Effect of pyrolysis upgrading temperature on particulate matter emissions from lignite semi-char combustion

Low-temperature pyrolysis is one of the most promising methods for lignite upgrading and staged utilization, however, its effect on particulate matter emissions from the combustion of upgrad lignite has not been reported before. In this paper, Xilin Gol lignite was pyrolyzed in a fixed-bed reactor at 250–550 °C, the produced semi-char was characterized, and then burned in a drop tube furnace at 1300 °C. Particulate matter emissions from lignite semi-char combustion are collected and measured passing through a 13- stage impactor. Results show that the particulate matter emissions of lignite combustion can be significantly affected through the change of fuel properties by low- temperature pyrolysis upgrading. In the studied pyrolysis temperature range, the most drastic devolatilization, fragmentation, porous structure development, and removal of reactive functional group occur at about 350 °C, when the produced semi-char has the highest combustion reactivity. With the increase of pyrolysis temperature, both emissions of particulate matter <0.5 μm and particulate matter in the range of 0.5–10 μm first decrease and then increase. Pyrolysis upgrading significantly reduces the emissions of particulate matter <0.5 μm from lignite combustion, and the combustion of semi-char produced at 350 °C has the lowest emissions of particulate matter <0.5 μm. The lowest emissions of particulate matter in the range of 0.5–10 μm are obtained from the combustion of semi-char produced at 250 °C. In particulate matter emissions from semi-char combustion, the ultrafine particles <100 nm are rich in sulfur, magnesium, sodium, phosphorus and ferrum while the coarse ones are rich in silicon and aluminum. The influencing mechanism of pyrolysis temperature on particulate matter emissions is complicated and includes many factors, requiring further study. This study indicates that low-temperature pyrolysis upgrading is efficient to control particulate matter emissions from lignite combustion.

[1]  Hong Yao,et al.  Coal combustion-generated aerosols: Formation and properties , 2011 .

[2]  J. Hao,et al.  Influences of coal size, volatile matter content, and additive on primary particulate matter emissions from household stove combustion , 2016 .

[3]  Shiqiu Gao,et al.  Catalytic upgrading of coal pyrolysis tar over char-based catalysts , 2014 .

[4]  R. Kandiyoti,et al.  Combustion reactivity and morphological change in coal chars: Effect of pyrolysis temperature, heating rate and pressure , 1996 .

[5]  Wenying Li,et al.  The oxygen evolution during pyrolysis of HunlunBuir lignite under different heating modes , 2017 .

[6]  Zhihua Wang,et al.  High-temperature pyrolysis behavior of a bituminous coal in a drop tube furnace and further characterization of the resultant char , 2019, Journal of Analytical and Applied Pyrolysis.

[7]  H. Tan,et al.  Characteristics of fine particulate matter formation during combustion of lignite riched in AAEM (alkali and alkaline earth metals) and sulfur , 2018 .

[8]  R. Ruan,et al.  Upgradation of Zhaotong Lignite through microwave drying , 2019, Materials Research Express.

[9]  M. R. Khan.  Prediction of sulphur distribution in products during low temperature coal pyrolysis and gasification , 1989 .

[10]  Lian Zhang,et al.  Effects of coal blending on the reduction of PM10 during high-temperature combustion 1. Mineral transformations , 2008 .

[11]  Guangqian Luo,et al.  Temperature Effect on Central-Mode Particulate Matter Formation in Combustion of Coals with Different Mineral Compositions , 2015 .

[12]  Hongwei Wu,et al.  Roles of Inherent Fine Included Mineral Particles in the Emission of PM10 during Pulverized Coal Combustion , 2012 .

[13]  A. Sarofim,et al.  Influence of char fragmentation on ash particle size distributions , 1989 .

[14]  Freek Kapteijn,et al.  Evolution of nitrogen functionalities in carbonaceous materials during pyrolysis , 1995 .

[15]  Hongwei Wu,et al.  Important role of volatile–char interactions in enhancing PM1 emission during the combustion of volatiles from biosolid , 2017 .

[16]  Q. Yao,et al.  Reduction of fine particulate matter by blending lignite with semi-char in a down-fired pulverized coal combustor , 2016 .

[17]  Wenying Li,et al.  Co-pyrolysis of lignite and Shendong coal direct liquefaction residue , 2015 .

[18]  A. Sarofim,et al.  Effect of Char structure on residual ash formation during pulverized coal combustion , 1992 .

[19]  Qin Yukun.  Influence of coal particle size on the combustion characteristics of yuanbaoshan lignite , 2008 .

[20]  Hongwei Wu,et al.  PM10 formation during the combustion of N2-char and CO2-char of Chinese coals , 2013 .

[21]  Wenying Li,et al.  Effect of adjusting coal properties on HulunBuir lignite pyrolysis , 2017 .

[22]  Jingkun Jiang,et al.  Semi-coke briquettes: towards reducing emissions of primary PM2.5, particulate carbon, and carbon monoxide from household coal combustion in China , 2016, Scientific Reports.

[23]  Diego Alvarez,et al.  Influence of pyrolysis temperature on char optical texture and reactivity , 2001 .

[24]  Lian Zhang,et al.  Effects of coal blending on the reduction of PM10 during high-temperature combustion 2. A coalescence-fragmentation model , 2009 .

[25]  Yong He,et al.  Morphological Characteristics of Chars Obtained from Low-Temperature Pyrolysis of Pulverized Lignite , 2018, Journal of Energy Engineering.

[26]  R. J. Quann,et al.  Vaporization of refractory oxides during pulverized coal combustion , 1982 .

[27]  Wayne Seames,et al.  An initial study of the fine fragmentation fly ash particle mode generated during pulverized coal combustion , 2003 .

[28]  P. Rosenberg,et al.  Oxygen groups in coals and alginite-rich kerogen revisited , 2008 .

[29]  H. Tan,et al.  Aggravated fine particulate matter emissions from heating-upgraded biomass and biochar combustion: The effect of pretreatment temperature , 2018 .

[30]  Jost O.L. Wendt,et al.  ON TRIMODAL PARTICLE SIZE DISTRIBUTIONS IN FLY ASH FROM PULVERIZED-COAL COMBUSTION , 2002 .