Fabrication and characterization of a nanowire/polymer-based nanocomposite for a prototype thermoelectric device

This paper discusses the design, fabrication and testing of a novel thermoelectric device comprised of arrays of silicon nanowires embedded in a polymer matrix. By exploiting the low-thermal conductivity of the composite and presumably high-power factor of the nanowires, a thermoelectric figure of merit, higher than the corresponding bulk value, should result. Arrays were first synthesized using a vapor-liquid-solid (VLS) process leading to one-dimensional (1-D) growth of single-crystalline nanowires. To provide structural support while maintaining thermal isolation between nanowires, parylene, a low thermal conductivity and extremely conformal polymer, was embedded within the arrays. Mechanical polishing and oxygen plasma etching techniques were used to expose the nanowire tips and a metal contact was deposited on the top surface. Scanning electron micrographs (SEMs) illustrate the results of the fabrication processes. Using a modification of the 3/spl omega/ technique, the effective thermal conductivity of the nanowire matrix was measured and 1 V characteristics were also demonstrated. An assessment of the suitability of this nanocomposite for high thermoelectric performance devices is given.

[1]  Yiying Wu,et al.  Thermal conductivity of individual silicon nanowires , 2003 .

[2]  Jae Hee Song,et al.  Inorganic semiconductor nanowires: rational growth, assembly, and novel properties. , 2002, Chemistry.

[3]  Ali Shakouri,et al.  Thermal conductivity of Si/SiGe and SiGe/SiGe superlattices , 2002 .

[4]  J. Bowers,et al.  Thermal Conductivity of Si/SiGe Superlattices , 2001, Heat Transfer: Volume 7 — Heat Transfer in Electronic Equipment, Student Research, and Visualization Techniques.

[5]  R. Venkatasubramanian,et al.  Thin-film thermoelectric devices with high room-temperature figures of merit , 2001, Nature.

[6]  Chun-Sing Lee,et al.  Scanning tunneling microscopic study of boron-doped silicon nanowires , 2001 .

[7]  M S Sander,et al.  Electrodeposition of ordered Bi2Te3 nanowire arrays. , 2001, Journal of the American Chemical Society.

[8]  Yu-Ming Lin,et al.  Anomalously high thermoelectric figure of merit in Bi1−xSbx nanowires by carrier pocket alignment , 2001 .

[9]  T. Borca-Tasciuc,et al.  Data reduction in 3ω method for thin-film thermal conductivity determination , 2001 .

[10]  Peidong Yang,et al.  Direct Observation of Vapor-Liquid-Solid Nanowire Growth , 2001 .

[11]  M. Dresselhaus,et al.  Phonons in carbon nanotubes , 2000 .

[12]  Yu-Ming Lin,et al.  Theoretical investigation of thermoelectric transport properties of cylindrical Bi nanowires , 2000 .

[13]  Charles M. Lieber,et al.  Doping and Electrical Transport in Silicon Nanowires , 2000 .

[14]  K. Johnston,et al.  Control of thickness and orientation of solution-grown silicon nanowires , 2000, Science.

[15]  Yu-Ming Lin,et al.  Bismuth nanowire arrays: Synthesis and galvanomagnetic properties , 2000 .

[16]  Kenneth A. Smith,et al.  Gas-phase catalytic growth of single-walled carbon nanotubes from carbon monoxide , 1999 .

[17]  Kang L. Wang,et al.  Modification of the lattice thermal conductivity in silicon quantum wires due to spatial confinement of acoustic phonons , 1999 .

[18]  Weili Liu,et al.  Thermal conductivity of Si/Ge superlattices , 1999, Eighteenth International Conference on Thermoelectrics. Proceedings, ICT'99 (Cat. No.99TH8407).

[19]  M. Dresselhaus,et al.  Theoretical modeling of thermoelectricity in Bi nanowires , 1999, Eighteenth International Conference on Thermoelectrics. Proceedings, ICT'99 (Cat. No.99TH8407).

[20]  D. Bergman,et al.  Enhancement of thermoelectric power factor in composite thermoelectrics , 1999, Eighteenth International Conference on Thermoelectrics. Proceedings, ICT'99 (Cat. No.99TH8407).

[21]  Jiangtao Hu,et al.  Chemistry and Physics in One Dimension: Synthesis and Properties of Nanowires and Nanotubes , 1999 .

[22]  Jackie Y. Ying,et al.  Bismuth quantum-wire arrays fabricated by a vacuum melting and pressure injection process , 1998 .

[23]  Charles M. Lieber,et al.  A laser ablation method for the synthesis of crystalline semiconductor nanowires , 1998, Science.

[24]  Michael L. Roukes,et al.  Direct thermal conductance measurements on suspended monocrystalline nanostructures , 1997 .

[25]  Seungmin Lee,et al.  Heat transport in thin dielectric films , 1997 .

[26]  Timothy J. Trentler,et al.  Solution−Liquid−Solid Growth of Indium Phosphide Fibers from Organometallic Precursors: Elucidation of Molecular and Nonmolecular Components of the Pathway , 1997 .

[27]  Brian C. Sales,et al.  Thermoelectric Materials: New Approaches to an Old Problem , 1997 .

[28]  C. B. Carter,et al.  Growth and Sintering of Fullerene Nanotubes , 1994, Science.

[29]  D. Cahill,et al.  Thermal conductivity of a-Si:H thin films. , 1994, Physical review. B, Condensed matter.

[30]  Mildred S. Dresselhaus,et al.  Use of quantum‐well superlattices to obtain a high figure of merit from nonconventional thermoelectric materials , 1993 .

[31]  M. S. de Vries,et al.  Cobalt-catalysed growth of carbon nanotubes with single-atomic-layer walls , 1993, Nature.

[32]  M. Dresselhaus,et al.  Thermoelectric figure of merit of a one-dimensional conductor. , 1993, Physical review. B, Condensed matter.

[33]  D. Cahill.  Thermal conductivity measurement from 30 to 750 K: the 3ω method , 1990 .

[34]  S. Kubakaddi,et al.  Thermopower enhancement in semiconducting quantum well wires for acoustic phonon scattering , 1985 .

[35]  A. W. van Herwaarden,et al.  The seebeck effect in silicon ICs , 1984 .

[36]  R. S. Wagner,et al.  VAPOR‐LIQUID‐SOLID MECHANISM OF SINGLE CRYSTAL GROWTH , 1964 .

[37]  Yiying Wu,et al.  Nanowire Arrays for Thermoelectric Devices , 2003 .

[38]  A. K. Hitun,et al.  Modification of the lattice thermal conductivity in silicon quantum wires due to spatial confinement of acoustic phonons , 1999 .

[39]  M. Kelly,et al.  Thermal transport in free-standing semiconductor fine wires , 1991 .