Experimental and modeling study of the oxidation of natural gas in a premixed flame, shock tube, and jet-stirred reactor

Abstract New experimental results have been obtained for the oxidation of a stoichiometric premixed synthetic natural gas flame at low pressure (10.6 kPa). Mole fraction profiles of stable and reactive species and temperature were measured using molecular beam/mass spectrometry, gas chromatography, and thermocouple techniques. A detailed reaction mechanism has been evaluated by comparison of computed and measured species mole fraction profiles. Good agreement was obtained for most molecular species (reactants, intermediate species, and final products). The proposed mechanism was also validated by modeling the laminar flame speeds of methane/air, ethane/air, and propane/air flames reported in the literature over a wide range of equivalence ratios. The model reproduces correctly the experimental values. The model was also used to simulate new experimental results obtained in a jet-stirred reactor (JSR) at atmospheric pressure and variable equivalence ratio ( Φ =0.75:1.0:1.5) for the oxidation of methane–ethane mixtures representative of natural gas. The ignition delays of methane–oxygen–argon and methane–ethane–oxygen were modeled. Sensitivity analyses and reaction path analyses, based on species rates of reaction, were used to interpret the results, especially the effect of higher alkanes on the oxidation of natural gas.

[1]  Jürgen Warnatz,et al.  Chemistry of high temperature combustion of alkanes up to octane , 1985 .

[2]  Peter Glarborg,et al.  Ammonia conversion and NOx formation in laminar coflowing nonpremixed methane-air flames , 2002 .

[3]  Norman Cohen,et al.  Are reaction rate coefficients additive? Revised transition state theory calculations for OH + alkane reactions , 1991 .

[4]  Alan Williams,et al.  A shock-tube investigation of the ignition of lean methane and n-butane mixtures with oxygen , 1969 .

[5]  Philippe Dagaut,et al.  A comparative study of the kinetics of benzene formation from unsaturated C2 to C4 hydrocarbons , 1998 .

[6]  C. P. Lazzara,et al.  Concentration profiles for radical species in a methane-oxygen-argon flame , 1973 .

[7]  P. Dagaut,et al.  Isobutene Oxidation and Ignition: Experimental and Detailed Kinetic Modeling Study , 1998 .

[8]  William J. Pitz,et al.  Chemical kinetics of the high pressure oxidation of n-butane and its relation to engine knock☆ , 1986 .

[9]  R. Walker.  Temperature coefficients for reactions of OH radicals with alkanes between 300 and 1000 K , 1985 .

[10]  G. B. Skinner,et al.  Shock-tube investigation of ignition in methane--oxygen--argon mixtures. [Temperature from 1500 to 2150/sup 0/K and pressures of 2 to 10 atm] , 1971 .

[11]  M. Cathonnet,et al.  KINETIC STUDY OFN-BUTANE OXIDATION , 1989 .

[12]  N. Peters,et al.  Reduced Kinetic Mechanisms for Applications in Combustion Systems , 1993 .

[13]  A. Burcat,et al.  Shock-tube investigation of comparative ignition delay times for C1-C5 alkanes , 1971 .

[14]  A. El-Sherif.  Effects of natural gas composition on the nitrogen oxide, flame structure and burning velocity under laminar premixed flame conditions , 1998 .

[15]  J. N. Bradley,et al.  Single-pulse shock tube studies of hydrocarbon pyrolysis. Part 6.—The pyrolysis of isobutene , 1976 .

[16]  Anthony M. Dean,et al.  Predictions of pressure and temperature effects upon radical addition and recombination reactions , 1985 .

[17]  C. Paillard,et al.  Low hydrocarbon mixtures ignition delay times investigation behind reflected shock waves , 2002 .

[18]  P. Frank,et al.  Detailed kinetic reaction mechanism for cyclohexane oxidation at pressure up to ten atmospheres , 2000 .

[19]  H. Richter,et al.  Investigation of stoichiometric methane/air/benzene (1.5%) and methane/air low pressure flames , 2003 .

[20]  S. Davis,et al.  Determination of and Fuel Structure Effects on Laminar Flame Speeds of C1 to C8 Hydrocarbons , 1998 .

[21]  G. Andrews,et al.  The burning velocity of methane-air mixtures , 1972 .

[22]  Robert N. Goldberg,et al.  Evaluated activity and osmotic coefficients for aqueous solutions: Bi‐univalent compounds of zinc, cadmium, and ethylene bis(trimethylammonium) chloride and iodide , 1981 .

[23]  R. R. Baldwin,et al.  Rate constants for hydrogen + oxygen system, and for H atoms and OH radicals + alkanes , 1979 .

[24]  P. Desgroux,et al.  Coupling of gas chromatography and molecular beam/mass spectrometry analytical techniques: Application to flame structure study , 1999 .

[25]  Robert Shaw,et al.  A compilation of kinetic parameters for the thermal degradation of n‐alkane molecules , 1980 .

[26]  R. R. Baldwin,et al.  Rate constants for elementary steps in hydrocarbon oxidation , 1977 .

[27]  Michael Frenklach,et al.  Shock-initiated ignition in methane-propane mixtures , 1984 .

[28]  P. Dagaut,et al.  A jet-stirred reactor for kinetic studies of homogeneous gas-phase reactions at pressures up to ten atmospheres (∼1 MPa) , 1986 .

[29]  R. W. Walker,et al.  Reactions of HO2 radicals in combustion chemistry , 1989 .

[30]  A. Burcat,et al.  The Effect of Higher Alkanes on the Ignition of Methane-Oxygen-Argon Mixtures in Shock Waves , 1972 .

[31]  G. B. Skinner,et al.  Shock tube investigation of ignition inethane-oxygen-argon mixtures , 1971 .

[32]  W. Tsang,et al.  Mechanism and rate constants for the reactions of hydrogen atoms with isobutene at high temperatures , 1989 .

[33]  R. Günther,et al.  Measurements of burning velocity in a flat flame front , 1972 .

[34]  J. C. Boettner,et al.  Kinetic study of n‐heptane oxidation , 1992 .

[35]  R. Cvetanovic.  Evaluated Chemical Kinetic Data for the Reactions of Atomic Oxygen O(3P) with Unsaturated Hydrocarbons , 1987 .

[36]  S. Benson,et al.  Pyrolysis of methyl chloride, a pathway in the chlorine-catalyzed polymerization of methane , 1984 .

[37]  J. Warnatz,et al.  Resolution of gas phase and surface combustion chemistry into elementary reactions , 1992 .

[38]  P. Dagaut,et al.  Natural gas and blends oxidation and ignition: Experiments and modeling , 1994 .

[39]  John T. Herron,et al.  Evaluated Chemical Kinetic Data for the Reactions of Atomic Oxygen O(3P) with Saturated Organic Compounds in the Gas Phase , 1988 .

[40]  James A. Miller,et al.  Kinetic modeling of hydrocarbon/nitric oxide interactions in a flow reactor , 1998 .

[41]  P. G. Hill,et al.  Laminar Burning Velocities of Stoichiometric Mixtures of Methane with Propane and Ethane Additives , 1988 .

[42]  Dimitrios T. Hountalas,et al.  Experimental investigation concerning the effect of natural gas percentage on performance and emissions of a DI dual fuel diesel engine , 2003 .

[43]  C. Westbrook,et al.  A kinetic modeling study of n-pentane oxidation in a well-stirred reactor , 1988 .

[44]  G. Andrews,et al.  Determination of burning velocities: A critical review , 1972 .

[45]  L. J. Spadaccini,et al.  Ignition delay characteristics of methane fuels , 1994 .