Enhanced thermal contact conductance using carbon nanotube arrays

Novel heat-conduction interfaces that employ carbon nanotube (CNT) arrays have been fabricated and studied experimentally. A reference calorimeter testing rig in a high vacuum environment with infrared temperature measurement has been established. Arrays of mat-type carbon nanotube layers have been grown directly on silicon substrates with microwave plasma-enhanced chemical vapor deposition. Iron and nickel are used as carbon nanotube catalysts. The thermal contact resistance of carbon nanotubes with a copper interface shows promising results with a minimum resistance of 23 mm/sup 2/K/W at a pressure of 0.445 MPa. Carbon nanotube arrays grown under different synthesis parameters exhibit different pressure-contact conductance characteristics. CNT-copper interface thermal contact conductance could be improved by optimization of carbon nanotube array parameters. Combinations of thermal gels and phase change materials with CNT array composites are proposed for further thermal contact conductance reduction.

[1]  Otto Zhou,et al.  Plasma-induced alignment of carbon nanotubes , 2000 .

[2]  P. McEuen,et al.  Thermal transport measurements of individual multiwalled nanotubes. , 2001, Physical Review Letters.

[3]  Thermal conduction in classical low-dimensional lattices , 2001, cond-mat/0112193.

[4]  W. Goddard,et al.  Thermal conductivity of carbon nanotubes , 2000 .

[5]  M. Radosavljevic,et al.  Carbon nanotube composites for thermal management , 2002, cond-mat/0205418.

[6]  Takamichi Hirata,et al.  Single-walled carbon nanotubes produced by plasma-enhanced chemical vapor deposition , 2003 .

[7]  S. Iijima.  Helical microtubules of graphitic carbon , 1991, Nature.

[8]  L. Fletcher,et al.  Comparison of Effective Thermal Conductivity and Contact Conductance of Fibrous Composites , 1999 .

[9]  Toshiaki Kato,et al.  Magnetron-type radio-frequency plasma control yielding vertically well-aligned carbon nanotube growth , 2003 .

[10]  S. Maruyama.  A MOLECULAR DYNAMICS SIMULATION OF HEAT CONDUCTION OF A FINITE LENGTH SINGLE-WALLED CARBON NANOTUBE , 2003 .

[11]  X. W. Liu,et al.  Well-aligned carbon nitride nanotubes synthesized in anodic alumina by electron cyclotron resonance chemical vapor deposition , 1999 .

[12]  Seong Chu Lim,et al.  Effect of surface morphology of Ni thin film on the growth of aligned carbon nanotubes by microwave plasma-enhanced chemical vapor deposition , 2000 .

[13]  E. Grulke,et al.  Anomalous thermal conductivity enhancement in nanotube suspensions , 2001 .

[14]  M. Mäkinen.  3 – Introduction to phase change materials , 2006 .

[15]  M. M. Yovanovich,et al.  Thermal resistance of cylinder-flat contacts: Theoretical analysis and experimental verification of a line-contact model , 1985 .

[16]  O. Zhou,et al.  Deposition of aligned bamboo-like carbon nanotubes via microwave plasma enhanced chemical vapor deposition , 2000 .

[17]  D.D.L. Chung,et al.  Sodium silicate based thermal interface material for high thermal contact conductance , 2000 .

[18]  Y. Shiratori,et al.  One-step formation of aligned carbon nanotube field emitters at 400 °C , 2003 .

[19]  Bower,et al.  Electronic structures of single-walled carbon nanotubes determined by NMR , 2000, Science.

[20]  R. Smalley.  Crystalline Ropes of Metallic Carbon Nanotubes , 1999 .

[21]  Sungho Jin,et al.  Nucleation and growth of carbon nanotubes by microwave plasma chemical vapor deposition , 2000 .

[22]  Kwon,et al.  Unusually high thermal conductivity of carbon nanotubes , 2000, Physical review letters.

[23]  S. Tsai,et al.  Bias-enhanced nucleation and growth of the aligned carbon nanotubes with open ends under microwave plasma synthesis , 1999 .

[24]  Scott T. Huxtable,et al.  Interfacial heat flow in carbon nanotube suspensions , 2003, Nature materials.