Pressure drop and convective heat transfer of water and nanofluids in a double-pipe helical heat exchanger

Pressure drop and convective heat transfer characteristics of water and five alumina/water nanofluids of weight concentrations from 0.78% wt. to 7.04% wt. were experimentally investigated for both laminar flow and turbulent flow inside a double-pipe helically coiled heat exchanger. Effect of nanoparticles on the critical Reynolds number is negligible. A new correlation was developed for laminar flow in helically coiled tubes, which can predict the experimental heat transfer data very well. For turbulent flow, the Seban and McLaughlin correlation can accurately predict the thermal behavior of water and nanofluids when nanofluid properties are taken into account. For both laminar flow and turbulent flow, no anomalous heat transfer enhancement was found. The heat transfer enhancement of the nanofluids compared to water is from 0.37% to 3.43% according to the constant flow velocity basis. Figure of merit based on the constant Reynolds number can be misleading and should not be used for heat transfer enhancement comparison. Additional possible effects of nanoparticles, e.g., Brownian motion, thermophoresis and diffusiophoresis, on the convective heat transfer characteristics of the nanofluids are insignificant compared to the dominant thermophysical properties of the nanofluids. No multiphase phenomenon was found and the tested alumina nanofluids can be treated as homogeneous fluids. (C) 2013 Elsevier Ltd. All rights reserved. (Less)

[1]  N. Galanis,et al.  Heat transfer enhancement by using nanofluids in forced convection flows , 2005 .

[2]  H. Itō,et al.  Laminar Flow in Curved Pipes , 1969 .

[3]  D. Drew,et al.  Theory of Multicomponent Fluids , 1998 .

[4]  J. Buongiorno.  Convective Transport in Nanofluids , 2006 .

[5]  Edward W. Merrill,et al.  Effect of secondary fluid motion on laminar flow heat transfer in helically coiled tubes , 1971 .

[6]  Rahman Saidur,et al.  A REVIEW ON APPLICATIONS AND CHALLENGES OF NANOFLUIDS , 2011 .

[7]  J. Maxwell.  A Treatise on Electricity and Magnetism , 1873, Nature.

[8]  K. Leong,et al.  A combined model for the effective thermal conductivity of nanofluids , 2009 .

[9]  J. Buongiorno,et al.  Experimental Investigation of Turbulent Convective Heat Transfer and Pressure Loss of Alumina/Water and Zirconia/Water Nanoparticle Colloids (Nanofluids) in Horizontal Tubes , 2008 .

[10]  Robert A. Taylor,et al.  Small particles, big impacts: A review of the diverse applications of nanofluids , 2013 .

[11]  Angel Huminic,et al.  Application of nanofluids in heat exchangers: A review , 2012 .

[12]  Nakayama Wataru,et al.  Study on forced convective heat transfer in curved pipes: (1st report, laminar region) , 1965 .

[13]  Avtar Singh Ahuja,et al.  Augmentation of heat transport in laminar flow of polystyrene suspensions. I. Experiments and results , 1975 .

[14]  E. Timofeeva,et al.  Thermophysical property-related comparison criteria for nanofluid heat transfer enhancement in turbulent flow , 2010 .

[15]  R. A. Seban,et al.  Heat transfer in tube coils with laminar and turbulent flow , 1963 .

[16]  Y. Jaluria,et al.  An Introduction to Heat Transfer , 1950 .

[17]  A. Mujumdar,et al.  Numerical evaluation of laminar heat transfer enhancement in nanofluid flow in coiled square tubes , 2011, Nanoscale research letters.

[18]  Mohammad Ghazvini,et al.  Experimental investigation on the convective heat transfer of nanofluid flow inside vertical helically coiled tubes under uniform wall temperature condition , 2012 .

[19]  H. Mohammed,et al.  Thermal and hydraulic characteristics of nanofluid flow in a helically coiled tube heat exchanger , 2012 .

[20]  J. D. Seader,et al.  Heat and mass transfer phenomena for viscous flow in curved circular tubes , 1972 .

[21]  Timothy J. Rennie,et al.  Numerical studies of a double-pipe helical heat exchanger , 2006 .

[22]  Xing Zhang,et al.  Effective thermal conductivity and thermal diffusivity of nanofluids containing spherical and cylindrical nanoparticles , 2006 .

[23]  A. S. Dalkılıç,et al.  Forced Convective Heat Transfer of Nanofluids - A Review of the Recent Literature , 2012 .

[24]  E. Timofeeva,et al.  Nanofluids for heat transfer: an engineering approach , 2011, Nanoscale research letters.

[25]  Y. Hardalupas,et al.  Anomalous heat transfer modes of nanofluids: a review based on statistical analysis , 2011, Nanoscale research letters.

[26]  Y. Xuan,et al.  Investigation on Convective Heat Transfer and Flow Features of Nanofluids , 2003 .

[27]  Yulong Ding,et al.  Experimental investigation into convective heat transfer of nanofluids at the entrance region under laminar flow conditions , 2004 .

[28]  Hussein A. Mohammed,et al.  Influence of nanofluids and rotation on helically coiled tube heat exchanger performance , 2013 .