Rapid preparation of CeFe4Sb12 skutterudite by melt spinning: rich nanostructures and high thermoelectric performance

In this work, we adopt a non-equilibrium melt spinning technique combined with a subsequent spark plasma sintering technique to successfully synthesize a p-type nanostructured CeFe4Sb12 skutterudite compound with high homogeneity in less than 24 hours. Microstructures of the melt-spun ribbons and the sintered bulk material are systematically investigated. The evolution of multiple-phase melt-spun ribbons into a single-phase skutterudite compound during the heating process is also carefully examined. Greatly refined matrix grains (300–500 nm) and numerous FeSb2 nanodots with sizes below 50 nm are evenly distributed inside the grains, and together contribute to the experimentally observed low lattice thermal conductivity of the sintered bulk material. Both absolute and average ZT values of this melt-spun skutterudite are about 10% higher than in the material of the same composition prepared by traditional melting and long-term annealing. The markedly shortened preparation time coupled with the enhanced thermoelectric performance should make this synthesis process of interest for commercial applications.

[1]  Qingjie Zhang,et al.  Preparation and thermoelectric properties of high-performance Sb additional Yb0.2Co4Sb12+y bulk materials with nanostructure , 2008 .

[2]  Terry M. Tritt,et al.  Identifying the specific nanostructures responsible for the high thermoelectric performance of (Bi,Sb)2Te3 nanocomposites. , 2010, Nano letters.

[3]  S. Ur,et al.  Synthesis and Thermoelectric Properties of InzCo4−xFexSb12 Skutterudites , 2010 .

[4]  Lijun Wu,et al.  Nanostructures and Defects in Non-equilibrium Synthesized Filled Skutterudite CeFe4Sb12 , 2010, 1012.2506.

[5]  F. Disalvo,et al.  Thermoelectric cooling and power generation , 1999, Science.

[6]  Xiangyang Huang,et al.  High thermoelectric performance of Yb0.26Co4Sb12/yGaSb nanocomposites originating from scattering electrons of low energy , 2010 .

[7]  S. Denisenko,et al.  DIRECT MEASUREMENTS OF THE COOLING RATES IN THE SINGLE ROLLER RAPID SOLIDIFICATION TECHNIQUE , 1997 .

[8]  D. Vashaee,et al.  Detrimental influence of nanostructuring on the thermoelectric properties of magnesium silicide , 2012 .

[9]  Song Jin,et al.  Enhancement of the thermoelectric properties in nanoscale and nanostructured materials , 2011 .

[10]  Jihui Yang,et al.  Iron valence in skutterudites: Transport and magnetic properties of Co1−xFexSb3 , 2000 .

[11]  G. J. Snyder,et al.  Complex thermoelectric materials. , 2008, Nature materials.

[12]  C. Uher,et al.  Thermoelectric properties of p-type YbxLayFe2.7Co1.3Sb12 double-filled skutterudites , 2013 .

[13]  Ali Shakouri,et al.  Nanostructured Thermoelectrics: Big Efficiency Gains from Small Features , 2010, Advanced materials.

[14]  Junyou Yang,et al.  Effect of Fe substitution on the thermoelectric transport properties of CoSb3-based Skutterudite compound , 2006 .

[15]  Han Li,et al.  Enhanced thermoelectric performance and novel nanopores in AgSbTe2 prepared by melt spinning , 2011 .

[16]  C. Uher,et al.  Rapid synthesis of high thermoelectric performance higher manganese silicide with in-situ formed nano-phase of MnSi , 2011 .

[17]  Miaofang Chi,et al.  Multiple-filled skutterudites: high thermoelectric figure of merit through separately optimizing electrical and thermal transports. , 2011, Journal of the American Chemical Society.

[18]  Han Li,et al.  Preparation and thermoelectric transport properties of high-performance p-type Bi2Te3 with layered nanostructure , 2007 .

