NO2 sensing properties of one-pot-synthesized ZnO nanowires with Pd functionalization

Abstract The application of NO2 sensor based on metal oxide semiconductor is limited due to high operating temperature and poor selectivity. In this work, a low-temperature and high-performance NO2 sensor based on Pd-functionalized ZnO nanowires (Pd-ZNWs) prepared by a facile one-pot hydrothermal method was reported. The Pd was formed and self-assembled onto the surface of ZnO nanowires (ZNWs) during this one-pot hydrothermal process. Microstructure characterization of Pd-ZNWs indicated that the obtained ZNWs with diameter of 100–250 nm and length of 2–10 μm had a single crystal hexagonal structure, and Pd/PdO nanoparticles of approximately 2–5 nm in diameter were distributed on their surface. Gas sensing measurement showed that Pd-ZNWs exhibited higher response, lower optimal operating temperature, and faster response/recovery speeds towards NO2 than those of pure ZNWs. The maximum responses of 1 mol%, 2 mol%, and 5 mol% Pd-ZNWs towards 1 ppm NO2 were 13.5, 9.4, and 9.4, respectively, which were obtained at a low operating temperature of 100 °C and 30% RH. Pd-ZNWs also showed a significant improvement in sensing selectivity towards NO2. At a high RH condition of 60%, the sensors based on pure and Pd-ZNWs still exhibited noticeable responses, fast response/recovery speeds, and good long-term stability to NO2 gas. The sensing mechanism of Pd-ZNWs towards NO2 was discussed by the combination of electronic and chemical sensitization.

[1]  Xinyong Li,et al.  Facile synthesis of ZnO/Zn2TiO4 core/shell nanowires for photocatalytic oxidation of acetone. , 2010, Journal of hazardous materials.

[2]  Myung Sik Choi,et al.  Synthesis of zinc oxide semiconductors-graphene nanocomposites by microwave irradiation for application to gas sensors , 2017 .

[3]  R. Devan,et al.  One‐Dimensional Metal‐Oxide Nanostructures: Recent Developments in Synthesis, Characterization, and Applications , 2012 .

[4]  Sher Bahadar Khan,et al.  Low-temperature growth of ZnO nanoparticles: photocatalyst and acetone sensor. , 2011, Talanta.

[5]  Majid Darroudi,et al.  Synthesis and characterization of ZnO nanoparticles prepared in gelatin media , 2011 .

[6]  H. Liu,et al.  Palladium-catalyzed intramolecular reductive cross-coupling of Csp2-Csp3 bond formation. , 2014, Chemistry.

[7]  Eicke R. Weber,et al.  Catalytic Growth of Zinc Oxide Nanowires by Vapor Transport , 2001 .

[8]  H. Swart,et al.  Pd2+ doped ZnO nanostructures: Structural, luminescence and gas sensing properties , 2015 .

[9]  Zhiyong Zhang,et al.  Novel SnO 2 @ZnO hierarchical nanostructures for highly sensitive and selective NO 2 gas sensing , 2018 .

[10]  L. Jia,et al.  Low-Temperature and Highly Enhanced NO2 Sensing Performance of Au-Functionalized WO3 Microspheres with a Hierarchical Nanostructure , 2018, ECS Meeting Abstracts.

[11]  M. Scheffler,et al.  Thermodynamic stability of PdO surfaces , 2003, cond-mat/0310235.

[12]  C. Zou,et al.  Synthesis and enhanced NO2 gas sensing properties of ZnO nanorods/TiO2 nanoparticles heterojunction composites. , 2016, Journal of colloid and interface science.

[13]  L. Schmidt‐Mende,et al.  ZnO - nanostructures, defects, and devices , 2007 .

[14]  Jin Hyeok Kim,et al.  Fabrication of nanostructured ZnO thin films based NO2 gas sensor via SILAR technique , 2017 .

[15]  Florian J. Stadler,et al.  Zinc oxide hierarchical nanostructures as potential NO2 sensors , 2017 .

[16]  N. Bârsan,et al.  Enhancing performance of FSP SnO2-based gas sensors through Sb-doping and Pd-functionalization , 2011 .

[17]  Sheikh A. Akbar,et al.  Gas Sensors Based on One Dimensional Nanostructured Metal-Oxides: A Review , 2012, Sensors.

[18]  Pengcheng Xu,et al.  Decoration of ZnO nanowires with Pt nanoparticles and their improved gas sensing and photocatalytic performance , 2010, Nanotechnology.

[19]  Rakesh K. Joshi,et al.  Au Decorated Zinc Oxide Nanowires for CO Sensing , 2009 .

[20]  Tianye Yang,et al.  Synthesis of ZnO nanosheet arrays with exposed (100) facets for gas sensing applications. , 2016, Physical chemistry chemical physics : PCCP.

[21]  Y. Hwang,et al.  Photo-oxidation activities on Pd-doped TiO2 nanoparticles: critical PdO formation effect , 2015 .

