Experimental investigation of stepped solar still with continuous water circulation

Abstract This paper presents a modification of stepped solar still with continuous water circulation using a storage tank for sea and salt water. Total dissolved solids (TDS) of seawater and salt water before desalination is 57,100 and 2370 mg/l. A comparison study between modified stepped and conventional solar still was carried out to evaluate the developed desalination system performance under the same climate conditions. The effect of installing a storage tank and cotton black absorber for modified stepped solar still on the distillate productivity was investigated. The results indicate that, the productivity of the modified stepped still is higher than that for conventional still approximately by 43% and 48% for sea and salt water with black absorber respectively, while 53% and 47% of sea and salt water, respectively with cotton absorber. Also, the daily efficiency for modified stepped still is higher than that for conventional still approximately by 20%. The maximum efficiency of modified stepped still is occurring at a feed water flow rate of 1 LPM for sea water and 3 LPM for salt water. Total dissolved solids (TDS) of seawater and salt water after desalination is 41, and 27 mg/l.

[1]  K. Srithar,et al.  Integrated performance of stepped and single basin solar stills with mini solar pond , 2009 .

[2]  K. Srithar,et al.  SINGLE BASIN SOLAR STILL WITH FIN FOR ENHANCING PRODUCTIVITY , 2008 .

[3]  Abdulhaiy M. Radhwan,et al.  Transient performance of a stepped solar still withbuilt-in latent heat thermal energy storage , 2005 .

[4]  N. C. Barford.  Experimental Measurements: Precision, Error and Truth , 1967 .

[5]  Thirugnanasambantham Arunkumar,et al.  The augmentation of distillate yield by using concentrator coupled solar still with phase change material , 2013 .

[6]  A. E. Kabeel,et al.  Enhancing the stepped solar still performance using internal and external reflectors , 2014 .

[7]  Mazen M. Abu-Khader,et al.  Performance evaluation of a modified design of a single slope solar still , 2008 .

[8]  Zhang Xiaoyan,et al.  A group of improved heat and mass transfer correlations in solar stills , 2002 .

[9]  A. A. El-Sebaii,et al.  Effect of wind speed on active and passive solar stills , 2004 .

[10]  A. E. Kabeel,et al.  Cost analysis of different solar still configurations , 2010 .

[11]  Aly M. Elzahaby,et al.  Enhancement of solar still performance using a reciprocating spray feeding system—An experimental approach , 2011 .

[12]  Abdul Jabbar N. Khalifa.  On the effect of cover tilt angle of the simple solar still on its productivity in different seasons and latitudes , 2011 .

[13]  Ahmed A. Al-Ghamdi,et al.  Thermal performance of a single basin solar still with PCM as a storage medium , 2009 .

[14]  A. E. Kabeel,et al.  Theoretical and experimental parametric study of modified stepped solar still , 2012 .

[15]  B. A. Jubran,et al.  Effect of climatic, design and operational parameters on the yield of a simple solar still , 2002 .

[16]  Arvind Tiwari,et al.  Design, fabrication and performance of a hybrid photovoltaic/thermal (PV/T) active solar still , 2010 .

[17]  K. Srithar,et al.  Productivity enhancement of stepped solar still: Performance analysis , 2008 .

[18]  Thirugnanasambantham Arunkumar,et al.  Effect of water and air flow on concentric tubular solar water desalting system , 2013 .

[19]  A. A. El-Sebaii.  Effect of wind speed on some designs of solar stills , 2000 .

[20]  Aly M. Elzahaby,et al.  Augmentation of solar still performance using flash evaporation , 2010 .

[21]  Farshad Farshchi Tabrizi,et al.  Thermal analysis of a weir-type cascade solar still integrated with PCM storage , 2011 .

[22]  Guo Xie,et al.  Experimental and numerical study on a new multi-effect solar still with enhanced condensation surface , 2013 .

[23]  K. Sampathkumar,et al.  Utilization of solar water heater in a single basin solar still—An experimental study , 2012 .

[24]  Nagamany Nirmalakhandan,et al.  Feasibility study of a new two-stage low temperature desalination process , 2012 .

[25]  Abdul Jabbar N. Khalifa,et al.  An experimental study on modified simple solar stills , 1999 .

[26]  H. Ettouney,et al.  Fundamentals of Salt Water Desalination , 2002 .