Fouling of Reverse Osmosis and Ultrafiltration Membranes: A Critical Review

Abstract Desalination by using reverse osmosis (RO) membranes has become very popular for producing freshwater from brackish water and seawater. Membrane lifetime and permeate flux, however, are primarily affected by the phenomena of concentration polarization and fouling at the membrane surface. The scope of the current paper was to critically review the literature on the fouling phenomena in RO and ultrafiltration (UF) membrane systems, the analytical techniques used to quantify fouling, preventive methods, and membrane cleaning strategies. The paper also makes specific recommendations on how scientists, engineers, and technical staff can assist in improving the performance of these systems through fundamental and applied research.

[1]  R. Singh,et al.  Effectively control reverse osmosis systems , 1999 .

[2]  AntonC.F. Ammerlaan,et al.  Yuma desalting plant. Membrane degradation during test operations , 1992 .

[3]  D. Drew,et al.  Lateral inertial migration of a small sphere in fast laminar flow through a membrane duct , 1991 .

[4]  C. R. Ethier,et al.  Concentration and concentration gradient measurements in an ultrafiltration concentration polarization layer Part II: Application to hyaluronan , 1997 .

[5]  C. Ross Ethier,et al.  Concentration and concentration gradient measurements in an ultrafiltration concentration polarization layer. Part I : A laser-based refractometric experimental technique , 1997 .

[6]  Tomasz Winnicki,et al.  Analysis of membrane fouling in the treatment of water solutions containing humic acids and mineral salts , 1999 .

[7]  Zacharias B. Maroulis,et al.  Salt and water permeability in reverse osmosis membranes , 1996 .

[8]  T. Yen,et al.  Selection of Bacteria with Favorable Transport Properties Through Porous Rock for the Application of Microbial-Enhanced Oil Recovery , 1983, Applied and environmental microbiology.

[9]  Anthony G. Fane,et al.  Adhesion of waste water bacteria to reverse osmosis membranes , 1998 .

[10]  R. Sanderson,et al.  Measurement and modelling of organic fouling deposition in ultrafiltration by ultrasonic transfer signals and reflections , 2002 .

[11]  H. Flemming,et al.  How do performance parameters respond to initial biofilm formation on separation membranes , 1993 .

[12]  B. Han,et al.  Arsenic removal from drinking water by flocculation and microfiltration , 2002 .

[13]  Shyam S. Sablani,et al.  Influence of spacer thickness on permeate flux in spiral-wound seawater reverse osmosis systems , 2002 .

[14]  G. Denisov,et al.  Theory of concentration polarization in cross-flow ultrafiltration: gel-layer model and osmotic-pressure model , 1994 .

[15]  M. Rabiller-Baudry,et al.  Characterisation of cleaned and fouled membrane by ATR-FTIR and EDX analysis coupled with SEM: application to UF of skimmed milk with a PES membrane , 2002 .

[16]  R. P. Schneider,et al.  Bacterial passage through microfiltration membranes in wastewater applications , 1999 .

[17]  Pierre Aimar,et al.  Model for colloidal fouling of membranes , 1995 .

[18]  A. B. de Haan,et al.  Optimization of non-woven spacers by CFD and validation by experiments , 2002 .

[19]  P. Glueckstern,et al.  Field evaluation of capillary UF technology as a pretreatment for large seawater RO systems , 2002 .

[20]  H. Ridgway,et al.  Adhesion of a Mycobacterium sp. to cellulose diacetate membranes used in reverse osmosis , 1984, Applied and environmental microbiology.

[21]  A. Jönsson,et al.  Cleaning of ultrafiltration membranes after treatment of oily waste water , 1994 .

[22]  Betty H. Olson,et al.  Biofilm Fouling of RO Membranes—Its Nature and Effect on Treatment of Water for Reuse , 1984 .

[23]  J. A. López-Ramírez,et al.  Comparison studies of feedwater pre-treatment in a reverse osmosis pilot plant , 2002 .

