Performance analysis of a biogas-fueled micro gas turbine using a validated thermodynamic model

Abstract This study focuses on an investigation of the fuel flexibility and performance analysis of micro gas turbines (MGTs) in biogas application. For this purpose, a steady state thermodynamic model of an MGT was developed and validated by experimental data obtained from a 100 kW MGT test rig. Quite good agreement was obtained between the measurements and the simulation results. A wide range of biogas compositions with varying methane content was simulated for this study. Necessary minor modifications to fuel valves and compressor were assumed to allow engine operation with the simulated biogas composition. The effects of biogas on the engine performance were fully analyzed at various operational conditions by changing the power demand and also the ambient temperature. Compared to the natural gas fueled case, the mass flow and pressure ratio in the MGT decreased, which resulted in a slight reduction of the surge margin. This effect became more severe, however, at low power loads and/or low ambient temperatures. For all operational conditions, the electrical efficiency decreased with decreasing methane content of the biogas. The results also indicated the negative effect of the biogas on the heat recovery in the recuperator, which lowered as the methane content of the fuel decreased.

[1]  Eliseu Monteiro,et al.  Planning of micro-combined heat and power systems in the Portuguese scenario , 2009 .

[2]  Nikolett Sipöcz,et al.  Novel High-Performing Single-Pressure Combined Cycle With CO2 Capture , 2011 .

[3]  Dieter Bohn,et al.  Effects of Biogas Combustion on the Operation Characteristics and Pollutant Emissions of a Micro Gas Turbine , 2003 .

[4]  Mohsen Assadi,et al.  Experimental Investigation of the Performance of a Micro Gas Turbine Fueled With Mixtures of Natural Gas and Biogas , 2013 .

[5]  Teruyuki Nakajima,et al.  Combustion Characteristics of Methane-CO2 Mixture and a Microturbine Cogeneration System Utilized Sewage Digester Gas , 2007 .

[6]  Mohsen Assadi,et al.  An EU initiative for future generation of IGCC power plants using hydrogen-rich syngas: Simulation results for the baseline configuration , 2012 .

[7]  Jeffrey P. Armstrong,et al.  The Correlation of IR Microturbine Combustion Performance While Burning Diluted Gaseous Fuel Supplied by a Fuel Mixing Facility , 2005 .

[8]  Henry Cohen,et al.  Gas turbine theory , 1973 .

[9]  Chiun-Hsun Chen,et al.  System Identification and Performance Improvement to a Micro Gas Turbine Applying Biogas , 2009 .

[10]  Alexandre Szklo,et al.  Strategic cogeneration — fresh horizons for the development of cogeneration in Brazil , 2001 .

[11]  Tong Seop Kim,et al.  The effect of firing biogas on the performance and operating characteristics of simple and recuperative cycle gas turbine combined heat and power systems , 2012 .

[12]  M. C. Cameretti,et al.  Study of an exhaust gas recirculation equipped micro gas turbine supplied with bio-fuels , 2013 .

[13]  O. Kruse,et al.  Microalgae as substrates for fermentative biogas production in a combined biorefinery concept. , 2010, Journal of biotechnology.

[14]  A. Rehman,et al.  Bio-fuels for the gas turbine: A review , 2010 .

[15]  P. A. Pilavachi.  Mini- and micro-gas turbines for combined heat and power , 2002 .

[16]  Björn Nyberg.  Fuel Flexible Prediction Model for T100 Gas Turbine , 2010 .

[17]  Nikolett Sipöcz,et al.  Combined Cycles With CO2 Capture: Two Alternatives for System Integration , 2010 .

[18]  Firdaus Basrawi,et al.  Effect of ambient temperature on the performance of micro gas turbine with cogeneration system in cold region , 2011 .

[19]  Takanobu Yamada,et al.  Analysis of the performances of biogas-fuelled micro gas turbine cogeneration systems (MGT-CGSs) in middle- and small-scale sewage treatment plants: Comparison of performances and optimization of MGTs with various electrical power outputs , 2012 .

[20]  Alberto Coronas,et al.  Integration of absorption cooling systems into micro gas turbine trigeneration systems using biogas: Case study of a sewage treatment plant , 2009 .

[21]  Gosse Stephane,et al.  UO 2 と炭素間の高温相互作用:超高温原子炉のTRISO粒子への応用 , 2010 .

[22]  Alberto Coronas,et al.  Performance analysis of combined microgas turbines and gas fired water/LiBr absorption chillers with post-combustion , 2005 .

[23]  Marcelo G. Molina,et al.  Biogas production from grape pomace: Thermodynamic model of the process and dynamic model of the power generation system , 2012 .