Solar-driven gasification of carbonaceous feedstock-a review

Given the future importance of solid carbonaceous feedstocks such as coal, coke, biomass, bitumen, and carbon-containing wastes for the power and chemical industries, gasification technologies for their thermochemical conversion into fluid fuels are developing rapidly. Solar-driven gasification, in which concentrated solar radiation is supplied as the energy source of high-temperature process heat to the endothermic reactions, offers an attractive alternative to conventional autothermal processes. It has the potential to produce high-quality synthesis gas with higher output per unit of feedstock and lower specific CO2 emissions, as the calorific value of the feedstock is upgraded through the solar energy input by an amount equal to the enthalpy change of the reaction. The elimination of an air separation unit further facilitates economic competitiveness. Ultimately, solar-driven gasification is an efficient means of storing intermittent solar energy in a transportable and dispatchable chemical form. This review article develops some of the underlying science, examines the thermodynamics and kinetics of the pertinent reactions, and describes the latest advances in solar thermochemical reactor technology.

[1]  Mikael Höök,et al.  A review on coal‐to‐liquid fuels and its coal consumption , 2010 .

[2]  A. Steinfeld,et al.  Reaction kinetics of the combined pyrolysis and steam-gasification of carbonaceous waste materials , 2010 .

[3]  A. Weimer,et al.  Rapid High Temperature Solar Thermal Biomass Gasification in a Prototype Cavity Reactor , 2010 .

[4]  Aldo Steinfeld,et al.  Solar thermal cracking of methane in a particle-flow reactor for the co-production of hydrogen and carbon , 2009 .

[5]  Alan W. Weimer,et al.  Solar-driven biochar gasification in a particle-flow reactor , 2009 .

[6]  Hermann Hofbauer,et al.  H2 rich product gas by steam gasification of biomass with in situ CO2 absorption in a dual fluidized bed system of 8 MW fuel input , 2009 .

[7]  A. Steinfeld,et al.  Experimental investigation of a packed-bed solar reactor for the steam-gasification of carbonaceous feedstocks , 2009 .

[8]  Aldo Steinfeld,et al.  Heat and mass transfer analysis of a suspension of reacting particles subjected to concentrated solar radiation – Application to the steam-gasification of carbonaceous materials , 2009 .

[9]  Alan W. Weimer,et al.  A cavity-receiver containing a tubular absorber for high-temperature thermochemical processing using concentrated solar energy , 2008 .

[10]  Aldo Steinfeld,et al.  Hydrogen production by steam-gasification of carbonaceous materials using concentrated solar energy – V. Reactor modeling, optimization, and scale-up , 2008 .

[11]  A. Steinfeld,et al.  Solar-Driven Coal Gasification in a Thermally Irradiated Packed-Bed Reactor , 2008 .

[12]  Aldo Steinfeld,et al.  A two-phase reactor model for the steam-gasification of carbonaceous materials under concentrated thermal radiation , 2008 .

[13]  Aldo Steinfeld,et al.  A Novel 50kW 11,000 suns High-Flux Solar Simulator Based on an Array of Xenon Arc Lamps , 2007 .

[14]  Manuel Romero,et al.  Hydrogen Production by Steam-Gasification of Petroleum Coke using Concentrated Solar Power: III. Reactor experimentation with slurry feeding , 2007 .

[15]  F. Golfier,et al.  Influence of the pyrolysis heating rate on the steam gasification rate of large wood char particles , 2006 .

[16]  M. Romero,et al.  Hydrogen production by steam-gasification of petroleum coke using concentrated solar power—II Reactor design, testing, and modeling , 2006 .

[17]  Aldo Steinfeld,et al.  Kinetic Modeling for the Combined Pyrolysis and Steam Gasification of Petroleum Coke and Experimental Determination of the Rate Constants by Dynamic Thermogravimetry in the 500−1520 K Range , 2006 .

[18]  Christian Sattler,et al.  Hydrogen Production by Solar Reforming of Natural Gas: A Comparison Study of Two Possible Process Configurations , 2006 .

[19]  Anne-Gaëlle Collot,et al.  Matching gasification technologies to coal properties , 2006 .

[20]  W. Lipinski,et al.  Transient radiative heat transfer within a suspension of coal particles undergoing steam gasification , 2005 .

[21]  M. Romero,et al.  Hydrogen production by steam-gasification of petroleum coke using concentrated solar power—I. Thermodynamic and kinetic analyses , 2005 .

[22]  A. Steinfeld,et al.  Steam-gasification of coal in a fluidized-bed/packed-bed reactor exposed to concentrated thermal radiation-modeling and experimental validation , 2005 .

[23]  Wojciech Lipiński,et al.  TRANSIENT RADIATION HEAT TRANSFER WITHIN A NONGRAY NONISOTHERMAL ABSORBING-EMITTING-SCATTERING SUSPENSION OF REACTING PARTICLES UNDERGOING SHRINKAGE , 2005 .