[22]  M. Rumyantseva,et al.  Pd nanoparticles on SnO2(Sb) whiskers: Aggregation and reactivity in CO detection , 2013 .

[23]  C. Perry,et al.  New insights into the mechanism of ZnO formation from aqueous solutions of zinc acetate and zinc nitrate , 2014 .

[24]  M. Barteau,et al.  Structure sensitivity of alcohol reactions on (110) and (111) palladium surfaces , 1995 .

[25]  Yawen Tang,et al.  New insights into enhanced electrocatalytic performance of carbon supported Pd–Cu catalyst for formic acid oxidation , 2012 .

[26]  A. K. Tyagi,et al.  Rapid synthesis and characterization of hybrid ZnO@Au core-shell nanorods for high performance, low temperature NO 2 gas sensor applications , 2015 .

[27]  Jin Zhang,et al.  In-situ growth of ZnO nanowire arrays on the sensing electrode via a facile hydrothermal route for high-performance NO2 sensor , 2018 .

[28]  Mingfei Shao,et al.  Hierarchical Nanowire Arrays Based on ZnO Core−Layered Double Hydroxide Shell for Largely Enhanced Photoelectrochemical Water Splitting , 2014 .

[29]  Qing Wang,et al.  Gas Sensors Based on Semiconducting Metal Oxide One-Dimensional Nanostructures , 2009, Sensors.

[30]  A. Sharma,et al.  Effect of surface groups on the luminescence property of ZnO nanoparticles synthesized by sol–gel route , 2012 .

[31]  Zhengguo Jin,et al.  Rapid and selective detection of acetone using hierarchical ZnO gas sensor for hazardous odor markers application. , 2014, Journal of hazardous materials.

[32]  H. Salamati,et al.  Microstructure and optical properties of ZnO nanoparticles prepared by a simple method , 2011 .

[33]  Jie Hu,et al.  Optimization of Pd content in ZnO microstructures for high-performance gas detection , 2015, Journal of Materials Science.

[34]  Il-Doo Kim,et al.  Pd-doped TiO2 nanofiber networks for gas sensor applications , 2010 .

[35]  Tae Jae Lee,et al.  Field emission from well-aligned zinc oxide nanowires grown at low temperature , 2002 .

[36]  Jin Hyeok Kim,et al.  Synthesis of fast response, highly sensitive and selective Ni:ZnO based NO2 sensor , 2016 .

[37]  M. Hon,et al.  Improvement in CO sensing characteristics by decorating ZnO nanorod arrays with Pd nanoparticles and the related mechanisms , 2012 .

[38]  Lili Xing,et al.  Room-temperature self-powered ethanol sensing of a Pd/ZnO nanoarray nanogenerator driven by human finger movement. , 2014, Nanoscale.

[39]  V. Soldi,et al.  Blends of hydroxypropyl methylcellulose and poly(1-vinylpyrrolidone-co-vinyl acetate) : Miscibility and thermal stability , 2005 .

[40]  Sundara Ramaprabhu,et al.  Palladium nanoparticles decorated graphite nanoplatelets for room temperature carbon dioxide adsorption , 2012 .

[41]  Kyung Soo Park,et al.  On-chip fabrication of ZnO-nanowire gas sensor with high gas sensitivity , 2009 .

[42]  Young-soon Kim,et al.  Synthesis and characterization of hydrozincite and its conversion into zinc oxide nanoparticles , 2008 .

[43]  Yuan Zhang,et al.  Self-assemblies of Pd nanoparticles on the surfaces of single crystal ZnO nanowires for chemical sensors with enhanced performances , 2009 .

[44]  Yeon-Tae Yu,et al.  The role of gold catalyst on the sensing behavior of ZnO nanorods for CO and NO2 gases , 2012 .

[45]  Wei Wang,et al.  Highly sensitive hydrogen sensors based on SnO2 nanomaterials with different morphologies , 2015 .

[46]  Taihong Wang,et al.  Enhanced Optical and Sensing Properties of One-Step Synthesized Pt−ZnO Nanoflowers , 2010 .

[47]  Shoou-Jinn Chang,et al.  Highly sensitive ZnO nanowire ethanol sensor with Pd adsorption , 2007 .

[48]  S. S. Kim,et al.  Functionalization of selectively grown networked SnO2 nanowires with Pd nanodots by γ-ray radiolysis , 2011, Nanotechnology.

[49]  Lili Xing,et al.  High gas sensing performance of one-step-synthesized Pd–ZnO nanoflowers due to surface reactions and modifications , 2011, Nanotechnology.

[50]  Lihui Xin,et al.  Optical Properties and Photocatalytic Performances of Pd Modified ZnO Samples , 2009 .

[51]  Alessandro Martucci,et al.  Au and Pt Nanoparticles Effects on the Optical and Electrical Gas Sensing Properties of Sol–Gel-Based ZnO Thin-Film Sensors , 2015, IEEE Sensors Journal.