener simulation models , 2014 .

[8]  Katsuhiko Ogata,et al.  Discrete-time control systems (2nd ed.) , 1995 .

[9]  Raimund Bürger,et al.  Computational uncertainty quantification for a clarifier-thickener model with several random perturbations: A hybrid stochastic Galerkin approach , 2016, Comput. Chem. Eng..

[10]  William A. Poe.  Chapter 3 – Process Control , 2017 .

[11]  S. Diehl.  A regulator for continuous sedimentation in ideal clarifier–thickener units , 2008 .

[12]  Katsuhiko Ogata,et al.  Discrete-time control systems , 1987 .

[13]  Graham Goodwin,et al.  Discrete time multivariable adaptive control , 1979, 1979 18th IEEE Conference on Decision and Control including the Symposium on Adaptive Processes.

[14]  Tianyou Chai,et al.  An intelligent switching control for a mixed separation thickener process , 2016 .

[15]  F. Betancourt,et al.  Modeling and controlling clarifier–thickeners fed by suspensions with time-dependent properties , 2014 .

[16]  Tianyou Chai,et al.  A Data-Driven Dual-Rate Control Method for a Heat Exchanging Process , 2017, IEEE Transactions on Industrial Electronics.

[17]  B. Pasik-Duncan,et al.  Adaptive Control , 1996, IEEE Control Systems.

[18]  Daniel Sbarbaro,et al.  On the control of sludge level and underflow concentration in industrial thickeners , 2011 .

[19]  Y. L. Sidrak.  Control of the thickener operation in alumina production , 1997 .

[20]  Tianyou Chai,et al.  Data-Based Virtual Unmodeled Dynamics Driven Multivariable Nonlinear Adaptive Switching Control , 2011, IEEE Transactions on Neural Networks.

[21]  Shuzhi Sam Ge,et al.  Consensus-based distributed cooperative learning control for a group of discrete-time nonlinear multi-agent systems using neural networks , 2014, Autom..

[22]  Miroslav Krstic.  On using least-squares updates without regressor filtering in identification and adaptive control of nonlinear systems , 2009, Autom..