An Investigation of PEFC Sub‐Zero Startup: Influence of Initial Conditions and Residual Water

Isothermal cold starts of polymer electrolyte fuel cells were performed at sub‐zero temperatures and analyzed by means of neutron radiography in order to unravel the relation between the preconditioning of the cell and the cold start capability. It was found out that the initial humidification state of the membrane (determined by its resistance) has a clear correlation with the duration of the initial phase of the cold start, but not with the total duration of startup until cell failure. In the experimental setup the impact of realistic and commercial sealing solutions was taken into account by adding an edge channel. The impact of water accumulations in this region on the cold start capability was assessed. Liquid water located in the outer perimeter of a cell could be directly verified to freeze during cell cool down by a novel dual spectrum neutron radiography method. The amount of water accumulated in the outer cell perimeter showed some correlation with the total duration of the cold start. It was found out that residual water located in the edge channel can initiate freezing of a substantial part of the active area nearby.

[1]  K. Friedrich,et al.  An Investigation of PEFC Sub-Zero Startup: Evidence of Local Freezing Effects , 2016 .

[2]  J. Biesdorf.  Neutron radiography of Polymer Electrolyte Fuel Cells: From conventional towards energy selective neutron imaging , 2016 .

[3]  K. Friedrich,et al.  Water Distribution Analysis in the Outer Perimeter Region of Technical PEFC Based on Neutron Radiography , 2015 .

[4]  P. Boillat,et al.  When Size Matters: Active Area Dependence of PEFC Cold Start Capability , 2015 .

[5]  Kohei Ito,et al.  Theoretical analysis of supercooled states of water generated below the freezing point in a PEFC , 2014 .

[6]  E. Lehmann,et al.  Dual spectrum neutron radiography: identification of phase transitions between frozen and liquid water. , 2014, Physical review letters.

[7]  Gérard Gebel,et al.  Water management in proton exchange membrane fuel cell at sub-zero temperatures: An in operando SANS-EIS coupled study , 2013 .

[8]  Thomas J. Dursch,et al.  Pseudo-isothermal ice-crystallization kinetics in the gas-diffusion layer of a fuel cell from differential scanning calorimetry , 2013 .

[9]  J. Eller.  X-ray tomographic microscopy of polymer electrolyte fuel cells , 2013 .

[10]  N. Kardjilov,et al.  Investigation of phase transfer properties of light and heavy water by means of energy selective neutron imaging , 2012 .

[11]  C. Radke,et al.  Isothermal ice crystallization kinetics in the gas-diffusion layer of a proton-exchange-membrane fuel cell. , 2012, Langmuir : the ACS journal of surfaces and colloids.

[12]  C. Grünzweig,et al.  The ICON beamline – A facility for cold neutron imaging at SINQ , 2011 .

[13]  G. Gebel,et al.  Water crystallization inside fuel cell membranes probed by X-ray scattering , 2011 .

[14]  A. Wokaun,et al.  Cold-Start of a PEFC Visualized with High Resolution Dynamic In-Plane Neutron Imaging , 2011 .

[15]  Sébastien Rosini,et al.  Experimental and theoretical investigations on a proton exchange membrane fuel cell starting up at subzero temperatures , 2009 .

[16]  Manish Khandelwal,et al.  Characteristic Behavior of Polymer Electrolyte Fuel Cell Resistance during Cold Start , 2008 .

[17]  Hubert A. Gasteiger,et al.  PEM Fuel Cell Operation at − 20 ° C . II. Ice Formation Dynamics, Current Distribution, and Voltage Losses within Electrodes , 2008 .

[18]  J. Jorné,et al.  PEM Fuel Cell Operation at − 20 ° C . I. Electrode and Membrane Water (Charge) Storage , 2008 .

[19]  Masahiro Shiozawa,et al.  Super-cooled water behavior inside polymer electrolyte fuel cell cross-section below freezing temperature , 2008 .

[20]  Chao-Yang Wang,et al.  Isothermal Cold Start of Polymer Electrolyte Fuel Cells , 2007 .

[21]  Kazuhiko Yoshida,et al.  Behavior of water below the freezing point in PEFCs , 2007 .

[22]  J. Jorné,et al.  Investigation of Low-Temperature Proton Transport in Nafion Using Direct Current Conductivity and Differential Scanning Calorimetry , 2006 .

[23]  J. R. Granada,et al.  Total cross sections of benzene at 90 K and light water ice at 115 K , 2006 .

[24]  Steven Holdcroft,et al.  Effect of water on the low temperature conductivity of polymer electrolytes. , 2006, The journal of physical chemistry. B.

[25]  N. Djilali,et al.  Ex situ visualization of liquid water transport in PEM fuel cell gas diffusion layers , 2006 .

[26]  Mario Zedda,et al.  Statistic analysis of operational influences on the cold start behaviour of PEM fuel cells , 2005 .

[27]  H. Pfeifer.  Physikalische Chemie , 1996 .