[19]  Qingjie Zhang,et al.  The role of Ga in Ba0.30GaxCo4Sb12+x filled skutterudites , 2012 .

[20]  Han Li,et al.  Preparation and thermoelectric properties of Ga-substituted p-type fully filled skutterudites CeFe4−xGaxSb12 , 2012 .

[21]  Xinbing Zhao,et al.  High figures of merit and natural nanostructures in Mg2Si0.4Sn0.6 based thermoelectric materials , 2008 .

[22]  A. Joffé,et al.  Heat Transfer in Semiconductors , 1956 .

[23]  B. Sales,et al.  FILLED SKUTTERUDITE ANTIMONIDES : ELECTRON CRYSTALS AND PHONON GLASSES , 1997 .

[24]  Xiaopeng Huang,et al.  Coherent Nanointerfaces in Thermoelectric Materials , 2010 .

[25]  Ctirad Uher,et al.  p-Type skutterudites RxMyFe3CoSb12 (R, M = Ba, Ce, Nd, and Yb): Effectiveness of double-filling for the lattice thermal conductivity reduction , 2011 .

[26]  G. Tan,et al.  Effects of Cobalt Substitution for Fe on the Thermoelectric Properties of p-Type CeFe4−xCoxSb12 Skutterudites , 2012, Journal of Electronic Materials.

[27]  M. Dresselhaus,et al.  Increased phonon scattering by nanograins and point defects in nanostructured silicon with a low concentration of germanium. , 2009, Physical review letters.

[28]  T. Hyeon,et al.  n-Type nanostructured thermoelectric materials prepared from chemically synthesized ultrathin Bi2Te3 nanoplates. , 2012, Nano letters.

[29]  Yixin Zhao,et al.  Improving Thermoelectric Properties of Chemically Synthesized Bi2Te3-Based Nanocrystals by Annealing , 2010 .

[30]  Han Li,et al.  Enhancement of the thermoelectric performance of β-Zn4Sb3 by in situ nanostructures and minute Cd-doping , 2011 .

[31]  Han Li,et al.  Rapid preparation method of bulk nanostructured Yb0.3Co4Sb12+y compounds and their improved thermoelectric performance , 2008 .

[32]  Zhifeng Ren,et al.  Enhancement of Thermoelectric Figure‐of‐Merit by a Bulk Nanostructuring Approach , 2010 .

[33]  Qiang Li,et al.  Thermoelectric Materials with Potential High Power Factors for Electricity Generation , 2009 .

[34]  Donald T. Morelli,et al.  Thermopower enhancement in lead telluride nanostructures , 2004 .

[35]  Hui Wang,et al.  Fast phase formation of double-filled p-type skutterudites by ball-milling and hot-pressing. , 2013, Physical chemistry chemical physics : PCCP.

[36]  Thierry Caillat,et al.  Preparation and thermoelectric properties of the skutterudite‐related phase Ru0.5Pd0.5Sb3 , 1996 .

[37]  J. Sakamoto,et al.  Enhanced thermoelectric properties of Ba-filled skutterudites by grain size reduction and Ag nanoparticle inclusion , 2012 .

[38]  M. Kanatzidis.  Nanostructured Thermoelectrics: The New Paradigm?† , 2010 .

[39]  L. Bell.  Cooling, Heating, Generating Power, and Recovering Waste Heat with Thermoelectric Systems , 2008, Science.

[40]  H. Geng,et al.  Solidification contraction-free synthesis for the Yb0.15Co4Sb12 bulk material , 2007 .

[41]  David J. Singh,et al.  Trends in Electrical Transport of p-type Skutterudites RFe4Sb12 (R-Na,K,Ca,Sr,Ba,La,Ce,Pr,Yb) from First Principles Calculations and Boltzmann Transport Theory , 2011 .

[42]  Junyou Yang,et al.  Synthesis of CoSb3 skutterudite by mechanical alloying , 2004 .