Analysis and Suppression of Leakage Current in Cascaded-Multilevel-Inverter-Based PV Systems

The transformerless cascaded multilevel inverter (CMI) is considered to be a promising topology alternative for low-cost and high-efficiency photovoltaic (PV) systems. However, the leakage current issue resulted from the parasitic capacitors between the PV panels and the earth remains a challenging in designing a reliable CMI-based PV system. In this paper, the leakage current paths in PV CMI are analyzed and the unique features are discussed. Two filter-based suppression solutions are then presented to tackle the leakage current issue in different PV CMI applications. Simplified leakage current analytical models are derived to study the suppression mechanisms and design the suppression filters. Study cases are demonstrated for each of the solutions with filter design example, simulation and experimental verifications.

[1]  Lipei Huang,et al.  High efficiency hybrid cascade inverter for photovoltaic generation , 2009, TENCON 2009 - 2009 IEEE Region 10 Conference.

[2]  Yi Zhao,et al.  1 MHz cascaded Z-source inverters for scalable grid-interactive photovoltaic (PV) applications using GaN device , 2011, 2011 IEEE Energy Conversion Congress and Exposition.

[3]  J. Rodriguez,et al.  Cascaded H-bridge multilevel converter multistring topology for large scale photovoltaic systems , 2011, 2011 IEEE International Symposium on Industrial Electronics.

[4]  Pierluigi Siano,et al.  A Multilevel Inverter for Photovoltaic Systems With Fuzzy Logic Control , 2010, IEEE Transactions on Industrial Electronics.

[5]  F. Wang,et al.  Analysis of CM Volt-Second Influence on CM Inductor Saturation and Design for Input EMI Filters in Three-Phase DC-Fed Motor Drive Systems , 2010, IEEE Transactions on Power Electronics.

[6]  Rixin Lai,et al.  Analysis and suppression of a common mode resonance in the cascaded H-bridge multilevel inverter , 2010, 2010 IEEE Energy Conversion Congress and Exposition.

[7]  Dushan Boroyevich,et al.  Grid-Interface Bidirectional Converter for Residential DC Distribution Systems—Part 2: AC and DC Interface Design With Passive Components Minimization , 2013, IEEE Transactions on Power Electronics.

[8]  D. Boroyevich,et al.  Leakage Current Reduction in a Single-Phase Bidirectional AC–DC Full-Bridge Inverter , 2012, IEEE Transactions on Power Electronics.

[9]  P. Enjeti,et al.  Independent control of series connected utility scale multilevel photovoltaic inverters , 2012, 2012 IEEE Energy Conversion Congress and Exposition (ECCE).

[10]  U. Borup,et al.  Transformerless Photovoltaic Inverters Connected to the Grid , 2007, APEC 07 - Twenty-Second Annual IEEE Applied Power Electronics Conference and Exposition.

[11]  Pablo Correa,et al.  Control of a Single-Phase Cascaded H-Bridge Multilevel Inverter for Grid-Connected Photovoltaic Systems , 2009, IEEE Transactions on Industrial Electronics.

[12]  Leon M. Tolbert,et al.  11-Level cascaded H-bridge grid-tied inverter interface with solar panels , 2010, 2010 Twenty-Fifth Annual IEEE Applied Power Electronics Conference and Exposition (APEC).

[13]  M. Liserre,et al.  Transformer-less photovoltaic (PV) inverters: A critical comparison , 2012, 2012 IEEE Energy Conversion Congress and Exposition (ECCE).

[14]  Hui Li,et al.  A High-Performance Photovoltaic Module-Integrated Converter (MIC) Based on Cascaded Quasi-Z-Source Inverters (qZSI) Using eGaN FETs , 2013, IEEE Transactions on Power Electronics.

[15]  Vassilios G. Agelidis,et al.  Multilevel converters for single-phase grid connected photovoltaic systems-an overview , 1998, IEEE International Symposium on Industrial Electronics. Proceedings. ISIE'98 (Cat. No.98TH8357).

