Analysis of two heat storage integrations for an Organic Rankine Cycle Parabolic trough solar power plant

Abstract Among the concentrated solar power technologies, those based on Organic Rankine Cycles have a very low market presence. However they have favorable characteristics for applications with low temperature and small/medium size ( In this paper is analyzed a 5 MW parabolic trough plant integrated with an Organic Rankine cycle power block and thermal storage. On this purpose, two different thermal storage integrations are analyzed. They are based on two different heat storage layouts: direct system using Hitec XL both as Heat Transfer Fluid and as storage medium; indirect system using Therminol VP-1 as Heat Transfer Fluid and Hitec XL as storage medium. Full system performance at rated and off-design conditions is presented operating with different organic working fluids. Its potential application and main challenges for its development are discussed in terms of performance and costs. Among the analyzed working fluids, the best results were obtained for the cycle working with Toluene with an efficiency at the power block of 31.5% and an estimated power block cost of 825 €/kW. The indirect storage layout was the most interesting from the point of view of Levelized Electricity Cost (16.19 c€/kW) and productivity (28.2 GW h/y for a 5 MW el plant) for 10 h of storage However, it results in a storage tanks volume 26% greater than the obtained for the equivalent direct storage layout. The results show the competitiveness and the potential of the proposed integrated small size parabolic trough designs for isolated applications as mines or for some distributed generation uses where grid capacity is limited.

[1]  Terrence L. Chambers,et al.  Demonstration of Pilot Scale Large Aperture Parabolic Trough Organic Rankine Cycle Solar Thermal Power Plant in Louisiana , 2013 .

[2]  Saili Li,et al.  Preliminary design and off-design performance analysis of an Organic Rankine Cycle for geothermal sources , 2015 .

[3]  Ricardo Chacartegui,et al.  Alternative cycles based on carbon dioxide for central receiver solar power plants , 2011 .

[4]  A. Mitsos,et al.  Effect of heat transfer structures on thermoeconomic performance of solid thermal storage , 2014 .

[5]  Amit Jain,et al.  Optimizing the cost and performance of parabolic trough solar plants with thermal energy storage in India , 2013 .

[6]  M. Valdés,et al.  Solar multiple optimization for a solar-only thermal power plant, using oil as heat transfer fluid in the parabolic trough collectors , 2009 .

[7]  Guo Tao,et al.  Performance comparison and parametric optimization of subcritical Organic Rankine Cycle (ORC) and transcritical power cycle system for low-temperature geothermal power generation , 2011 .

[8]  Frank P. Incropera,et al.  Fundamentals of Heat and Mass Transfer , 1981 .

[9]  Daniele Cocco,et al.  Comparison of Medium-size Concentrating Solar Power Plants based on Parabolic Trough and Linear Fresnel Collectors , 2014 .

[10]  A. Hammerschmid,et al.  Theoretical Analysis of the Combination of CSP with a Biomass CHP-plant Using ORC-technology in Central Europe , 2014 .

[11]  M. Khalil Bassiouny,et al.  Modeling of heat transfer for flow across tube banks , 2000 .

[12]  I. Dincer,et al.  Thermoeconomic optimization of three trigeneration systems using organic Rankine cycles: Part II – Applications , 2013 .

[13]  D. Sánchez,et al.  Alternative ORC bottoming cycles FOR combined cycle power plants , 2009 .

[14]  Fateme Ahmadi Boyaghchi,et al.  Thermoeconomic assessment and multi objective optimization of a solar micro CCHP based on Organic Rankine Cycle for domestic application , 2015 .

[15]  Charles F. Kutscher,et al.  Generation of a Parabolic Trough Collector Efficiency Curve From Separate Measurements of Outdoor Optical Efficiency and Indoor Receiver Heat Loss , 2012 .

[16]  M. M. Prieto,et al.  Thermodynamic analysis of high-temperature regenerative organic Rankine cycles using siloxanes as working fluids , 2011 .

[17]  Flavio Manenti,et al.  Assessment of Direct Thermal Energy Storage Technologies for Concentrating Solar Power Plants , 2013 .

[18]  N. Lai,et al.  Working fluids for high-temperature organic Rankine cycles , 2007 .

[19]  Eduardo Zarza,et al.  Performance model and annual yield comparison of parabolic-trough solar thermal power plants with either nitrogen or synthetic oil as heat transfer fluid , 2014 .

[20]  Lana S. Pantić,et al.  A review of concentrating solar power plants in the world and their potential use in Serbia , 2012 .

[21]  Tsu-Chin Tsao,et al.  Control of a Base Load and Load-Following Regulating Organic Rankine Cycle for Waste Heat Recovery in Heavy-Duty Diesel Powertrain , 2015 .

[22]  Riccardo Basosi,et al.  Evaluation of the environmental sustainability of a micro CHP system fueled by low-temperature geothermal and solar energy , 2014 .

[23]  Alfredo Gimelli,et al.  Small-scale Concentrated Solar Power (CSP) Plant: ORCs Comparison for Different Organic Fluids , 2014 .

[24]  María José Montes,et al.  Energy management in solar thermal power plants with double thermal storage system and subdivided solar field , 2011 .

[25]  Norberto Fueyo,et al.  Analysis of CSP plants for the definition of energy policies: The influence on electricity cost of solar multiples, capacity factors and energy storage , 2010 .

[26]  J. Forrester,et al.  The Value of CSP with Thermal Energy Storage in Providing Grid Stability , 2014 .

[27]  Ennio Macchi,et al.  Power Block Off-design Control Strategies for Indirect Solar ORC Cycles , 2015 .

[28]  Khamid Mahkamov,et al.  Solar energy storage using phase change materials , 2007 .

