Experimental and computer performance evaluation of a movable thermal insulation for energy conservation in greenhouses

In recent years internal night curtains or thermal screens have appeared to be useful in reducing heat losses in greenhouses during cold weather. Most of the curtains used consisted of single-layer thin plastic materials, and lack of storage space inside the greenhouse may prevent use of thicker sections. The difficulty with thermal screens operating on the outside of the structure is that they are exposed to the weather. This paper describes the construction and experimental evaluation of a greenhouse thermal screen system where heavily insulated and relatively thick screens operate in-between the glazings of a double-glazed greenhouse. The thermal screen system was evaluated on a commercial size, arch (semi-circular) greenhouse with inflated outer polythylene and inner fibreglass glazings. A computer program was developed to predict the thermal performance of the shutter system in reducing greenhouse energy consumption. The comparisons between the experimental and computer results showed a high degree of correlation, and these results indicated that under average climatic conditions the heating requirements of a double-glazed greenhouse using the thermal screens could be reduced by as much as 60 to 80%

[1]  M. Iqbal,et al.  Wind Coefficients from Long Semi-Circular Greenhouses , 1976 .

[2]  R. A. Aldrich,et al.  Internal Curtains for Energy Conservation in Greenhouses , 1977 .

[3]  David R. Mears,et al.  THE RUTGERS SYSTEM FOR SOLAR HEATING OF COMMERCIAL GREENHOUSES , 1980 .

[4]  E. A. Arinze,et al.  A Dynamic Thermal Performance Simulation Model of an Energy Conserving Greenhouse With Thermal Storage , 1984 .

[5]  W. Swinbank.  Long‐wave radiation from clear skies , 1963 .

[6]  L. R. Wilhelm,et al.  Numerical Calculation of Psychrometric Properties in SI Units , 1976 .

[7]  Louis D. Albright,et al.  Analytical Determination of the Effect on Greenhouse Heating Requirements of Using Night Curtains , 1980 .

[8]  Robert Fuller,et al.  A transient model of the interaction between crop, environment and greenhouse structure for predicting crop yield and energy consumption , 1983 .

[9]  C. Murphy,et al.  Simultaneous determinations of the sensible and latent heat transfer coefficients for tree leaves , 1977 .

[10]  C. A. Riegel.  Comments on “A Simple but Accurate Formula for the Saturation Vapor Pressure Over Liquid Water” , 1974 .

[11]  J. N. Walker,et al.  Condensation and Resultant Humidity in Greenhouses During Cold Weather , 1968 .

[12]  L. D. Albright,et al.  A highly insulative thermal curtain for greenhouses. , 1980 .

[13]  M. Iqbal,et al.  Configuration Factors for Greenhouses , 1971 .

[14]  Richard C. Jordan.  Low temperature engineering application of solar energy , 1967 .

[15]  M. G. Amsen.  THE INFLUENCE OF CONVECTIVE SENSIBLE HEAT TRANSFER ON THE GREENHOUSE AND THE CURTAIN EFFECT , 1975 .

[16]  David R. Mears,et al.  Reducing Heat Losses in Polyethylene Covered Greenhouses , 1976 .

[17]  L. L. Boyd,et al.  Dynamic Simulation of Plant Growth and Environment in the Greenhouse , 1971 .