[24]  Lianfa Song,et al.  A new model for the calculation of the limiting flux in ultrafiltration , 1998 .

[25]  Harry F. Ridgway,et al.  Bacterial Adhesion and Fouling of Reverse Osmosis Membranes , 1985 .

[26]  R. Sheikholeslami,et al.  Effect of several inorganic species on silica fouling in RO membranes , 2002 .

[27]  B. Fabre,et al.  Sodium chloride stimulus-response experiments in spiral wound reverse osmosis membranes: a new method to detect fouling , 1999 .

[28]  J. Rouch,et al.  Impact of coagulation conditions on the in-line coagulation/UF process for drinking water production☆ , 2002 .

[29]  S. Sablani,et al.  Effect of feed temperature on permeate flux and mass transfer coefficient in spiral-wound reverse osmosis systems☆ , 2002 .

[30]  Hans-Curt Flemming,et al.  Biofouling on membranes - A microbiological approach , 1988 .

[31]  Vicki Chen,et al.  Ultrafiltration of protein mixtures: measurement of apparent critical flux, rejection performance, and identification of protein deposition , 2002 .

[32]  A. Cherkasov,et al.  Selective properties of ultrafiltration membranes from the standpoint of concentration polarization and adsorption phenomena , 1995 .

[33]  H. Ngo,et al.  Pre-flocculation of secondary treated wastewater in enhancing the performance of microfiltration , 2002 .

[34]  T. Mohammadi,et al.  Investigation of membrane fouling , 2003 .

[35]  W P E Robert Peters.  Water management, purification, and conservation in arid climates, volume 3: Water conservation edited by Mattheus F.A. Goosen and Walid H. Shayya Technomic Publishing Company Lancaster, PA (2000) 348 pages hardcover ISBN 1‐56676‐771‐7 U.S. list price: $89.95 , 2001 .

[36]  Robert H. Davis,et al.  Direct observation of membrane cleaning via rapid backpulsing , 2002 .

[37]  J. Hermia,et al.  Constant Pressure Blocking Filtration Laws - Application To Power-law Non-newtonian Fluids , 1982 .

[38]  Mushtaque Ahmed,et al.  Feasibility of salt production from inland RO desalination plant reject brine: A case study , 2003 .

[39]  Antoni W. Morawski,et al.  Membrane processes used for potable water quality improvement , 2002 .

[40]  S. Ripperger,et al.  Investigation on the effect of flocculants on the filtration behavior in microfiltration of fine particles , 2002 .

[41]  J. Pope,et al.  Quantitative measurements of the concentration polarisation layer thickness in membrane filtration of oil-water emulsions using NMR micro-imaging , 1996 .

[42]  A. Karabelas,et al.  The effect of colloid stability on membrane fouling , 1998 .

[43]  Anthony G. Fane,et al.  Water reclamation from municipal wastewater using combined microfiltration-reverse osmosis (ME-RO): Preliminary performance data and microbiological aspects of system operation , 1998 .

[44]  Jérôme Rose,et al.  Physico-chemical study of fouling mechanisms of ultrafiltration membrane on Biwa lake (Japan) , 1997 .

[45]  Shyam S. Sablani,et al.  Capacity-building strategies for desalination: activities, facilities and educational programs in Oman , 2001 .

[46]  Huabing Yin,et al.  Atomic force microscopy studies of membrane—solute interactions (fouling)☆ , 2002 .

[47]  P. Glueckstern,et al.  Advanced concept of large seawater desalination systems for Israel , 1998 .

[48]  Viriato Semiao,et al.  The effect of the ladder-type spacers configuration in NF spiral-wound modules on the concentration boundary layers disruption☆ , 2002 .

[49]  W. T. Hanbury,et al.  Numerical simulation and optimisation of spiral-wound modules , 1992 .

[50]  M. A. Islam,et al.  Contribution of adsorbed layer resistance to the flux-decline in an ultrafiltration process , 1998 .