[29]  Eckhard Lüpfert,et al.  Advances in Parabolic Trough Solar Power Technology , 2002 .

[30]  Sharon J. W. Klein,et al.  Multi-criteria decision analysis of concentrated solar power with thermal energy storage and dry cooling. , 2013, Environmental science & technology.

[31]  E. Prabhu,et al.  Solar Trough Organic Rankine Electricity System (STORES) Stage 1: Power Plant Optimization and Economics; November 2000 -- May 2005 , 2006 .

[32]  Yiping Dai,et al.  Off-design performance analysis of a solar-powered organic Rankine cycle , 2014 .

[33]  George Kosmadakis,et al.  An investigation of design concepts and control strategies of a double-stage expansion solar organic Rankine cycle , 2015 .

[34]  Gequn Shu,et al.  Fluids and parameters optimization for the organic Rankine cycles (ORCs) used in exhaust heat recovery of Internal Combustion Engine (ICE) , 2012 .

[35]  S. Quoilin,et al.  Performance and design optimization of a low-cost solar organic Rankine cycle for remote power generation , 2011 .

[36]  Paul Denholm,et al.  Enabling Greater Penetration of Solar Power via the Use of CSP with Thermal Energy Storage , 2011 .

[37]  Antonio L. Avila-Marin,et al.  Evaluation of the potential of central receiver solar power plants: Configuration, optimization and trends , 2013 .

[38]  Ricardo Chacartegui,et al.  Alternative Approach to Determining the Preferred Plant Size of Parabolic Trough CSP Power Plants , 2011 .

[39]  Chi-Chuan Wang,et al.  Effect of working fluids on organic Rankine cycle for waste heat recovery , 2004 .

[40]  Maciej Z. Lukawski.  Design and optimization of standardized organic Rankine cycle power plant for European conditions , 2010 .

[41]  Eduardo Zarza,et al.  Parabolic-trough solar collectors and their applications , 2010 .

[42]  Henry Price,et al.  Reducing the Cost of Energy From Parabolic Trough Solar Power Plants , 2003 .

[43]  Elias K. Stefanakos,et al.  Thermal energy storage technologies and systems for concentrating solar power plants , 2013 .

[44]  Craig Turchi,et al.  Parabolic Trough Reference Plant for Cost Modeling with the Solar Advisor Model (SAM) , 2010 .

[45]  G. Glatzmaier,et al.  Developing a Cost Model and Methodology to Estimate Capital Costs for Thermal Energy Storage , 2011 .

[46]  J. Hernández-Moro,et al.  Main parameters influencing present solar electricity costs and their evolution (2012–2050) , 2013 .

[47]  Luisa F. Cabeza,et al.  State of the art on high temperature thermal energy storage for power generation. Part 1—Concepts, materials and modellization , 2010 .

[48]  Valerio Fernández,et al.  DESIGN AND IMPLEMENTATION PLAN OF A 10 MW SOLAR TOWER POWER PLANT BASED ON VOLUMETRIC-AIR TECHNOLOGY IN SEVILLE (SPAIN) , 2000 .

[49]  Suresh V. Garimella,et al.  Economic Optimization of a Concentrating Solar Power Plant With Molten-Salt Thermocline Storage , 2014 .

[50]  G. Angelino,et al.  Multicomponent Working Fluids For Organic Rankine Cycles (ORCs) , 1998 .

[51]  Francesco Calise,et al.  Design and simulation of a prototype of a small-scale solar CHP system based on evacuated flat-plate solar collectors and Organic Rankine Cycle , 2015 .

[52]  Anton Meier,et al.  Pilot Scale Demonstration of a 100-kWth Solar Thermochemical Plant for the Thermal Dissociation of ZnO , 2014 .

[53]  Roland Span,et al.  Techno-economic evaluation of a solar assisted combined heat pump – Organic Rankine Cycle system , 2015 .

[54]  Suresh V. Garimella,et al.  Cyclic operation of molten-salt thermal energy storage in thermoclines for solar power plants , 2013 .

[55]  Ulli Drescher,et al.  Fluid selection for the Organic Rankine Cycle (ORC) in biomass power and heat plants , 2007 .

[56]  Ricardo Chacartegui,et al.  Analysis of Intermediate Temperature Combined Cycles With a Carbon Dioxide Topping Cycle , 2008 .

[57]  Ben-Ran Fu,et al.  Effect of off-design heat source temperature on heat transfer characteristics and system performance of a 250-kW organic Rankine cycle system , 2014 .

[58]  Luisa F. Cabeza,et al.  Review on thermal energy storage with phase change: materials, heat transfer analysis and applications , 2003 .

[59]  Ricardo Chacartegui,et al.  Non‐conventional combined cycle for intermediate temperature systems , 2013 .

[60]  R. A. Johns,et al.  Two-phase heat transfer coefficients of three HFC refrigerants inside a horizontal smooth tube, part I: evaporation , 2000 .

[61]  D. Kearney,et al.  Assessment of a Molten Salt Heat Transfer Fluid in a Parabolic Trough Solar Field , 2003 .

[62]  Christos N. Markides,et al.  An assessment of solar-powered organic Rankine cycle systems for combined heating and power in UK domestic applications , 2015 .

[63]  J. Pacheco,et al.  DEVELOPMENT OF A MOLTEN-SALT THERMOCLINE THERMAL STORAGE SYSTEM FOR PARABOLIC TROUGH PLANTS , 2001 .

[64]  O. A. Jaramillo,et al.  Organic Rankine Cycle coupling with a Parabolic Trough Solar Power Plant for cogeneration and industrial processes , 2016 .

[65]  K. Lovegrove,et al.  Concentrating Solar Power Technology , 2012 .