[24]  A. Steinfeld,et al.  Solar Carbothermal Reduction of ZnO: Shrinking Packed-Bed Reactor Modeling and Experimental Validation , 2004 .

[25]  A. Steinfeld,et al.  Radiative exchange within a two-cavity configuration with a spectrally selective window , 2004 .

[26]  A. Steinfeld,et al.  Kinetic investigation on steam gasification of charcoal under direct high-flux irradiation , 2003 .

[27]  Aldo Steinfeld,et al.  The solar thermal gasification of coal — energy conversion efficiency and CO2 mitigation potential , 2003 .

[28]  T. Kodama,et al.  Fluidized Bed Coal Gasification with CO2 under Direct Irradiation with Concentrated Visible Light , 2002 .

[29]  A. Kribus,et al.  Performance of the Directly-Irradiated Annular Pressurized Receiver (DIAPR) Operating at 20 Bar and 1,200°C , 2001 .

[30]  Aldo Steinfeld,et al.  A new high-flux solar furnace for high-temperature thermochemical research , 1999 .

[31]  Anke Weidenkaff,et al.  A solar chemical reactor for co-production of zinc and synthesis gas , 1998 .

[32]  M Morris,et al.  Energy recovery from solid waste fuels using advanced gasification technology , 1998 .

[33]  Abraham Kribus,et al.  Solar tower reflector systems : A new approach for high-temperature solar plants , 1998 .

[34]  I. Wender.  Reactions of synthesis gas , 1996 .

[35]  W. Al-Masry,et al.  The influence of bed depth on secondary reactions during slow pyrolysis of coal , 1996 .

[36]  Martin Flechsenhar,et al.  Solar Gasification of Biomass Using Oil Shale and Coal as Candidate Materials. , 1995 .

[37]  Valerio Cozzani,et al.  Devolatilization and pyrolysis of refuse derived fuels: characterization and kinetic modelling by a thermogravimetric and calorimetric approach , 1995 .

[38]  Edward A. Fletcher,et al.  Reaction of steam with cellulose in a fluidized bed using concentrated sunlight , 1994 .

[39]  Jeffrey M. Gordon,et al.  Gasification of oil shales by solar energy , 1991 .

[40]  Paul T. Williams,et al.  The pyrolysis of scrap automotive tyres , 1990 .

[41]  H. Jüntgen.  Application of catalysts to coal gasification processes. Incentives and perspectives , 1983 .

[42]  A. Steinfeld,et al.  Tomography-Based Analysis of Radiative Transfer in Reacting Packed Beds Undergoing a Solid-Gas Thermochemical , 2009 .

[43]  Manuel Romero,et al.  Hydrogen production by steam-gasification of carbonaceous materials using concentrated solar energy—IV. Reactor experimentation with vacuum residue , 2008 .

[44]  C. Higman.  Chapter 11 – Gasification , 2008 .

[45]  A. Steinfeld,et al.  Numerical and experimental study of gas–particle radiative heat exchange in a fluidized-bed reactor for steam-gasification of coal , 2007 .

[46]  A. Steinfeld,et al.  Radiative Transfer Within a Cylindrical Cavity With Diffusely/Specularly Reflecting Inner Walls Containing an Array of Tubular Absorbers , 2006 .

[47]  Aldo Steinfeld,et al.  A 300kW Solar Chemical Pilot Plant for the Carbothermic Production of Zinc , 2006 .

[48]  Thomas Malkow,et al.  Novel and innovative pyrolysis and gasification technologies for energy efficient and environmentally sound MSW disposal. , 2004, Waste management.

[49]  Fausto Pochetti,et al.  Prediction of syngas quality for two-stage gasification of selected waste feedstocks. , 2004, Waste management.

[50]  Jörg Petrasch,et al.  Hydrogen Production Via the Solar Thermal Decarbonization of Fossil Fuels , 2003 .

[51]  Wolfgang Hoffelner,et al.  Recycling of hazardous solid waste material using high-temperature solar process heat. 2. Reactor design and experimentation. , 2003, Environmental science & technology.

[52]  Anton Meier,et al.  Indirectly Irradiated Solar Receiver-Reactors for High-Temperature Thermochemical Processes , 2002 .

[53]  Jacques Lédé,et al.  SOLAR THERMOCHEMICAL CONVERSION OF BIOMASS , 1999 .

[54]  Aldo Steinfeld,et al.  Optimum aperture size and operating temperature of a solar cavity-receiver , 1993 .

[55]  Peter R. Solomon,et al.  Coal pyrolysis: Experiments, kinetic rates and mechanisms , 1992 .

[56]  W. H. Beattie,et al.  High-temperature solar pyrolysis of coal , 1983 .

[57]  R. Berjoan,et al.  Solar gasification of carbonaceous materials , 1983 .

[58]  D. W. Gregg,et al.  Solar gasification of coal, activated carbon, coke and coal and biomass mixtures☆ , 1980 .

[59]  C. B. Thorsness,et al.  Solar coal gasification , 1980 .