[51]  D. Wiley,et al.  The relationship between membrane cleaning efficiency and water quality , 1998 .

[52]  A. Fane,et al.  Particle deposition during membrane filtration of colloids: transition between concentration polarization and cake formation , 1997 .

[53]  H. F. Shaalan,et al.  Development of fouling control strategies pertinent to nanofiltration membranes , 2003 .

[54]  P. V. Danckwerts.  Significance of Liquid-Film Coefficients in Gas Absorption , 1951 .

[55]  Shyam S. Sablani,et al.  Concentration polarization in ultrafiltration and reverse osmosis: a critical review , 2001 .

[56]  Georges Belfort,et al.  Flux enhancement during Dean vortex microfiltration. 8. Further diagnostics1 , 1997 .

[57]  I. Galambos,et al.  Humic substances removal from drinking water by membrane filtration , 2002 .

[58]  M. Nyström,et al.  Humic acid as a fouling agent in filtration , 1996 .

[59]  Kerry J. Howe,et al.  Use of ATR/FTIR spectrometry to study fouling of microfiltration membranes by natural waters , 2002 .

[60]  Seunghyun Kim,et al.  Effect of the removal of DOMs on the performance of a coagulation-UF membrane system for drinking water production , 2002 .

[61]  Jean-Philippe Croué,et al.  Fouling characteristics of wastewater effluent organic matter (EfOM) isolates on NF and UF membranes , 2002 .

[62]  M. Pérez,et al.  Comparison of MF/UF pretreatment with conventional filtration prior to RO membranes for surface seawater desalination , 2002 .

[63]  K. Scott,et al.  Intensified membrane filtration with corrugated membranes , 2000 .

[64]  Georges Belfort,et al.  Lateral migration of spherical particles in porous flow channels: application to membrane filtration , 1984 .

[65]  B H Olson,et al.  Microbial fouling of reverse-osmosis membranes used in advanced wastewater treatment technology: chemical, bacteriological, and ultrastructural analyses , 1983, Applied and environmental microbiology.

[66]  Taher bin Mohammed Ali Al Sajwani.  The desalination plants of Oman : past, present and future , 1998 .

[67]  Ángel Cambiella,et al.  Design and construction of a modular pilot plant for the treatment of oil-containing wastewaters , 2002 .

[68]  M. Dal-Cin,et al.  Membrane performance with a pulp mill effluent: Relative contributions of fouling mechanisms☆ , 1996 .

[69]  W. Den,et al.  Predictive membrane transport model for nanofiltration processes in water treatment , 2001 .

[70]  A. Zydney,et al.  Scale-up of microfiltration systems: fouling phenomena and Vmax analysis☆ , 2002 .

[71]  A. Grasmick,et al.  Ultrafiltration enhanced by coagulation in an immersed membrane system , 2002 .

[72]  Andrzej Koltuniewicz,et al.  Dynamic Properties of Ultrafiltration Systems in Light of the Surface Renewal Theory , 1994 .

[73]  Gunnar Eigil Jonsson,et al.  Flow dynamics and concentration polarisation in spacer-filled channels☆ , 2002 .

[74]  B. Girard,et al.  Influence of membrane structure on fouling layer morphology during apple juice clarification , 1998 .

[75]  David F. Fletcher,et al.  A CFD study of unsteady flow in narrow spacer-filled channels for spiral-wound membrane modules , 2002 .

[76]  Mark Wilf,et al.  Effective new pretreatment for seawater reverse osmosis systems , 1998 .

[77]  Mike Jenkins,et al.  Operational experience with a new fouling resistant reverse osmosis membrane , 1998 .

[78]  Michael K. Stenstrom,et al.  An unsteady-state model to predict concentration polarization in commercial spiral wound membranes , 1999 .

[79]  Andrea I. Schäfer,et al.  Particle interactions and removal of trace contaminants from water and wastewaters , 2002 .

[80]  W. T. Hanbury,et al.  Spiral wound modules performance an analytical solution: Part II , 1991 .