[16]  E. Gubia,et al.  Cascaded H-bridge multilevel converter for grid connected photovoltaic generators with independent maximum power point tracking of each solar array , 2003, IEEE 34th Annual Conference on Power Electronics Specialist, 2003. PESC '03..

[17]  Thomas A. Lipo,et al.  CarrierBased PWM of Multilevel Inverters , 2003 .

[18]  Johan Strydom.  Driving eGaN Transistors for Maximum Performance , 2010 .

[19]  Hung-Chi Chen,et al.  Common mode and differential mode circulating-current control in paralleled single-phase boost rectifiers , 2013, 2013 Twenty-Eighth Annual IEEE Applied Power Electronics Conference and Exposition (APEC).

[20]  Dushan Boroyevich,et al.  Control of circulating current in two parallel three-phase boost rectifiers , 2002 .

[21]  D. Biel,et al.  Energy-Sampled Data Modeling of a Cascade H-Bridge Multilevel Converter for Grid-connected PV Systems , 2006, 2006 IEEE International Power Electronics Congress.

[22]  Yunjie Gu,et al.  Improved Transformerless Inverter With Common-Mode Leakage Current Elimination for a Photovoltaic Grid-Connected Power System , 2012, IEEE Transactions on Power Electronics.

[23]  Remus Teodorescu,et al.  A New High-Efficiency Single-Phase Transformerless PV Inverter Topology , 2011, IEEE Transactions on Industrial Electronics.

[24]  Shaojun Xie,et al.  Leakage Current Analytical Model and Application in Single-Phase Transformerless Photovoltaic Grid-Connected Inverter , 2010, IEEE Transactions on Electromagnetic Compatibility.

[25]  Holmes,et al.  Pulse width modulation for power converters , 2003 .

[26]  P. Jain,et al.  The Application of the Cascaded Multilevel Converters in Grid Connected Photovoltaic Systems , 2007, 2007 IEEE Canada Electrical Power Conference.

[27]  Hui Li,et al.  A Cascaded Photovoltaic System Integrating Segmented Energy Storages With Self-Regulating Power Allocation Control and Wide Range Reactive Power Compensation , 2011, IEEE Transactions on Power Electronics.

[28]  Prasad Enjeti,et al.  Analysis of common mode voltage-"neutral shift" in medium voltage PWM adjustable speed drive (MV-ASD) systems , 2000 .

[29]  A.K. Gupta,et al.  A Space Vector Modulation Scheme to Reduce Common Mode Voltage for Cascaded Multilevel Inverters , 2007, IEEE Transactions on Power Electronics.

[30]  Hembram Mansing.  A Cascaded Inverter For Transformerless Single Phase Grid Connected Photovoltaic Systems , 2013 .

[31]  Leon M. Tolbert,et al.  Single-phase cascaded H-bridge multilevel inverter with nonactive power compensation for grid-connected photovoltaic generators , 2011, 2011 IEEE Energy Conversion Congress and Exposition.

[32]  R. Rizzo,et al.  A Sensorless Control of H-bridge Multilevel Converter for Maximum Power Point Tracking in Grid Connected Photovoltaic Systems , 2007, 2007 International Conference on Clean Electrical Power.

[33]  Hui Li,et al.  A coordinated active and reactive power control strategy for grid-connected cascaded photovoltaic (PV) system in high voltage high power applications , 2013, 2013 Twenty-Eighth Annual IEEE Applied Power Electronics Conference and Exposition (APEC).

[34]  Pablo Sanchis,et al.  Ground currents in single-phase transformerless photovoltaic systems , 2007 .

[35]  Baoming Ge,et al.  A modular multilevel space vector modulation for photovoltaic quasi-Z-source cascade multilevel inverter , 2013, 2013 Twenty-Eighth Annual IEEE Applied Power Electronics Conference and Exposition (APEC).

[36]  Baoming Ge,et al.  A new grid-connected PV system based on cascaded H-bridge quasi-Z source inverter , 2012, 2012 IEEE International Symposium on Industrial Electronics.

[37]  Leon M. Tolbert,et al.  Multilevel converters as a utility interface for renewable energy systems , 2000, 2000 Power Engineering Society Summer Meeting (Cat. No.00CH37134).