Piezoelectric polymeric bicomponent fibers produced by melt spinning

Melt spinning of a novel piezoelectric bicomponent fiber, with poly(vinylidene fluoride) as the electroactive sheath component, has been demonstrated. An electrically conductive compound of carbon black (CB) and high density polyethylene was used as core material, working as an inner electrode. A force sensor consisting of a number of fibers embedded in a soft CB/polyolefin elastomer matrix was manufactured for characterization. The fibers showed a clear piezoelectric effect, with a voltage output (peak-to-peak) of up to 40 mV under lateral compression. This continuous all-polymer piezoelectric fiber introduces new possibilities toward minimal single fiber sensors as well as large area sensors produced in standard industrial weaving machines.

[1]  T. Gries,et al.  Characterisation of piezoelectric PVDF monofilaments , 2011 .

[2]  M. Litt,et al.  The Crystal Structure of the ? Phase of Poly(vinylidene fluoride) , 1980 .

[3]  H. Kawai,et al.  The Piezoelectricity of Poly (vinylidene Fluoride) , 1969 .

[4]  A. Yousefi,et al.  Effect of flow history on poly(vinylidine fluoride) crystalline phase transformation , 2007 .

[5]  Xianfeng Li,et al.  Effect of annealing on the structure and properties of polyvinylidene fluoride hollow fiber by melt-spinning , 2007 .

[6]  M. Kotaki,et al.  Morphology, polymorphism behavior and molecular orientation of electrospun poly(vinylidene fluoride) fibers , 2007 .

[7]  M. Cakmak,et al.  Structure development in melt spinning poly(vinylidene fluoride) fibers and tapes , 1985 .

[8]  Yozo Chatani,et al.  Crystal Structures of Three Crystalline Forms of Poly(vinylidene fluoride) , 1972 .

[9]  B. Hsiao,et al.  Structure development during the melt spinning of polyethylene and poly(vinylidene fluoride) fibers by in situ synchrotron small- and wide-angle X-ray scattering techniques , 1999 .

[10]  K. Matsushige,et al.  The II-I crystal transformation of poly(vinylidene fluoride) under tensile and compressional stresses , 1980 .

[11]  Liwei Lin,et al.  Direct-write piezoelectric polymeric nanogenerator with high energy conversion efficiency. , 2010, Nano letters.

[12]  J D Joannopoulos,et al.  Multimaterial piezoelectric fibres. , 2010, Nature materials.

[13]  Anja Lund,et al.  Melt spinning of poly(vinylidene fluoride) fibers and the influence of spinning parameters on beta-phase crystallinity , 2010 .

[14]  Kevin A. Snook,et al.  縦方向電界場中で曲げたPIN-PMN-PT単結晶の強度 , 2011 .

[15]  Ali Akbar Yousefi,et al.  Effect of tensile strain rate and elongation on crystalline structure and piezoelectric properties of PVDF thin films , 2007 .

[16]  James L White,et al.  Elongational flow and melt‐spinning instability of concentrated suspensions of small particles in polymer melts , 1981 .

[17]  J. Lando,et al.  The crystal structure of phase IV of poly(vinylidene fluoride) , 1980 .

[18]  J. Lando,et al.  The polymorphism of poly(vinylidene fluoride). I. The effect of head-to-head structure , 1968 .

[19]  S. Lanceros‐Méndez,et al.  Influence of the β-phase content and degree of crystallinity on the piezo- and ferroelectric properties of poly(vinylidene fluoride) , 2010 .

[20]  Andrzej Wasiak,et al.  Phase transitions during stretching of poly(vinylidene fluoride) , 1999 .

[21]  Eiichi Fukada,et al.  Piezoelectric Effect in Polarized Poly (vinylidene Fluoride) , 1969 .

[22]  I. Alig,et al.  Destruction and formation of a carbon nanotube network in polymer melts: Rheology and conductivity spectroscopy , 2008 .

[23]  D. K. Gupta,et al.  Changes in x‐ray diffraction patterns of polyvinylidene fluoride due to corona charging , 1977 .

[24]  D. Clarke,et al.  Effect of electrospinning on the ferroelectric phase content of polyvinylidene difluoride fibers. , 2008, Langmuir : the ACS journal of surfaces and colloids.

[25]  Anja Lund,et al.  Melt spinning of beta-phase poly(vinylidene fluoride) yarns with and without a conductive core , 2011 .

[26]  B. Hagström,et al.  Conducting bicomponent fibers obtained by melt spinning of PA6 and polyolefins containing high amounts of carbonaceous fillers , 2012 .

[27]  Xuehong Lu,et al.  Electrospinning of polyvinylidene difluoride with carbon nanotubes: synergistic effects of extensional force and interfacial interaction on crystalline structures. , 2008, Langmuir : the ACS journal of surfaces and colloids.

[28]  R. E. Collins,et al.  Piezoelectricity and pyroelectricity in polyvinylidene fluoride—A model , 1978 .

[29]  Stephen H. Foulger,et al.  Electrical properties of composites in the vicinity of the percolation threshold , 1999 .

[30]  J. Dumbleton,et al.  Structure and fiber formation in poly‐(vinylidene fluoride) , 1968 .

[31]  C. Lacabanne,et al.  Cooperative movements associated with the Curie transition in P(VDF-TrFE) copolymers , 1995 .

[32]  S. Toll,et al.  Melt spinning of conducting polymeric composites containing carbonaceous fillers , 2011 .